基于有源整流的无线电能传输系统双边LCL零电压软开关控制策略

doi:10.19595/j.cnki.1000-6753.tces.240557

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (4919 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract In wireless power transfer (WPT) systems, achieving accurate voltage regulation and efficient operation are critical. Current research achieves constant voltage output and zero voltage switch (ZVS) with additional DC-DC converters and variable resonant networks. However, these approaches increase system losses and costs. Therefore, this paper proposes a two-sided LCL phase-shifting control strategy. The internal phase shift angle of the inverter and active rectifier (AR) is used to achieve constant voltage output and maximum efficiency tracking, and the external phase shift angle between the two converters achieves ZVS of all switching tubes. By analyzing the power loss, the constraint condition between the internal phase shift angle is obtained. The minimum external phase shift angle δ_opt of ZVS is further determined, and the system’s high efficiency is realized. In addition, the power angle θ_power is introduced as the intermediate variable, and the frequency synchronization of the primary and secondary sides is realized using the voltage-controlled oscillator (VCO).
Firstly, utilizing the fundamental wave equivalent model, the constant voltage characteristics of the system and the constraint conditions of the inverter output voltage and AR input voltage pulse-width ratio D₁ and D₂ are analyzed. The results show that transmission efficiency peaks when the AC voltage ratio α =1. With load variations, achieving constant voltage output and maximum efficiency tracking is feasible by adjusting D₁ and D₂. Secondly, based on the time-domain harmonics model, the derivation and simplification of the time-domain expression of inductance current are conducted. The simplified model is then analyzed to determine the external phase shift angle δ. By comparing δ of the inverter and AR, the δ_opt is obtained. Thirdly, the overall control strategy is introduced. The constant voltage output is achieved by adjusting D₁ and D₂. The introduction of θ_power as an intermediate variable establishes the relationship between δ and θ_power, enabling indirect control of δ through the regulation of θ_power. Subsequently, the frequency synchronization of the primary and secondary sides is realized using a VCO, effectively solving the synchronization challenge associated with an active rectifier.
Finally, system simulations and experiments were conducted. The experimental results show that the system can achieve ZVS for all MOSFETs and maintain a constant voltage output regardless of load variations. Moreover, the proposed synchronous control strategy can effectively track the switching frequency of the inverter and precisely adjust the required δ_opt. As D₁ and D₂ consistently adhere to the maximum efficiency constraints during system adjustments, the system also achieves maximum efficiency tracking. When the coupling coefficient k is 0.31, the transmission efficiency of the system is the highest, and the maximum efficiency is 93.8%.

Key words： Wireless power transfer (WPT) phase-shifting control active rectifier (AR) zero voltage switching (ZVS)

Received: 08 April 2024

PACS:

TM724

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Li Zheng
	Yu Zhihao
	Gao Shihao
	Tang Minglei
	Sun Hexu

Cite this article:

Li Zheng,Yu Zhihao,Gao Shihao等. Two-Sided LCL Zero Voltage Switching Control Strategy Based on Active Rectifier for Wireless Power Transfer System[J]. Transactions of China Electrotechnical Society, 2025, 40(8): 2380-2392.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.240557 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I8/2380

[1] 田勇, 冯华逸, 田劲东, 等. 电动汽车动态无线充电系统输出电流模型预测控制[J]. 电工技术学报, 2023, 38(9): 2310-2322, 2447.
Tian Yong, Feng Huayi, Tian Jindong, et al.Model predictive control for output current of electric vehicle dynamic wireless charging systems[J]. Transactions of China Electrotechnical Society, 2023, 38(9): 2310-2322, 2447.
[2] Jiang Yongbin, Wang Laili, Wang Yue, et al.Analysis, design, and implementation of WPT system for EV’s battery charging based on optimal operation frequ-ency range[J]. IEEE Transactions on Power Elec-tronics, 2019, 34(7): 6890-6905.
[3] Jiang Yongbin, Wang Laili, Fang Jingyang, et al.A high-efficiency ZVS wireless power transfer system for electric vehicle charging with variable angle phase shift control[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2021, 9(2): 2356-2372.
[4] 陈伟华, 刘宗旺, 李政兴, 等. 谐振式无线供能心脏起搏器多线圈无功屏蔽研究[J]. 电工技术学报, 2022, 37(11): 2673-2685.
Chen Weihua, Liu Zongwang, Li Zhengxing, et al.Research on multi coil reactive shielding of resonant wireless energy supply cardiac pacemaker[J]. Transa-ctions of China Electrotechnical Society, 2022, 37(11): 2673-2685.
[5] 李砚玲, 蒋旭应, 应杨江, 等. 感应无线供电系统的线圈自定位方法研究[J]. 中国电机工程学报, 2023, 43(11): 4367-4377.
Li Yanling, Jiang Xuying, Ying Yangjiang, et al.Research on coil self-positioning method for indu-ctive wireless power supply system[J]. Proceedings of the CSEE, 2023, 43(11): 4367-4377.
[6] 薛明, 杨庆新, 章鹏程, 等. 无线电能传输技术应用研究现状与关键问题[J]. 电工技术学报, 2021, 36(8): 1547-1568.
Xue Ming, Yang Qingxin, Zhang Pengcheng, et al.Application status and key issues of wireless power transmission technology[J]. Transactions of China Electrotechnical Society, 2021, 36(8): 1547-1568.
[7] Zhang Yiming, Chen Shuxin, Li Xin, et al.Design methodology of free-positioning nonoverlapping wireless charging for consumer electronics based on antiparallel windings[J]. IEEE Transactions on Industrial Electronics, 2022, 69(1): 825-834.
[8] Yang Lin, Ren Li, Shi Yanyan, et al.Analysis and design of an S/S/P-compensated three-coil structure WPT system with constant current and constant voltage output[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2023, 11(3): 2487-2500.
[9] Yuan Hao, Wang Chunfang, Xia Dongwei.Research on input-parallel single-switch WPT system with load-independent constant voltage output[J]. IEEE Transactions on Transportation Electrification, 2023, 9(1): 1888-1896.
[10] 姚若玉, 曲小慧, 郁继栋, 等. 自适应电池充电曲线的三线圈电池无线充电器[J]. 电力系统自动化, 2022, 46(7): 170-177.
Yao Ruoyu, Qu Xiaohui, Yu Jidong, et al.Three-coil wireless battery charger with self-adaptation to battery charging curve[J]. Automation of Electric Power Systems, 2022, 46(7): 170-177.
[11] 黄文聪, 饶天彪, 蒋煊焱, 等. 无线电能传输系统最大效率追踪及恒压输出复合控制方法[J]. 电工技术学报, 2024, 39(12): 3589-3601, 3615.
Huang Wencong, Rao Tianbiao, Jiang Xuanyan, et al.Maximum efficiency tracking and constant voltage output compound control method for wireless power transfer system[J]. Transactions of China Electro-technical Society, 2024, 39(12): 3589-3601, 3615.
[12] 赵进国, 赵晋斌, 张俊伟, 等. 无线电能传输系统中有源阻抗匹配网络断续电流模式最大效率跟踪研究[J]. 电工技术学报, 2022, 37(1): 24-35.
Zhao Jinguo, Zhao Jinbin, Zhang Junwei, et al.Maximum efficiency tracking study of active impedance matching network discontinous current mode in wireless power transfer system[J]. Transa-ctions of China Electrotechnical Society, 2022, 37(1): 24-35.
[13] Li Hongchang, Li Jie, Wang Kangping, et al.A maximum efficiency point tracking control scheme for wireless power transfer systems using magnetic resonant coupling[J]. IEEE Transactions on Power Electronics, 2015, 30(7): 3998-4008.
[14] Yang Yun, Zhong Wenxing, Kiratipongvoot S, et al.Dynamic improvement of series-series compensated wireless power transfer systems using discrete sliding mode control[J]. IEEE Transactions on Power Electronics, 2018, 33(7): 6351-6360.
[15] Gheisarnejad M, Farsizadeh H, Tavana M R, et al.A novel deep learning controller for DC-DC Buck-Boost converters in wireless power transfer feeding CPLs[J]. IEEE Transactions on Industrial Electronics, 2021, 68(7): 6379-6384.
[16] 杨云虎, 贾维娜, 梁大壮, 等. LCC-LCC/S自切换恒流-恒压复合型无线电能传输系统[J]. 电工技术学报, 2023, 38(18): 4823-4837, 4852.
Yang Yunhu, Jia Weina, Liang Dazhuang, et al.A self-switching wireless power transfer system based on hybrid topology of LCC-LCC/S with constant current and constant voltage[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 4823-4837, 4852.
[17] Li Zheng, Xie Bo, Zhu Yiding, et al.Wireless charging constant power output system based on LCC/S-S self-switching[J]. IEEE Access, 2022, 10: 86435-86444.
[18] Li Weijie, Diao Lijun, Mei Weiyao, et al.Optimized resonant network design for high energy transfer efficiency of the WPT system[J]. Electronics, 2023, 12(9): 1984.
[19] 李争, 唐明磊, 解波, 等. 无线电能传输零电压开关角跟踪和动态电容补偿矩阵复合控制策略[J]. 电工技术学报, 2024, 39(12): 3602-3615.
Li Zheng, Tang Minglei, Xie Bo, et al.Composite control strategy of zero voltage switch angle tracking and dynamic capacitance compensation matrix for wireless power transfer[J]. Transactions of China Electrotechnical Society, 2024, 39(12): 3602-3615.
[20] Jiang Yongbin, Wang Laili, Wang Yue, et al.Phase-locked loop combined with chained trigger mode used for impedance matching in wireless high power transfer[J]. IEEE Transactions on Power Electronics, 2020, 35(4): 4272-4285.
[21] Mai Ruikun, Liu Yeran, Li Yong, et al.An active-rectifier-based maximum efficiency tracking method using an additional measurement coil for wireless power transfer[J]. IEEE Transactions on Power Electronics, 2018, 33(1): 716-728.
[22] 郭星, 刘利强, 齐咏生, 等. 基于LCL-LCL/S混合自切换谐振式无线充电系统[J]. 电工技术学报, 2022, 37(10): 2422-2434.
Guo Xing, Liu Liqiang, Qi Yongsheng, et al.Hybrid self-switching resonant wireless charging system based on LCL-LCL/S[J]. Transactions of China Electrotechnical Society, 2022, 37(10): 2422-2434.
[23] Gupta R, Samanta S.A novel parameter tuning for LCL-LCL WPT with combined CC/CV charging and improved harmonic performance[J]. IEEE Transa-ctions on Industrial Electronics, 2024, 99: 1-11.