基于新型可重构拓扑的电池分层均衡方法

doi:10.19595/j.cnki.1000-6753.tces.250499

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (2885 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract With the global energy transition and rapid growth of the electric vehicle (EV) market, the second-life utilization of retired power batteries has become a critical pathway for constructing new energy storage systems. However, retired batteries often face issues such as significant capacity degradation, increased internal resistance, and low capacity utilization in battery packs during their second-life application. These issues are particularly challenging in idle (non-charging/discharging) conditions, where conventional balancing methods exhibit technical limitations. Thus, this paper proposes a hierarchical balancing method based on a novel reconfigurable topology.
Traditional reconfigurable topologies suffer from excessive switch numbers, reliance on DC-DC converters, and inadequate balancing under idle conditions. A new reconfigurable topology is introduced, adopting a hierarchical design featuring series/bypass connections between modules and split/parallel configurations within modules. Compared to conventional four-switch topologies, the proposed structure reduces the switch count by 12.5% and limits output voltage fluctuations to within 3% without additional DC-DC converters.
Subsequently, a hierarchical coordinated balancing strategy is proposed. This approach synergistically couples asymmetric PWM energy scheduling among outer modules with intra-module cell-level management techniques, i.e., splitting, recombining, and bypassing—within inner modules. Specifically, asymmetric PWM is used to redistribute energy between outer modules, reducing SOC differences and preventing circulating currents during charging and discharging. Within the inner modules, a capacity gradient splitting and cell bypassing method is applied to optimize the SOC differences, ensuring balance across the entire battery pack.
An RC circuit-based rapid balancing method is proposed for inner module balancing to overcome the limitations in balancing during idle periods of an energy storage system (ESS). The integration of the RC circuit with dynamic topology reconfiguration markedly amplified the inter-module voltage gradient, thereby expediting energy transfer between inner modules.
Finally, a reconfigurable battery experimental platform is built. In discharge scenarios, experimental results show that the proposed strategy reduces the SOC difference from 6.65% to within 0.5% in approximately 1 000 seconds, with output voltage remaining stable and voltage fluctuations below 3%. Under ESS idle conditions, the RC circuit-based balancing strategy quickly reduces SOC differences between inner modules to below 0.5%, and peak currents are strictly controlled within safe limits. The proposed topology and balancing strategy are verified.

Key words： Reconfigurable topology grid energy storage system battery balancing control hierarchical balancing method

Received: 28 March 2025

PACS:

TM912

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Zhou Juan
	Guo Zeyun
	Du Shimin
	Zhang Yonglei
	Pang Yufan

Cite this article:

Zhou Juan,Guo Zeyun,Du Shimin等. A Hierarchical Balancing Method for Batteries Based on a Novel Reconfigurable Topology[J]. Transactions of China Electrotechnical Society, 2026, 41(6): 2132-2145.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.250499 OR https://dgjsxb.ces-transaction.com/EN/Y2026/V41/I6/2132

[1] 程林, 索克兰, 许鹤麟. 新能源侧电池储能系统运行评价: 现状与展望[J]. 电力系统自动化, 2025, 49(15): 1-19.
Cheng Lin, Suo Kelan, Xu Helin.Operation evaluation of battery energy storage systems at renewable energy side: current status and prospects[J]. Automation of Electric Power Systems, 2025, 49(15): 1-19.
[2] 姬鹏, 吕泽旭. 考虑温度及老化的储能用锂离子电池组荷电状态估算算法[J]. 电工技术学报, 2025, 40(17): 5667-5682.
Ji Peng, Lü Zexu.SOC estimation algorithm of lithium-ion battery pack for energy storage considering temperature and aging[J]. Transactions of China Electrotechnical Society, 2025, 40(17): 5667-5682.
[3] 毛路, 赵文元, 王越, 等. 锂离子电池快充-均衡双层优化控制方法[J]. 电工技术学报, 2025, 40(19): 6395-6406.
Mao Lu, Zhao Wenyuan, Wang Yue, et al.Double layer optimal control method of fast charge equalization for lithium ion batteries[J]. Transactions of China Electrotechnical Society, 2025, 40(19): 6395-6406.
[4] 蔡敏怡, 张娥, 林靖, 等. 串联锂离子电池组均衡拓扑综述[J]. 中国电机工程学报, 2021, 41(15): 5294-5311.
Cai Minyi, Zhang E, Lin Jing, et al.Review on balancing topology of lithium-ion battery pack[J]. Proceedings of the CSEE, 2021, 41(15): 5294-5311.
[5] 孙玉巍, 付超, 李永刚, 等. 用于电池储能系统的级联式电力电子变压器均衡及协调控制[J]. 电力系统自动化, 2018, 42(18): 123-130.
Sun Yuwei, Fu Chao, Li Yonggang, et al.Balancing and coordinated control of cascaded power electronic transformers for battery energy storage system[J]. Automation of Electric Power Systems, 2018, 42(18): 123-130.
[6] 阮观强, 曹金良, 符啸宇, 等. 主被动均衡电池管理系统设计[J]. 科学技术与工程, 2023, 23(34): 14609-14617.
Ruan Guanqiang, Cao Jinliang, Fu Xiaoyu, et al.Design of active and passive balanced battery management system[J]. Science Technology and Engineering, 2023, 23(34): 14609-14617.
[7] 郭向伟, 王晨, 钱伟, 等. 电池储能系统均衡方法研究综述[J]. 电工技术学报, 2024, 39(13): 4204-4225.
Guo Xiangwei, Wang Chen, Qian Wei, et al.A review of equalization methods for battery energy storage system[J]. Transactions of China Electrotechnical Society, 2024, 39(13): 4204-4225.
[8] Xu Jun, Cao Binggang, Wang Junping.A novel method to balance and reconfigure series-connected battery strings[J]. Energies, 2016, 9(10): 766.
[9] 慈松, 张从佳, 刘宝昌, 等. 动态可重构电池储能技术: 原理与应用[J]. 储能科学与技术, 2023, 12(11): 3445-3455.
Ci Song, Zhang Congjia, Liu Baochang, et al.Dynamic reconfigurable battery energy storage technology: principle and application[J]. Energy Storage Science and Technology, 2023, 12(11): 3445-3455.
[10] 陈思哲, 王玉乐, 陶以彬, 等. 基于纵横交叉优化的可重构电池组环流抑制策略[J]. 电网技术, 2022, 46(1): 165-174.
Chen Sizhe, Wang Yule, Tao Yibin, et al.Circulation suppression strategy for reconfigurable battery packs based on crisscross optimization[J]. Power System Technology, 2022, 46(1): 165-174.
[11] 尹镨. 基于可重构拓扑的锂离子电池组高效主动均衡技术研究[D]. 西安: 长安大学, 2023.
Yin Pan.Research on efficient active equalization technology of lithium-ion batteries based on reconfigurable topology[D]. Xi’an: Chang'an University, 2023.
[12] 张婷婷, 纪锋. 无DC-DC变换器的稳压均衡电路[J]. 电力电容器与无功补偿, 2023, 44(2): 117-123.
Zhang Tingting, Ji Feng.Voltage stabilization equalization circuit without DC-DC converter[J]. Power Capacitor & Reactive Power Compensation, 2023, 44(2): 117-123.
[13] 任子豪, 田恩刚. 基于两级均衡电路的电池组智能均衡方法[J]. 电子科技, 2024, 37(7): 9-15.
Ren Zihao, Tian Engang.Intelligent equalization method for battery packs based on a two-level equalization circuit[J]. Electronic Science and Technology, 2024, 37(7): 9-15.
[14] 黄薛, 王友仁, 徐智童. 可重构电池技术研究综述[J]. 机械制造与自动化, 2019, 48(1): 219-221, 224.
Huang Xue, Wang Youren, Xu Zhitong.Review of researching on reconfigurable battery technology[J]. Machine Building & Automation, 2019, 48(1): 219-221, 224.
[15] Zhu Yu, Zhang Wuyang, Cheng Jun, et al.A novel design of reconfigurable multicell for large-scale battery packs[C]//2018 International Conference on Power System Technology (POWERCON), Guangzhou, China, 2018: 1445-1452.
[16] 于仲安, 张军令, 陈可怡. 基于GA-ELM的锂电池SOC估计及主动均衡[J]. 电气工程学报, 2024, 19(1): 326-333.
Yu Zhongan, Zhang Junling, Chen Keyi.SOC estimation and active equalization of lithium battery based on GA-ELM[J]. Journal of Electrical Engineering, 2024, 19(1): 326-333.
[17] 徐鹏, 康龙云, 万蕾, 等. 一种均衡阈值可调的双模式电池均衡电路[J]. 电机与控制学报, 2023, 27(10): 96-107.
Xu Peng, Kang Longyun, Wan Lei, et al.Two-mode cell balancing circuit with adjustable balancing threshold[J]. Electrical Machines and Control, 2023, 27(10): 96-107.
[18] 刘剑锋, 龚仁喜, 张圆圆. 一种非对称级联H桥三相逆变器的功率均衡混合随机脉宽调制方法[J]. 电工技术学报, 2024, 39(24): 7807-7820.
Liu Jianfeng, Gong Renxi, Zhang Yuanyuan.A power-balanced hybrid random pulse width modulation method for asymmetric cascaded H-bridge three-phase inverter[J]. Transactions of China Electrotechnical Society, 2024, 39(24): 7807-7820.
[19] 崔皓勇, 魏中宝, 何洪文. 基于动态可重构的智能电池容量最大化利用[C]//第23届中国系统仿真技术及其应用学术年会, 合肥, 2022: 238-244.
Cui Haoyong, Wei Zhongbao, He Hongwen.Dynamic reconfiguration-enabled capacity maximum utilization of smart battery[C]//23rd The IEEE-China Conference on System Simulation Technology and its Application (CCSSTA), Hefei, 2022: 238-244.
[20] Wang Yichen, Zhang Bao, Wu Yanze, et al.A lightload optimization method for CLLC resonant converters based on asymmetric PWM control strategy[C]// 2024 3rd Asia Power and Electrical Technology Conference (APET), Fuzhou, China, 2024: 181-186.
[21] 张旭阳, 许锋, 周华, 等. 串联电池组模块化分层主动均衡方法研究[J/OL]. 电源学报, 2024, https:// link.cnki.net/urlid/12.1420.TM.20240426.1418.078.
Zhang Xuyang, Xu Feng, Zhou Hua, et al. Modular layered active equalization method for series battery pack[J/OL]. Journal of Power Supply, 2024, https:// link.cnki.net/urlid/12.1420.TM.20240426.1418.078.
[22] 李艳波, 马海涛, 程绍峰, 等. 结合CUK电路与单电感电路的电池均衡分层研究[J/OL]. 电源学报, 2023, https://link.cnki.net/urlid/12.1420.TM.20231213.1351.003.
Li Yanbo, Ma Haitao, Cheng Shaofeng, et al. Balanced stratification of batteries combining CUK circuit and single inductor circuit[J/OL]. Journal of Power Supply, 2023, https://link.cnki.net/urlid/12.1420.TM.20231213.1351.003.
[23] Daowd M, Antoine M, Omar N, et al.Single switched capacitor battery balancing system enhancements[J]. Energies, 2013, 6(4): 2149-2174.
[24] 姚芳, 王晓鹏, 陈盛华, 等. 基于Buck-Boost准谐振电路的电池自适应分组均衡方案研究[J]. 中国电机工程学报, 2023, 43(2): 714-727.
Yao Fang, Wang Xiaopeng, Chen Shenghua, et al.Research on battery adaptive grouping equalization scheme based on Buck-Boost quasi-resonant circuit[J]. Proceedings of the CSEE, 2023, 43(2): 714-727.
[25] 王鹿军, 柯锦洋, 詹敏, 等. 基于四管双向变换器的退役电池组有源快速均衡方法[J]. 中国电机工程学报, 2022, 42(14): 5254-5266.
Wang Lujun, Ke Jinyang, Zhan Min, et al.Active fast equalization method for retired battery pack based on four switch bidirectional converter[J]. Proceedings of the CSEE, 2022, 42(14): 5254-5266.