三元混合式绝缘油和矿物油的雷电冲击击穿及产气特性对比分析研究

doi:10.19595/j.cnki.1000-6753.tces.181956

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (39699 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Mixed insulation oil takes into account the advantages of mineral oil and natural ester, which has attracted wide attention from researchers at home and abroad. Taking mineral oil as control group, this paper studied the lightning impulse behaviors and gas production characteristics of a novel three-element mixed insulation oil under severe non-uniform electric field. The gap distance of needle-plate electrode structure was between 5mm and 25mm. The differences in breakdown voltage, discharge propagation velocity and gas production for two kinds of oils were analyzed under positive and negative lightning impulse voltages. The results show that the lightning impulse breakdown voltage of three-element mixed insulation oil is close to that of mineral oil under the positive lightning impulse. However, under the negative lightning impulse, the lightning impulse breakdown voltage of mineral oil is 1.5~3.5 times that of the three-element mixed insulation oil. The discharge propagation velocity of mineral oil is slightly faster than that of the three-element mixed insulation oil under both positive and negative lightning impulse voltages. With the increase of oil gap distance, the lightning impulse breakdown voltage and discharge propagation velocity show upward trend in different growth amplitudes, respectively. After the positive lightning impulse and negative lighting impulse have the same number breakdowns, the dissolved gas concentration in the three-element mixed insulation oil is significantly lower than that of mineral oil. Besides, the H2 and C₂H₂ can be used as the characteristic gases for the arc discharge analysis of three-element mixed insulation oil.

Key words： Three-element mixed insulation oil lightning impulse severe non-uniform electric field breakdown characteristic dissolved gas

Received: 26 December 2018 Published: 28 February 2020

PACS:

TM470.4037

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Chen Xin
	Hao Jian
	Feng Dawei
	Yang Lijun
	Liao Ruijin

Cite this article:

Chen Xin,Hao Jian,Feng Dawei等. Comparative Study on Lightning Impulse Breakdown and Gas Production Characteristics of Three-Element Mixed Insulation Oil and Mineral Oil[J]. Transactions of China Electrotechnical Society, 2020, 35(4): 906-918.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.181956 OR https://dgjsxb.ces-transaction.com/EN/Y2020/V35/I4/906

[1] Hamdi A, Fofana I, Djillali M.Stability of mineral oil and oil-ester mixtures under thermal ageing and electrical discharges[J]. IET Generation Transmission & Distribution, 2017, 11(9): 2384-2392.
[2] 崔鲁, 陈伟根, 杜劲超, 等. 植物油-纸绝缘气隙放电形态及发展特征[J]. 电工技术学报, 2018, 33(3): 618-626.
Cui Lu, Chen Weigen, Du Jinchao, et al.Investig- ation on air-gap discharge patterns and development characteristics of vegetable oil-paper insulation[J]. Transactions of China Electrotechnical Society, 2018, 33(3): 618-626.
[3] Rao U M, Sood Y R, Jarial R K.Oxidation stability enhancement of a blend of mineral and synthetic ester oils[J]. IEEE Electrical Insulation Magazine, 2016, 32(2): 43-47.
[4] Mehta D M, Kundu P, Chowdhury A, et al.A review on critical evaluation of natural ester vis-a-vismineral oil insulating liquid for use in transformers: part 1[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(2): 873-880.
[5] Martins M A G. Vegetable oils, an alternative tomineral oil for power transformers- experimental study of paper aging in vegetable oil versus mineral oil[J]. IEEE Electrical Insulation Magazine, 2010, 26(6): 7-13.
[6] 李剑, 姚舒瀚, 杜斌, 等. 植物绝缘油及其应用研究关键问题分析与展望[J]. 高电压技术, 2015, 41(2): 353-363.
Li Jian, Yao Shuhan, Du Bin, et al.Analysis to principle problems and future prospect of research on vegetable insulating oils and their applications[J]. High voltage engineering, 2015, 41(2): 353-363.
[7] Pukel G J, Fleck G, Pregartner H, et al.Safe and environmentally friendly large power transformers with ester successful introduction of ester liquids at the 420kV transmission level[C]//IEEE Electrical Insulation Conference(EIC), Montreal, QC, Canada, 2016: 134-137.
[8] 廖瑞金, 郭沛, 周年荣, 等. 新型抗老化混合油-纸板绝缘热老化特性[J]. 电工技术学报, 2015, 30(22): 222-230.
Liao Ruijin, Guo Pei, Zhou Nianrong, et al.The thermal aging characteristics of the new anti-aging mixed oil-pressboard insulation[J]. Transactions of China Electrotechnical Society, 2015, 30(22): 222-230.
[9] Fofana I, Wasserberg V, Borsi H, et al.Challenge of mixed insulating liquids for use in high-voltage transformers. Ⅰ. Investigation of mixed liquids[J]. Electrical Insulation Magazine IEEE, 2002, 18(3): 18-31.
[10] Fofana I, Wasserberg V, Borsi H, et al.Challenge of mixed insulating liquids for use in high-voltage transformers. Ⅱ. Investigations of mixed liquid impregnated paper insulation[J]. Electrical Insulation Magazine IEEE, 2002, 18(4): 5-16.
[11] Perrier C, Beroual A, Bessède J L.Improvement of power transformers by using mixtures of mineral oil with synthetic esters[J]. IEEE Transactions on Dielectrics & Electrical Insulation, 2006, 13(3): 556-564.
[12] 梁帅伟. 抗老化变压器油及其对绝缘纸热老化影响的研究[D]. 重庆: 重庆大学, 2009.
[13] 郭沛. 新型混合油-纸板绝缘的热老化特性及其在配电变压器中应用[D]. 重庆: 重庆大学, 2014.
[14] Rao U M, Sood Y R, Jarial R K.Performance analysis of alternate liquid dielectrics for power transformers[J]. IEEE Transactions on Dielectrics & Electrical Insulation, 2016, 23(4): 2475-2484.
[15] Abderrahmane Beroual, Henry B H Sitorus, Rudy Setiabudy, et al. Comparative study of AC and DC breakdown voltages in Jatropha methyl ester oil, mineral oil, and their mixtures[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2018, 25(5): 1831-1836.
[16] 林翔. 植物绝缘油长油隙雷电冲击放电特性研究[D]. 重庆: 重庆大学, 2017.
[17] 赵涛, 律方成, 刘云鹏, 等. 纤维素颗粒物对变压器油冲击击穿特性影响的试验研究[J]. 电工技术学报, 2018, 33(7): 1626-1633.
Zhao Tao, Lü Fangcheng, Liu Yunpeng, et, al. Experimental study of cellulose particles effect on impulse breakdown in transformer oil[J]. Transa- ctions of China Electrotechnical Society, 2018, 33(7): 1626-1633.
[18] Thien Y V, Azis N, Jasni J, et al.Pre-breakdown streamer propagation and breakdown characteristics of refined bleached and deodorized palm oil under lightning impulse voltage[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2018, 25(5): 1614-1620.
[19] 全国绝缘材料标准化技术委员会. GB/T 21222—2007 绝缘液体雷电冲击击穿电压测定方法[S]. 北京: 中国标准出版社, 2008.
[20] 王有元, 李熙, 李原龙, 等. 交直流复合电压下铜颗粒在油中的分布及对绝缘油击穿特性的影响[J]. 电工技术学报, 2018, 33(23): 5581-5590.
Wang Youyuan, Li Xi, Li Yuanlong, et al.Distri- bution of copper particle in insulating oil and its influence on breakdown strength of insulating oil under combined AC and DC voltage[J]. Transactions of China Electrotechnical Society, 2018, 33(23): 5581-5590.
[21] Beldjilali A, Idir O, Saidi-Amroun N, et al.Electrical and physicochemical properties and transient charging currents in mineral and vegetable oils mixtures[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2018, 25(5): 1739-1748.
[22] 李恩文, 王力农, 宋斌, 等. 基于改进模糊聚类算法的变压器油色谱分析[J]. 电工技术学报, 2018, 33(19): 4594-4602.
Li Enwen, Wang Linong, Song Bin, et al.Analysis of transformer oil chromatography based on improved fuzzy clustering algorithm[J]. Transactions of China Electrotechnical Society, 2018, 33(19): 4594-4602.
[23] 唐勇波, 熊印国. 基于二次维数约简的油中溶解气体浓度预测[J]. 电工技术学报, 2017, 32(21): 104-112.
Tang Yongbo, Xiong Yinguo.Prediction model for dissolved gases content in transformer oil based on twice dimensionality reduction[J]. Transactions of China Electrotechnical Society, 2017, 32(21): 104-112.
[24] 杜林, 王五静, 张彼德, 等. 基于ReaxFF场的矿物绝缘油热解分子动力学模拟[J]. 高电压技术, 2018, 44(2): 488-497.
Du Lin, Wang Wujing, Zhang Bide, et al.Molecular dynamics simulation of mineral insulating oil pyrolysis based on force field ReaxFF[J]. High Voltage Engineering, 2018, 44(2): 488-497.
[25] Xiang Chenmeng, Zhou Quan, Li Jian, et al.Com- parison of dissolved gases in mineral and vegetable insulating oils under typical electrical and thermal faults[J]. Energies, 2016, 9(5): 1-22.