新型抗老化混合油-纸板绝缘热老化特性

Abstract
Figure/Table
References (0)
Related Citation (15)

Download: PDF (15349 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract

In order to promote the application of mixed insulation oil in transformers, the preparation method of a new anti-aging mixed insulation oil with mass production has been developed. Then two kinds of oil-paper insulation samples were prepared with common insulation pressboard and insulation oil, namely new mixed insulation oil and mineral oil respectively. Accelerated aging experiments were performed under the 130℃ to analysis their dielectric properties, breakdown voltage and the general characteristics of aging products. The results show that: the properties of new mixed insulation oil meet the requirements of GB 2536—2011 and it can delay the aging process of oil-paper insulation system. The breakdown voltages of new mixed insulation oil and its impregnated insulation pressboard at different aging time are mostly higher than that of relevant mineral oil and its impregnated insulation pressboard respectively. With the increase of temperature,the breakdown voltages of two kinds of insulation pressboard at early aging time decrease while at later aging time decrease firstly and then increase. The relative dielectric constant and the ratio of relative dielectric constants of new mixed insulation oil and its impregnated insulation pressboard at different aging time are higher than that of relevant mineral oil and its impregnated insulation pressboard. This indicates that new mixed insulation oil improves the distribution uniformity of electric field in insulation oil and insulation pressboard, which is helpful to the miniaturization of transformer manufacturing.

Key words： New mixed insulation oil insulation pressboard thermal aging dielectric property breakdown voltage

Published: 30 November 2015

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Liao Ruijin
	Guo Pei
	Zhou Nianrong
	Xia Huanhuan
	Lin Yuandi
	Liu Haibin

Cite this article:

Liao Ruijin,Guo Pei,Zhou Nianrong等. The Thermal Aging Characteristics of the New Anti-Aging Mixed Oil-Pressboard Insulation[J]. Transactions of China Electrotechnical Society, 2015, 30(22): 222-230.

URL:

https://dgjsxb.ces-transaction.com/EN/ OR https://dgjsxb.ces-transaction.com/EN/Y2015/V30/I22/222

[1] 廖瑞金, 梁帅伟, 李剑, 等. 矿物油和天然酯混合绝缘油的理化特性和击穿电压研究[J]. 中国电机工程学报, 2009, 29(13): 117-123.
Liao Ruijin, Liang Shuaiwei, Li Jian, et al. Study on the physics and chemistry characteristics and breakdown voltage of a mixed insulation oil composed of mineral oil and natural easter[J]. Proceedings of the CSEE, 2009, 29(13): 117-123.
[2] 王世强, 魏建林, 杨双锁, 等. 油纸绝缘加速热老化的频域介电谱特性[J]. 中国电机工程学报, 2010, 30(34): 125-131.
Wang Shiqiang, Wei Jianlin, Yang Shuangsuo, et al. Frequency domain dielectric spectroscopy characte- ristics of oil-paper insulation under accelerated thermal aging[J]. Proceedings of the CSEE, 2010, 30(34): 125-131.
[3] 梁帅伟. 抗老化变压器油及其对绝缘纸热老化影响的研究[D]. 重庆: 重庆大学, 2009.
[4] Perrier C, Beroual A, Bessede J L. Improvement of power transformers by using mixtures of mineral oil with synthetic esters[J]. IEEE Transactions on Dielec- trics and Electrical Insulation, 2006, 13(3): 556-564.
[5] Fofana I, Wasserberg V, Borsi H, et al. Challenge of mixed insulating liquids for use in high-voltage transformers, Part 1: Investigation of mixed liquids[J]. IEEE Electrical Insulation Magazine, 2002, 18(4): 18-31.
[6] Fofana I, Wasserberg V, Borsi H, et al. Challenge of mixed insulating liquids for use in high-voltage transformers, Part 2: Investigations of mixed liquid impregnated paper insulation[J]. IEEE Electrical Insulation Magazine, 2002, 18(4): 5-16.
[7] 廖瑞金, 郝建, 梁帅伟, 等. 水分和酸对矿物油与天然酯混合油-纸绝缘热老化的影响[J]. 电工技术学报, 2010, 25(7): 31-37.
Liao Ruijin, Hao Jian, Liang Shuaiwei, et al. Influence of water and acid on the thermal aging of mineral oil mixed with natural ester oil-paper insulation[J]. Transac- tions of China Electrotechnical Society, 2010, 25(7): 31-37.
[8] 李晓虎, 李剑, 杜林, 等. 一种转基因菜籽绝缘油的电气性能[J]. 中国电机工程学报, 2006, 26(15): 95-99.
Li Xiaohu, Li Jian, Du Lin, et al. The electric properties of a transgenic vegetable oil[J]. Proceedings of the CSEE, 2006, 26(15): 95-99.
[9] 毕鹏翔, 张文元, 秦少臻, 等. 变压器固体绝缘状况的监测方法[J]. 高电压技术, 2000, 26(3): 47-51.
Bi Pengxiang, Zhang Wenyuan, Qin Shaozhen, et al. Methods for monitoring the condition of insulation in power transformers[J]. High Voltage Engineering, 2000, 26(3): 47-51.
[10] Emsley A M. Kinetics and mechanisms of degradation of cellulosic insulation in power transformers[J]. Polymer Degradation and Stability, 1994, 44(3): 343- 349.
[11] 刘玉仙. 变压器油纸绝缘的含湿分析及其对运行安全的影响[J]. 变压器, 2002, 39(5): 1-5.
Liu Yuxian. Moisture content analysis of oil-paper insulation in transformer and its influence on operation safety[J]. Transformer, 2002, 39(5): 1-5.
[12] 陈季丹, 刘子玉. 电介质物理学[M]. 北京: 机械工业出版社, 1988.
[13] 廖瑞金, 郝建, 杨丽君, 等. 变压器油纸绝缘频域介电特征量与绝缘老化状态的关系[J]. 电工技术学报, 2012, 27(5): 43-49.
Liao Ruijin, Hao Jian, Yang Lijun, et al. Relationship between frequency domain dielectric characteristic quantity and aging status of transformer oil-paper insulation[J]. Transactions of China Electrotechnical Society, 2012, 27(5): 43-49.
[14] 杨丽君, 廖瑞金, 孙会刚, 等. 变压器油纸绝缘热老化特性及特征量研究[J]. 电工技术学报, 2009, 24(8): 27-33.
Yang Lijun, Liao Ruijin, Sun Huigang, et al. Inves- tigation on properties and characteristics of oil-paper insulation in transformer during thermal degradation process[J]. Transactions of China Electrotechnical Society, 2009, 24(8): 27-33.
[15] Liao Ruijin, Hao Jian, Chen George, et al. A com- parative study of physicochemical, dielectric and thermal properties of pressboard insulation impregnated with natural ester and mineral oil[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2011, 18(5): 1626-1637.
[16] Suwarno, Darma I S. Dielectric properties of mixtures between mineral oil and natural ester from palm oil[J]. World Scientific and Engineering Academy and Society (WSEAS) Transactions on Power Systems, 2008, 3(2): 37-46.
[17] 唐超, 廖瑞金, 黄飞龙, 等. 电力变压器绝缘纸热老化的击穿电压特性[J]. 电工技术学报, 2010, 25(11): 1-8.
Tang Chao, Liao Ruijin, Huang Feilong, et al. The breakdown voltage of power transformer insulation paper after thermal aging[J]. Transactions of China Electrotechnical Society, 2010, 25(11): 1-8.