图腾柱双有源桥AC-DC变换器的非对称扩展移相优化调制策略

doi:10.19595/j.cnki.1000-6753.tces.240510

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (7325 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The single-stage Totem pole dual active bridge (DAB) AC-DC converter has the advantages of low component count, high power density, and low cost, which has a broad application prospect in the field of on-board chargers (OBC). However, in the available research, the traditional single phase shift (SPS) and extended phase shift (EPS) modulation strategies are unable to optimize the quality of grid-connected current and efficiency of the Totem pole DAB AC-DC converter at the same time due to the problem of insufficient modulation degrees of freedom, limiting the further application in on-board chargers.
This paper introduces the asymmetric modulation based on the extended phase shift modulation strategy when the duty cycle of the secondary side switching tubes is no longer 50%. An asymmetric extended phase shift (AEPS) modulation strategy with three degrees of freedom is proposed. Accordingly, a multi-objective optimal modulation strategy is solved by considering the simultaneous optimization of the grid-connected current quality and efficiency of the Totem pole DAB AC-DC converter.
Firstly, the steady-state analytical model of AEPS modulation is established by using the time domain analysis method. The initial value decoupling constraint of the inductor current is considered to optimize the quality of grid-connected current, and the peak-to-peak inductor current is taken as the optimization objective. According to the Lagrange algorithm and Karush Kuhn Tucker conditions, the above multi-objective optimization problem is transformed into mathematical equations to solve the optimization solution of modulation variables. Matlab simulations show that the inductor current’s initial value decoupling and peak-to-peak value optimization are realized under the AEPS optimization modulation strategy. Compared with the SPS and EPS modulation, the proposed AEPS optimization modulation strategy reduces the peak-to-peak and RMS levels of the inductor current in the full power band, which reduces the conduction loss of the converter. Moreover, the optimized solutions in different operating modes under APES modulation are continuous, making seamless switching between different operating modes available.
An experimental prototype of a totem pole DAB AC-DC converter with a rated power of 800 W is constructed. Experimental results show that the converter achieves a peak efficiency of 93.5% under the proposed AEPS optimized modulation strategy, 5% and 14.7% higher than the SPS strategy at full load and light load, respectively; 1.5% and 14.7% higher than the EPS modulation strategy at full load and light load, respectively. The converter's grid-connected current THD is significantly reduced in the full power range, improving its grid-connected current quality. Simulation and experimental results verify the effectiveness of the proposed AEPS-optimized modulation strategy.

Key words： Totem pole dual active bridge (DAB) AC-DC converter asymmetric extended phase shift (EPS) modulation power factor correction modulation strategy optimization

Received: 01 April 2024

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Yu Chengyang
	Li Jia
	Yan Yipeng
	Mou Di
	Luo Quanming

Cite this article:

Yu Chengyang,Li Jia,Yan Yipeng等. Asymmetric Extended Phase Shift Optimized Modulation Strategy for Totem Pole Dual Active Bridge AC-DC Converter[J]. Transactions of China Electrotechnical Society, 2025, 40(8): 2560-2572.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.240510 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I8/2560

[1] Yilmaz M, Krein P T.Review of battery charger topologies, charging power levels, and infrastructure for plug-in electric and hybrid vehicles[J]. IEEE Transactions on Power Electronics, 2013, 28(5): 2151-2169.
[2] 晏益朋, 余城洋, 熊露婧, 等. 一种基于离散时域模型的单相PWM整流器控制参数多目标优化设计方法[J]. 电工技术学报, 2024, 39(1): 206-216.
Yan Yipeng, Yu Chengyang, Xiong Lujing, et al.A multi-objective controller parameter design optimi-zation method of single-phase PWM rectifierwith discrete-time domain model[J]. Transactions of China Electrotechnical Society, 2024, 39(1): 206-216.
[3] Li Bin, Li Qiang, Lee F C, et al.A high-efficiency high-density wide-bandgap device-based bidirectional on-board charger[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2018, 6(3): 1627-1636.
[4] Wang Huai, Blaabjerg F.Reliability of capacitors for DC-link applications in power electronic converters-an overview[J]. IEEE Transactions on Industry Applications, 2014, 50(5): 3569-3578.
[5] Jeong Y S, Lee S H, Jeong S G, et al.High-efficiency bidirectional grid-tied converter using single power conversion with high-quality grid current[J]. IEEE Transactions on Industrial Electronics, 2017, 64(11): 8504-8513.
[6] Everts J, Krismer F, Van den Keybus J, et al. Optimal ZVS modulation of single-phase single-stage bidire-ctional DAB AC-DC converters[J]. IEEE Transa-ctions on Power Electronics, 2014, 29(8): 3954-3970.
[7] Weise N D, Castelino G, Basu K, et al.A single-stage dual-active-bridge-based soft switched AC-DC con-verter with open-loop power factor correction and other advanced features[J]. IEEE Transactions on Power Electronics, 2014, 29(8): 4007-4016.
[8] Zhang Yun, Yang Gen, Li Jing, et al.A modulation scheme with full range ZVS and natural power factor correction for bridgeless single-stage isolated AC-DC converter[J]. IEEE Transactions on Power Electronics, 2023, 38(1): 195-205.
[9] 刘猛, 孙孝峰, 王洪龙, 等. 一种新型单级隔离型AC-DC变换器研究[J]. 中国电机工程学报, 2023, 43(7): 2802-2814, 28.
Liu Meng, Sun Xiaofeng, Wang Honglong, et al.Research on novel single-stage isolated AC-DC converter[J]. Proceedings of the CSEE, 2023, 43(7): 2802-2814, 28.
[10] 邓丹阳, 陈艳慧. 双有源桥直流变换器三电平扩展移相控制下电感电流有效值最优跟踪控制策略[J]. 电工技术学报, 2024, 39(18): 5800-5815.
Deng Danyang, Chen Yanhui.Optimal tracking control strategy of inductive current RMS for dual active bridge dc converter with three-level extended phase-shift control[J]. Transactions of China Elec-trotechnical Society, 2024, 39(18): 5800-5815.
[11] Mou Di, Luo Quanming, Li Jia, et al.Five-degree-of-freedom modulation scheme for dual active bridge DC-DC converter[J]. IEEE Transactions on Power Electronics, 2021, 36(9): 10584-10601.
[12] 刘赞, 沙金, 邱高峰, 等. 多级离散扩展移相控制双有源桥DC-DC变换器的原理、参数设计与性能[J]. 电工技术学报, 2024, 39(12): 3761-3773.
Liu Zhan, Sha Jin, Qiu Gaofeng, et al.Principle, parameter design and performance of multistage discrete extended-phase-shift control dual active bridge DC-DC converters[J]. Transactions of China Electrotechnical Society, 2024, 39(12): 3761-3773.
[13] Sha Deshang, Zhang Debin, Zhang Jiankun.A single-stage dual-active-bridge AC-DC converter employing mode transition based on real-time calculation[J]. IEEE Transactions on Power Electronics, 2021, 36(9): 10081-10088.
[14] Li Xiaoguang, Wu Fengjiang, Yang Guijie, et al.Improved modulation strategy for single-phase isolated quasi-single-stage AC-DC converter to improve current characteristics[J]. IEEE Transactions on Power Electronics, 2020, 35(4): 4296-4308.
[15] Singh A, Yadav A K, Khaligh A.Steady-state modeling of a dual-active bridge AC-DC converter considering circuit nonidealities and intracycle transient effects[J]. IEEE Transactions on Power Electronics, 2021, 36(10): 11276-11287.