基于交错双沿调制的四管Buck-Boost变换器的变频控制策略

doi:10.19595/j.cnki.1000-6753.tces.240409

Abstract
Figure/Table
References
Related Citation (8)

Download: PDF (5410 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The four-switch Buck-Boost converter (FSBB) has the advantages of a wide input voltage range, input and output polarity, and high control degree of freedom, which is suitable for charging photovoltaic cells in a DC microgrid. At present, research on FSBB mainly focuses on the smooth switching of multi-mode control and efficiency improvement. After discussing the influence of multi-mode control and modulation mode on FSBB efficiency, this paper proposes a variable frequency control strategy that considers efficiency improvement and smooth mode switching.
Through the analysis of the inductor current under multi-mode control, it can be concluded that the inductor current ripple and average value of the two-mode control are the smallest when the input and output voltages are close, and its efficiency performance is optimal. Under the same gain, reducing d₂ can reduce the average value of inductance current. In addition, under the same duty cycle d₂, reducing or avoiding the simultaneous conduction of S₁ and S₄ can reduce the ripple of the inductor current. Both are beneficial in improving the efficiency of the converter. Then, this paper proposes an interleaved dual-edge modulation method, which avoids the simultaneous conduction of S₁ and S₄ while ensuring that d₂ is a small value.
Under the two-mode control, when the converter gain is close to 1, the inductor current ripple is close to 0. The multi-switch switch works, and the switching loss ratio increases. Because the current ripple is small at this time, reducing the switching loss is convenient. The average value of the inductor current formed by the interleaved dual-edge modulation is exactly the starting and ending position values of each switching cycle. Thus, the frequency can be modified to achieve a smooth transition of the converter operating mode. A variable frequency multi-mode control strategy is proposed. Then, the half-bridge on both sides of the inductor of FSBB is divided into high-frequency and low-frequency bridges. When the input and output voltages are close, the frequency of the two bridges is the lowest f_base. When the input voltage increases (decreases), ensuring the inductor current ripple does not exceed ΔI_{L_max}, the Buck duty cycle is reduced, and the frequency of the Buck bridge is increased (the Boost duty cycle and the frequency of the Boost bridge are increased).
A 600 W FSBB prototype is built to verify the proposed variable frequency control strategy. The experimental results show that the converter can achieve Buck-Boost conversion in different modes. When the input voltage changes, the strategy can automatically adjust the frequency to improve the conversion efficiency. When the switching frequency is adjusted, the inductor current ripple changes, and the converter can always maintain the stability of the output voltage during the mode-switching process. Compared with the fixed- frequency two-mode control, the proposed frequency conversion significantly reduces the switching loss due to the decrease of the switching frequency. Although the increase in the inductor current ripple increases the conduction loss, the overall loss is reduced, thereby improving the efficiency. Especially near the operating point when the input and output voltages are close, the converter’s efficiency is significantly improved.

Key words： Four-switch Buck-Boost converter interleaved dual-edge modulation variable frequency control smooth mode switch

Received: 15 March 2024

PACS:

TM461

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Luo Lijiang
	Shi Jianan
	Ren Xiaoyong
	Lin Congzhi

Cite this article:

Luo Lijiang,Shi Jianan,Ren Xiaoyong等. Variable Frequency Control Strategy of Four-Switch Buck-Boost Converter Based on Interleaved Dual-Edge Modulation[J]. Transactions of China Electrotechnical Society, 2025, 40(6): 1878-1887.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.240409 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I6/1878

[1] 赵书强, 王慧, 田娜, 等. 基于模型预测控制的直流微电网虚拟惯性优化方法[J]. 电工技术学报, 2023, 38(12): 3264-3276.
Zhao Shuqiang, Wang Hui, Tian Na, et al.Model predictive control based DC microgrid virtual inertia optimal method[J]. Transactions of China Elec- trotechnical Society, 2023, 38(12): 3264-3276.
[2] 张昊, 李昱, 尹亚飞, 等. 直流微电网集成式高品质协同控制策略[J]. 电工技术学报, 2023, 38(23): 6345-6358.
Zhang Hao, Li Yu, Yin Yafei, et al.An integrated high-quality cooperative control strategy of DC microgrids[J]. Transactions of China Electrotechnical Society, 2023, 38(23): 6345-6358.
[3] 高圣伟, 祝庆同. 一种独立光储发电系统用宽输入范围非隔离三端口变换器[J]. 电工技术学报, 2023, 38(4): 970-982.
Gao Shengwei, Zhu Qingtong.A wide input range non-isolated three-port converter for stand-alone PV storage power generation system[J]. Transactions of China Electrotechnical Society, 2023, 38(4): 970-982.
[4] 任小永, 唐钊, 阮新波, 等. 一种新颖的四开关Buck-Boost变换器[J]. 中国电机工程学报, 2008, 28(21): 15-19.
Ren Xiaoyong, Tang Zhao, Ruan Xinbo, et al.A novel four switch Buck-Boost converter[J]. Proceedings of the CSEE, 2008, 28(21): 15-19.
[5] 方天治, 王愿, 张惠丽, 等. 四管Buck-Boost变换器的改进型三模式变频软开关控制策略[J]. 电工技术学报, 2021, 36(21): 4544-4557.
Fang Tianzhi, Wang Yuan, Zhang Huili, et al.An improved three-mode variable frequency control strategy based on four-switch Buck-Boost con- verter[J]. Transactions of China Electrotechnical Society, 2021, 36(21): 4544-4557.
[6] Guo Zhiqiang, Mao Tianhao.Efficiency optimization and control strategy of four-switch Buck-Boost con- verter for wide conversion ratio[J]. IEEE Transactions on Power Electronics, 2023, 38(9): 10702-10715.
[7] Ahmad H J, Hagiwara M.A compact high-power noninverting bidirectional Buck-Boost chopper for onboard battery energy storage systems[J]. IEEE Transactions on Power Electronics, 2022, 37(2): 1722-1735.
[8] 周国华, 邱森林, 张小兵. 宽增益高效率级联式四开关Buck-Boost LLC变换器[J]. 电工技术学报, 2024, 39(4): 1103-1115.
Zhou Guohua, Qiu Senlin, Zhang Xiaobing.Wide gain and high efficiency cascaded four-switch Buck-Boost LLC converter[J]. Transactions of China Electrotechnical Society, 2024, 39(4): 1103-1115.
[9] 吴岩, 王玮, 曾国宏, 等. 四开关Buck-Boost变换器的多模式模型预测控制策略[J]. 电工技术学报, 2022, 37(10): 2572-2583.
Wu Yan, Wang Wei, Zeng Guohong, et al.Multi- mode model predictive control strategy for the four- switch Buck-Boost converter[J]. Transactions of China Electrotechnical Society, 2022, 37(10): 2572-2583.
[10] Díaz V, Barrado A, Lázaro A, et al.Comparison of several modulation strategies for the Four Switch Buck-Boost converter[C]//2023 IEEE 17th Inter- national Conference on Compatibility, Power Elec- tronics and Power Engineering (CPE-POWERENG), Tallinn, Estonia, 2023: 1-6.
[11] Bai Yuning, Hu Sideng, Yang Zhi, et al.Model predictive control for four-switch Buck-Boost converter based on tuning-free cost function with smooth mode transition[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2022, 10(6): 6607-6618.
[12] Ma Jianjun, Zhu Miao, Pan Chunyang, et al.Multimode operation of non-inverting Buck-Boost converter for energy storage system[C]//2021 IEEE 30th International Symposium on Industrial Elec- tronics (ISIE), Kyoto, Japan, 2021: 1-5.
[13] 戴瑞然, 马运东, 王鹏, 等. 一种基于多谐振开关槽与Buck-Boost电路的准并联变换器[J/OL]. 电工技术学报, 2024: 1-19. DOI: 10.19595/j.cnki.1000- 6753.tces.230918.
Dai Ruiran, Ma Yundong, Wang Peng, et al.A quasi parallel converter based on multi resonant switched tank and Buck-Boost circuit[J/OL]. Transactions of China Electrotechnical Society, 2024: 1-19. DOI: 10.19595/j.cnki.1000-6753.tces.230918.
[14] 任小永, 阮新波, 李明秋, 等. 双沿调制的四开关Buck-Boost变换器[J]. 中国电机工程学报, 2009, 29(12): 16-23.
Ren Xiaoyong, Ruan Xinbo, Li Mingqiu, et al.Dual edge modulated four-switch Buck-Boost converter[J]. Proceedings of the CSEE, 2009, 29(12): 16-23.
[15] 任林涛, 汪飞, 肖杨婷, 等. 四开关Buck-Boost变换器研究综述[J]. 电气工程学报, 2023, 18(2): 52-69.
Ren Lintao, Wang Fei, Xiao Yangting, et al.Review research on the four-switch Buck-Boost converter[J]. Journal of Electrical Engineering, 2023, 18(2): 52-69.
[16] 曹以龙, 吴丹, 朱冬冬, 等. 一种基于四开关Buck- Boost变换器的四模式控制策略[J]. 电源学报, 2022, 20(5): 111-118.
Cao Yilong, Wu Dan, Zhu Dongdong, et al.Four- mode control strategy based on four-switch Buck- Boost converter[J]. Journal of Power Supply, 2022, 20(5): 111-118.
[17] Wani R, Patil S L, Shinde P.Modeling and simulation of average current-mode controlled bidirectional multiphase DC-DC converters used in hybrid vehicles[C]//2021 6th International Conference for Convergence in Technology (I2CT), Maharashtra, India, 2021: 1-7.