消除EMI噪声影响的电机驱动系统噪声源阻抗提取方法

doi:10.19595/j.cnki.1000-6753.tces.242126

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (3784 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The extraction of noise source impedance in motor drive systems is essential for designing high-performance EMI filters with high insertion loss and evaluating the operational status of the systems. The high-frequency electromagnetic interference (EMI) noises generated by the fast on-off of the power switching component in the motor drive system significantly affect the accuracy of extracting the noise source impedance. Existing methods need additional measurement equipment, which increases the hardware costs and measurement complexity. Thus, this paper proposes an extraction method without additional hardware equipment.
Firstly, the noise source performances and EMI noise paths in the motor drive system are analyzed. The extraction mechanism of noise source impedance for a motor drive system by inductive coupling is studied. Then, a noise source impedance extraction model considering the influences of EMI noise generated by the motor drive system is built. At the same time, a relative error model of the noise source impedance extraction is constructed to evaluate the influence of EMI noise on impedance extraction accuracy. The impact of signal-to-noise ratio and the turns around the probe on the error percentage is studied. With the increase in signal-to-noise ratio and the turns around the probe, the relative error decreases, and the influence of EMI noise on source impedance extraction is reduced. An EMI noise source impedance extraction method is proposed for motor drive systems. The proposed method can extract the noise source impedance only through two measurements without obtaining the EMI noise spectrum in the motor drive system.
The experimental results show that the noise source impedance extracted by the proposed method can effectively eliminate the influence of EMI noise generated by the motor drive system without measuring the EMI noise. Still, it can get the noise source impedance by twice scattering-parameter measurements with injecting swept-frequency small signals under different power levels. Compared with the existing method, which increases the signal-to-noise ratio with an external amplifier, the proposed method is low-cost and straightforward without additional hardware.
Compared with the existing noise source impedance extraction method, the proposed method can eliminate the influence of EMI noise generated by motor drive systems. The proposed method does not introduce additional hardware and has strong practicality. In addition, the proposed method helps design high-performance EMI filters for monitoring the operating state of the motor drive system.

Key words： Impedance extraction noise source impedance inductive coupling method motor drive system electromagnetic interference

Received: 27 November 2024

PACS:

TM464

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Ji Junpeng
	Wang Ruina
	Yang Hui
	Lu Jingjie
	Luo Peng

Cite this article:

Ji Junpeng,Wang Ruina,Yang Hui等. Extraction Method of Noise Source Impedance of Motor Drive System with Eliminating EMI Noise Influence[J]. Transactions of China Electrotechnical Society, 2025, 40(19): 6213-6222.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.242126 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I19/6213

[1] 夏衍, 孙立鹏, 李军伟, 等. 基于三状态PWM的电动汽车电机驱动系统多模式调制策略研究[J]. 电工技术学报, 2024, 39(4): 1010-1021.
Xia Yan, Sun Lipeng, Li Junwei, et al.Research on multi-mode modulation strategy of motor drive system based on tri-state PWM in EV[J]. Transactions of China Electrotechnical Society, 2024, 39(4): 1010-1021.
[2] 赵丹, 申科, 刘卫国, 等. 基于级联多模块的永磁同步电机驱动系统传导EMI建模与预测[J]. 中国电机工程学报, 2022, 42(12): 4603-4612.
Zhao Dan, Shen Ke, Liu Weiguo, et al.Cascaded multi-module based conducted EMI modeling and prediction method for permanent magnet synchronous motor drive system[J]. Proceedings of the CSEE, 2022, 42(12): 4603-4612.
[3] 徐浩东, 罗嗣勇, 毕闯, 等. 基于SiC MOSFET同步Buck DC-DC变换器的宽频混合EMI滤波器设计[J]. 电工技术学报, 2024, 39(10): 3060-3069.
Xu Haodong, Luo Siyong, Bi Chuang, et al.Design of broadband hybrid EMI filter in synchronous Buck DC-DC converter with SiC MOSFETs[J]. Transa-ctions of China Electrotechnical Society, 2024, 39(10): 3060-3069.
[4] 迟连强, 张殿海, 赵俊清, 等. 旋转电机轴承电蚀损伤机理与缓解措施研究进展[J]. 电工技术学报, 2024, 39(20): 6409-6430.
Chi Lianqiang, Zhang Dianhai, Zhao Junqing, et al.Research progress on the mechanism and mitigation measure of electrical corrosion damage in rotating motor bearings[J]. Transactions of China Electro-technical Society, 2024, 39(20): 6409-6430.
[5] Park C, Lee H, Zapico M O, et al.Automated testing for early identification of PD in the stator insulation of low voltage VFD motors[J]. IEEE Transactions on Industry Applications, 2023, 59(4): 3910-3919.
[6] 马世金, 王鹏, 朱英伟, 等. 变频电机匝间绝缘故障放电信号电磁辐射特性研究[J]. 电工技术学报, 2023, 38(22): 5975-5986.
Ma Shijin, Wang Peng, Zhu Yingwei, et al.Elec-tromagnetic radiation characteristics of partial dis-charge in inverter-fed motor turn-turn insulation[J]. Transactions of China Electrotechnical Society, 2023, 38(22): 5975-5986.
[7] Zhang Boyi, Wang Shuo, Lai Yanwen, et al.Mode-ling and prediction of low-frequency radiated EMI for a SiC motor drive system[J]. IEEE Transactions on Industrial Electronics, 2024, 71(9): 10210-10220.
[8] 江师齐, 刘艺涛, 银杉, 等. 基于噪声源阻抗提取的单相逆变器电磁干扰滤波器的设计[J]. 电工技术学报, 2019, 34(17): 3552-3562.
Jiang Shiqi, Liu Yitao, Yin Shan, et al.Electro-magnetic interference filter design of single-phase inverter based on the noise source impedance extraction[J]. Transactions of China Electrotechnical Society, 2019, 34(17): 3552-3562.
[9] Fan Fei, See K Y, Liu Xiong, et al.Systematic common-mode filter design for inverter-driven motor system based on in-circuit impedance extraction[J]. IEEE Transactions on Electromagnetic Compatibility, 2020, 62(5): 1711-1722.
[10] Liu Yitao, Ye Xin, Peng Jianchun.EMI filter design for single-phase grid-connected inverter with noise source impedance consideration[J]. IET Power Elec-tronics, 2020, 13(17): 3963-3974.
[11] Zhao Zhenyu, Fan Fei, Wang Wensong, et al.Detection of stator interturn short-circuit faults in inverter-fed induction motors by online common-mode impedance monitoring[J]. IEEE Transactions on Instrumentation and Measurement, 2021, 70: 3513110.
[12] Zhao Zhenyu, Chua E K, Svimonishvili T, et al.Current collector health monitoring of LRT trains powered by three-phase AC power rail based on inductive coupling method[J]. IEEE Transactions on Industrial Electronics, 2024, 71(3): 3103-3112.
[13] Chen Henglin, Yan Yunfan, Zhao Huan.Extraction of common-mode impedance of an inverter-fed indu-ction motor[J]. IEEE Transactions on Electromagnetic Compatibility, 2016, 58(2): 599-606.
[14] Shang Xiaofan, Su Donglin, Xu Hui, et al.A noise source impedance extraction method for operating SMPS using modified LISN and simplified calibration procedure[J]. IEEE Transactions on Power Elec-tronics, 2017, 32(6): 4132-4139.
[15] 张佳佳, 张逸成, 韦莉, 等. 基于插入损耗的噪声源阻抗修正计算方法[J]. 电工技术学报, 2015, 30(4): 80-87.