高效宽范围四开关Buck-Boost变换器纹波-变频控制策略

doi:10.19595/j.cnki.1000-6753.tces.240865

Abstract
Figure/Table
References
Related Citation (14)

Download: PDF (8972 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Recently, the bus voltage of data center power architectures has been gradually increased from the traditional 12 V to 48 V to reduce the current in the distribution lines, thus reducing distribution losses. In 48 V bus-powered architectures, the uninterruptible power supply (UPS) system is connected in parallel with the 48 V bus, which causes the bus voltage to fluctuate over a wide range (40 V to 60 V). To better manage the bus voltage and energy flow, a bidirectional DC-DC converter must be inserted between the UPS and power-using systems. The four-switch Buck-Boost converter is attractive because of its high efficiency and wide voltage regulation capability. In order to reduce the energy consumption in data centers, it becomes crucial to improve the efficiency of FSBB.
This paper analyzes the voltage gain of the FSBB converter. Then, a graphical approach compares the control strategies of the FSBB converter. The unimodal control strategy has large ripples. The bimodal control strategy system is unstable. Tri-modal solves the problems of duty cycle limitation and system stability, but the duty cycle varies greatly when the transition mode is switched. Four-mode control can add a control mode in the transition section to realize smooth conversion between different modes, and the ripple of inductor current is small. It is a control strategy with excellent performance.
Then, the minimum ripple condition of the inductor current is analyzed based on four-mode control. The inductor current ripple of the FSBB converter is minimized when the phase shift time between the Buck and Boost bridge arms is controlled to zero. The average value of the inductor current is related to the output voltage, input voltage, maximum duty cycle, and output current, and it is almost the same for all four-mode control strategies. Therefore, the control method to minimize the inductor current can be obtained by simultaneously controlling the phase shift time to zero.
Next, an accurate loss model of the FSBB converter is developed. When the voltage gain is constant, the loss of the converter increases as the load current increases. When the load is fixed, the lower the switching frequency, the lower the loss. Under the same load conditions, if the voltage gain is greater than 1, the loss decreases with the gradual increase of the gain at the same switching frequency until the loss is minimized when the voltage gain equals 1. On the contrary, if the voltage gain is less than 1, the loss gradually decreases as the gain gradually increases. Thus, this paper proposes a frequency reduction control strategy to reduce the converter loss in the transition mode and improve the conversion efficiency by reducing the switching.
Finally, an experimental platform is established to test the inverter control strategy for the FSBB converter in steady states. The minimum ripple control strategy is then validated. The results show that the transition mode’s inductor current ripple with the proposed control strategy is much smaller than the conventional four-mode control strategy. Among them, the inductor current ripple of the proposed minimum ripple control strategy is 35.2% of the conventional control strategy under the operating conditions of 51 V input voltage and 48 V output voltage. After reducing the switching frequency, the inductor current ripple of the minimum ripple control strategy is still smaller than that of the conventional control strategy. The efficiency of the proposed low ripple inverter control strategy is improved over the whole load variation range compared with the traditional fixed frequency control. Among them, the peak efficiency of the proposed inverter control strategy reaches 98.52% and full-load efficiency 98.4%, which is improved by 2.46% and 2.35% compared to the conventional scheme, respectively.

Key words： Four-switch Buck-Boost converter multimodal control frequency reduction control high efficiency

Received: 24 May 2024

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Wu Jiarui
	Yang Xu
	Wang Daoxi
	Wang Kangping
	Chen Wenjie

Cite this article:

Wu Jiarui,Yang Xu,Wang Daoxi等. Low Ripple-Variable Frequency Control Strategy for High Efficiency Wide Range Four-Switch Buck-Boost Converter[J]. Transactions of China Electrotechnical Society, 2025, 40(10): 3236-3250.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.240865 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I10/3236

[1] 李金雨, 宋福龙, 马俊杰, 等. 基于5G基站可调度潜力与配电网集群划分的储能选址定容方法[J]. 电力系统自动化, 2023, 47(18): 151-160.
Li Jinyu, Song Fulong, Ma Junjie, et al.Siting and sizing method for energy storage based on dis- patchable potential of 5G base station and cluster partition of distribution network[J]. Automation of Electric Power Systems, 2023, 47(18): 151-160.
[2] 张玉莹, 曾博, 周吟雨, 等. 碳减排驱动下的数据中心与配电网交互式集成规划研究[J]. 电工技术学报, 2023, 38(23): 6433-6450.
Zhang Yuying, Zeng Bo, Zhou Yinyu, et al.Research on interactive integration planning of data centers and distribution network driven by carbon emission reduction[J]. Transactions of China Electrotechnical Society, 2023, 38(23): 6433-6450.
[3] 刘树林, 王斌, 朱高中, 等. 基于开关电感的二次型Buck-Boost变换器[J]. 电工技术学报, 2022, 37(增刊1): 190-197.
Liu Shulin, Wang Bin, Zhu Gaozhong, et al.Quadratic Buck-Boost converter based on switching inductance[J]. Transactions of China Electrotechnical Society, 2022, 37(S1): 190-197.
[4] 倪硕, 吴红飞, 陈君雨, 等. 交错并联临界导通模式Buck电感高密度集成与优化[J]. 电工技术学报, 2022, 37(18): 4688-4696.
Ni Shuo, Wu Hongfei, Chen Junyu, et al.Integration and optimization of a high power density inductor for an interleaved critical conduction mode Buck con- verter[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4688-4696.
[5] Baek J, Elasser Y, Radhakrishnan K, et al.Vertical stacked LEGO-PoL CPU voltage regulator[J]. IEEE Transactions on Power Electronics, 2022, 37(6): 6305-6322.
[6] Ahmed M H, Nabih A, Lee F C, et al.Low-loss integrated inductor and transformer structure and application in regulated LLC converter for 48-V bus converter[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2020, 8(1): 589-600.
[7] Akar F, Tavlasoglu Y, Ugur E, et al.A bidirectional nonisolated multi-input DC-DC converter for hybrid energy storage systems in electric vehicles[J]. IEEE Transactions on Vehicular Technology, 2016, 65(10): 7944-7955.
[8] Zhou Dehong, Wang Jiangfeng, Hou Nie, et al.Dual- port inverters with internal DC-DC conversion for adjustable DC-link voltage operation of electric vehicles[J]. IEEE Transactions on Power Electronics, 2021, 36(6): 6917-6928.
[9] Kasper M, Bortis D, Kolar J W.Classification and comparative evaluation of PV panel-integrated DC-DC converter concepts[J]. IEEE Transactions on Power Electronics, 2014, 29(5): 2511-2526.
[10] 任林涛, 汪飞, 肖杨婷, 等. 四开关Buck-Boost变换器研究综述[J]. 电气工程学报, 2023, 18(2): 52-69.
Ren Lintao, Wang Fei, Xiao Yangting, et al.Review research on the four-switch Buck-Boost converter[J]. Journal of Electrical Engineering, 2023, 18(2): 52-69.
[11] 周国华, 邱森林, 张小兵. 宽增益高效率级联式四开关Buck-Boost LLC变换器[J]. 电工技术学报, 2024, 39(4): 1103-1115.
Zhou Guohua, Qiu Senlin, Zhang Xiaobing.Cascaded four-switch Buck-Boost LLC converter with wide gain range and high efficiency[J]. Transactions of China Electrotechnical Society, 2024, 39(4): 1103-1115.
[12] Zhou Zongjie, Li Haiyan, Wu Xinke.A constant frequency ZVS control system for the four-switch Buck-Boost DC-DC converter with reduced inductor current[J]. IEEE Transactions on Power Electronics, 2019, 34(7): 5996-6003.
[13] 祁静静, 吴学智, 王久和, 等. 采用开关电感的Buck变换器CCM和DCM特性分析[J]. 电工技术学报, 2022, 37(16): 4155-4168.
Qi Jingjing, Wu Xuezhi, Wang Jiuhe, et al.Characteristics analysis of Buck converter with switched inductor in CCM and DCM[J]. Transactions of China Electrotechnical Society, 2022, 37(16): 4155-4168.
[14] 刘琦, 时雷雷, 徐奇, 等. 四开关升降压变换器高效控制策略研究与设计[J/OL]. 中国电机工程学报: 1-13 [2024-03-25]. https://doi.org/10.13334/j.0258-8013.pcsee.231719.
Liu Qi,Shi Leilei,Xu Qi, et al. Research and design of high-efficiency control strategy for four-switch lift-voltage converter[J/OL]. Chinese Journal of Elec- trical Engineering: 1-13 [2024-03-25]. https://doi.org/10.13334/j.0258-8013.pcsee.231719.
[15] 刘述喜, 邓瑞祥, 郭强, 等. 一种四开关Buck-boost变换器的模糊控制策略[J/OL]. 电气工程学报, 2023: 1-9.(2023-11-16).https://kns.cnki.net/kcms/detail/10.1289.TM.20231115.0953.004.html.
Liu Shuxi, Deng Ruixiang, Guo Qiang, et al. A fuzzy control strategy for four-switch Buck-Boost con- verter[J/OL]. Journal of Electrical Engineering, 2023: 1-9.(2023-11-16).https://kns.cnki.net/kcms/detail/10.1289.TM.20231115.0953.004.html.
[16] Fang Jie, Ruan Xinbo, Huang Xinze, et al.A PWM plus phase-shift control for four-switch Buck-Boost converter to achieve ZVS in full input voltage and load range[J]. IEEE Transactions on Industrial Electronics, 2022, 69(12): 12698-12709.
[17] Tian Lin, Wu Xinke, Jiang Congrang, et al.A simplified real-time digital control scheme for ZVS four-switch Buck-Boost with low inductor current[J]. IEEE Transactions on Industrial Electronics, 2022, 69(8): 7920-7929.
[18] Callegaro L, Ciobotaru M, Pagano D J, et al.A simple smooth transition technique for the noninverting Buck-Boost converter[J]. IEEE Transactions on Power Electronics, 2018, 33(6): 4906-4915.
[19] 康家玉, 陈旭阳, 刘甲琛, 等. 基于四开关Buck- Boost的三模式平滑切换控制策略[J]. 科学技术与工程, 2019, 19(33): 193-199.
Kang Jiayu, Chen Xuyang, Liu Jiachen, et al.Research on three-mode smooth switching control strategy based on four switch Buck-Boost[J]. Science Technology and Engineering, 2019, 19(33): 193-199.
[20] 曹以龙, 朱冬冬, 吴丹. 基于三模控制的四开关变换器设计[J]. 电源技术, 2021, 45(5): 665-668.
Cao Yilong, Zhu Dongdong, Wu Dan.Design of four-switch converter based on three-mode control[J]. Chinese Journal of Power Sources, 2021, 45(5): 665-668.
[21] 李山, 宋立风, 章治国. 四开关Buck-Boost变换器的三模式控制方法研究[J]. 电源学报, 2019, 17(3): 111-119.
Li Shan, Song Lifeng, Zhang Zhiguo.Study on three- mode control method for four-switch Buck-Boost converter[J]. Journal of Power Supply, 2019, 17(3): 111-119.
[22] 王红斌, 陈奥博, 薛云涛, 等. 基于图形化方法的四开关Buck-Boost变换器模式平滑切换策略研究[J/OL]. 电源学报, 2023: 1-14.(2023-03-09).https://kns.cnki.net/kcms/detail/12.1420.TM.20230309.0948.002.html.
Wang Hongbin, Chen Aobo, Xue Yuntao, et al. Research on smooth mode transition strategy of FSBB converter based on graphical method[J/OL]. Journal of Power Supply, 2023: 1-14.(2023-03-09).https:// kns.cnki.net/kcms/detail/12.1420.TM.20230309.0948.002.html.
[23] Ren Xiaoyong, Ruan Xinbo, Qian Hai, et al.Three- mode dual-frequency two-edge modulation scheme for four-switch Buck-Boost converter[J]. IEEE Transactions on Power Electronics, 2009, 24(2): 499-509.
[24] 曹以龙, 吴丹, 朱冬冬, 等. 一种基于四开关Buck- Boost变换器的四模式控制策略[J]. 电源学报, 2022, 20(5): 111-118.
Cao Yilong, Wu Dan, Zhu Dongdong, et al.Four- mode control strategy based on four-switch Buck- Boost converter[J]. Journal of Power Supply, 2022, 20(5): 111-118.
[25] 李慧慧, 皇金锋. 单电感双输出Buck-Boost变换器的非最小相位特性分析及控制策略[J]. 电工技术学报, 2023, 38(14): 3875-3887.
Li Huihui, Huang Jinfeng.Analysis of non-minimum phase characteristics and control strategies for single- inductor dual-output Buck-Boost converters[J]. Transa- ctions of China Electrotechnical Society, 2023, 38(14): 3875-3887.
[26] Zhang Neng, Zhang Guidong, See K W.Systematic derivation of dead-zone elimination strategies for the noninverting synchronous Buck-Boost converter[J]. IEEE Transactions on Power Electronics, 2018, 33(4): 3497-3508.
[27] 樊靖轩, 施佳楠, 徐子梁, 等. 基于GaN的开关线性复合高速随动脉冲负载直流变换器[J]. 电工技术学报, 2024, 39(6): 1818-1829.
Fan Jingxuan, Shi Jianan, Xu Ziliang, et al.GaN- based switched linear composite high-speed follow-up pulse load DC converter[J]. Transactions of China Electrotechnical Society, 2024, 39(6): 1818-1829.