基于模块选择的级联H桥型静止无功发生器直流侧电容在线状态监测策略

doi:10.19595/j.cnki.1000-6753.tces.240204

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (5766 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The DC-link capacitor is the core component of the cascaded H-bridge (CHB) static var generator (SVG) system. It withstands complex electrical stress during long-term operation, and an online condition monitoring of its health status is critical to the reliable operation of the system. This paper proposes an online condition monitoring strategy for CHB-SVG capacitors based on module selection. According to the collected control signals, the parameter reflecting the capacitance value is calculated to sort the capacitance value of each module. Then, a special switching mode is used to bypass the module with the smallest capacitance from the system, establishing an independent discharging path. An accurate measurement of the capacitance is achieved through the discharging curve. The proposed method does not rely on extra sensors or affect the normal operation of the system, and no complicated algorithms are required.
Firstly, a health indicator of each capacitor is calculated using the existing control signals to select the most fragile module among all CHB modules. Based on the power balancing equation, the health-related indicator K is given, disproportional to the capacitance C. This process can be conducted during normal operation without heavy computational burden. By repeating this process, the degradation trend of each capacitor is monitored in real-time. Once the K is larger than a certain value, the specific module is considered at risk. However, the result can only roughly report potential capacitor failure risk, and the accurate capacitance value cannot be acquired.
After locating the risky module, a special switching mode is applied to create an independent internal discharging curve. In this process, the grid-side current is isolated with the capacitor, and an RC discharging path is established. The capacitor voltage is decreasing, which can be measured by the existing voltage sensor. The capacitance value is calculated accurately using the discharging curve. However, extra bypassing and inserting actions are produced, and the power loss during this process is substantial. With the proposed two steps, the risky module is located at the first step, and its capacitance is acquired by the discharging curve at the second step. The overall cost and monitoring accuracy are both guaranteed.
The simulation is carried out in Matlab/Simulink, and a three-module CHB prototype is built and operates under SVG mode. The results show that the overall accuracy is above 95%, verifying the effectiveness of the proposed method. The method also works well in similar CHB structures, such as motor drives and PV systems, and is promising to be integrated into existing projects.

Key words： Cascade H-bridge capacitor condition monitoring static var generator

Received: 30 January 2024

PACS:

TM464

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Wang Hanyu
	Qiu Ronglu
	Wu Jiawei
	Yang Liu
	Zhang Xing

Cite this article:

Wang Hanyu,Qiu Ronglu,Wu Jiawei等. Online Condition Monitoring Strategy of Capacitors in Cascaded-H-Bridge Static Var Generator Based on Module Selection[J]. Transactions of China Electrotechnical Society, 2025, 40(4): 1169-1179.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.240204 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I4/1169

[1] 吴洪洋, 何湘宁. 级联型多电平变换器PWM控制方法的仿真研究[J]. 中国电机工程学报, 2001, 21(8): 42-46.
Wu Hongyang, He Xiangning.Research on PWM control of a cascade multilevel converter[J]. Proceedings of the CSEE, 2001, 21(8): 42-46.
[2] 单庆晓, 李永东, 潘孟春. 级联型逆变器的新进展[J]. 电工技术学报, 2004, 19(2): 1-9.
Shan Qingxiao, Li Yongdong, Pan Mengchun.A review on cascaded inverter[J]. Transactions of China Electrotechnical Society, 2004, 19(2): 1-9.
[3] 李金玉, 陈杰, 龚春英, 等. 一种提高级联H桥逆变器功率不平衡运行能力的控制策略[J]. 电工技术学报, 2023, 38(10): 2731-2743.
Li Jinyu, Chen Jie, Gong Chunying, et al.A control strategy for improving the power unbalanced operation capability of cascaded H-bridge inverter[J]. Transactions of China Electrotechnical Society, 2023, 38(10): 2731-2743.
[4] 范学鑫, 杨北超, 揭贵生, 等. 考虑漏感频变特性的三相立体卷铁心变压器建模及分析[J]. 电工技术学报, 2023, 38(1): 140-152.
Fan Xuexin, Yang Beichao, Jie Guisheng, et al.Modeling and analysis of 3D wound core transformer considering frequency-dependent characteristics of leakage inductance[J]. Transactions of China Electrotechnical Society, 2023, 38(1): 140-152.
[5] 黄海宏, 颜碧琛, 王海欣. 并联级联H桥电源电流跟踪优化与环流抑制的模型预测控制[J]. 电工技术学报, 2023, 38(16): 4376-4390.
Huang Haihong, Yan Bichen, Wang Haixin.Model predictive control of current tracking optimization and circulating current suppression for multi-parallel cascaded H-bridge power supplies[J]. Transactions of China Electrotechnical Society, 2023, 38(16): 4376-4390.
[6] 颜湘武, 郭燕, 彭维锋, 等. 基于旋转移相变压器的电压源型无功补偿器及其控制策略[J]. 电工技术学报, 2023, 38(16): 4448-4464.
Yan Xiangwu, Guo Yan, Peng Weifeng, et al.Voltage source var compensator based on rotary phase shifting transformer and its control strategy[J]. Transactions of China Electrotechnical Society, 2023, 38(16): 4448-4464.
[7] Wang Haoran, Wang Huai, Zhu Guorong, et al.An overview of capacitive DC-links-topology derivation and scalability analysis[J]. IEEE Transactions on Power Electronics, 2020, 35(2): 1805-1829.
[8] Wang Haoran, Davari P, Wang Huai, et al.Lifetime estimation of DC-link capacitors in adjustable speed drives under grid voltage unbalances[J]. IEEE Transactions on Power Electronics, 2019, 34(5): 4064-4078.
[9] Wen Huiqing, Xiao Weidong, Wen Xuhui, et al.Analysis and evaluation of DC-link capacitors for high-power-density electric vehicle drive systems[J]. IEEE Transactions on Vehicular Technology, 2012, 61(7): 2950-2964.
[10] Ma Ke, Wang Huai, Blaabjerg F.New approaches to reliability assessment: using physics-of-failure for prediction and design in power electronics systems[J]. IEEE Power Electronics Magazine, 2016, 3(4): 28-41.
[11] Zhou Dao, Song Yipeng, Liu Yang, et al.Mission profile based reliability evaluation of capacitor banks in wind power converters[J]. IEEE Transactions on Power Electronics, 2019, 34(5): 4665-4677.
[12] Wang Huai, Liserre M, Blaabjerg F.Toward reliable power electronics: challenges, design tools, and opportunities[J]. IEEE Industrial Electronics Magazine, 2013, 7(2): 17-26.
[13] Yang Shaoyong, Xiang Dawei, Bryant A, et al.Condition monitoring for device reliability in power electronic converters: a review[J]. IEEE Transactions on Power Electronics, 2010, 25(11): 2734-2752.
[14] Yang Shaoyong, Bryant A, Mawby P, et al.An industry-based survey of reliability in power electronic converters[J]. IEEE Transactions on Industry Applications, 2011, 47(3): 1441-1451.
[15] Rodriguez Ramos E, Leyva R, Farivar G G, et al.Capacitor condition monitoring for the lowcapacitance StatCom: an online approach[J]. IEEE Transactions on Power Electronics, 2022, 37(4): 3697-3701.
[16] Ramos E R, Leyva R, Liu Qingxiang, et al.Capacitor condition monitoring method for low-capacitance StatComs: an online approach using the inherent second-harmonic oscillations[J]. IEEE Transactions on Power Electronics, 2023, 38(9): 10559-10562.
[17] Deng Fujin, Wang Qingsong, Liu Dong, et al.Reference submodule based capacitor monitoring strategy for modular multilevel converters[J]. IEEE Transactions on Power Electronics, 2019, 34(5): 4711-4721.
[18] Ghadrdan M, Abdi B, Peyghami S, et al.On-line condition monitoring system for DC-link capacitor of back-to-back converters using large-signal transients[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2023, 11(1): 1132-1142.
[19] Wang Zhongxu, Zhang Yi, Wang Huai, et al.Capacitor condition monitoring based on the DC-side start-up of modular multilevel converters[J]. IEEE Transactions on Power Electronics, 2020, 35(6): 5589-5593.
[20] Wu Yu, Du Xiong.A VEN condition monitoring method of DC-link capacitors for power converters[J]. IEEE Transactions on Industrial Electronics, 2019, 66(2): 1296-1306.
[21] Soliman H, Wang Huai, Gadalla B, et al.Condition monitoring for DC-link capacitors based on artificial neural network algorithm[C]//2015 IEEE 5th International Conference on Power Engineering, Energy and Electrical Drives (POWERENG), Riga, Latvia, 2015: 587-591.
[22] 赵涛. 级联H桥光伏逆变器关键技术研究[D]. 合肥: 合肥工业大学, 2017.
Zhao Tao.Research on key techniques of cascaded H-brdige photovoltaic inverter[D]. Hefei: Hefei University of Technology, 2017.
[23] 李玲玲, 鲁修学, 吉海涛, 等. 级联H桥型SVG直流侧电压平衡控制方法[J]. 电工技术学报, 2016, 31(9): 1-7.
Li Lingling, Lu Xiuxue, Ji Haitao, et al.A balancing control method of DC side voltage for cascaded H-bridge static var generator[J]. Transactions of China Electrotechnical Society, 2016, 31(9): 1-7.
[24] 何英杰, 付亚斌, 段文岩. 一种星接H桥级联型SVG直流侧电压均衡控制方法研究[J]. 电工技术学报, 2016, 31(11): 13-21.
He Yingjie, Fu Yabin, Duan Wenyan.Research on DC voltage balancing control method of star connection cascaded H bridge static var generator[J]. Transactions of China Electrotechnical Society, 2016, 31(11): 13-21.
[25] 丁玉峰. 基于载波移相调制的改进型MMCSTATCOM的分层控制策略研究[D]. 武汉: 华中科技大学, 2014.
Ding Yufeng.Research on hierarchical control strategy of an improved MMC-STATCOM based on CPS-PWM[D]. Wuhan: Huazhong University of Science and Technology, 2014.
[26] 孙黎, 胡峰, 马成廉, 等. 基于载波移相的MMC逆变器调制方法研究[J]. 电网与清洁能源, 2017, 33(10): 56-62.
Sun Li, Hu Feng, Ma Chenglian, et al.Research on carrier phase shift modulation mode of the MMC inverter[J]. Power System and Clean Energy, 2017, 33(10): 56-62.
[27] 李继华. 级联多电平逆变器功率均衡和功率匹配调制策略研究[D]. 武汉: 华中科技大学, 2013.
Li Jihua.Power balance and power match modulation strategies for cascaded multilevel inverter[D]. Wuhan: Huazhong University of Science and Technology, 2013.
[28] 聂子玲, 张波涛, 孙驰, 等. 级联H桥SVG直流侧电容电压的二次谐波计算[J]. 电工技术学报, 2006, 21(4): 111-116.
Nie Ziling, Zhang Botao, Sun Chi, et al.The 2nd harmonic calculation of the capacitor voltage in the DC link of the cascade H-bridge SVG[J]. Transactions of China Electrotechnical Society, 2006, 21(4): 111-116.
[29] Zhao Zhaoyang, Davari P, Lu Weiguo, et al.An overview of condition monitoring techniques for capacitors in DC-link applications[J]. IEEE Transactions on Power Electronics, 2021, 36(4): 3692-3716.
[30] 季振东, 赵剑锋, 孙毅超, 等. 三角形连接的链式H桥并网逆变器相间直流侧电压平衡控制[J]. 电工技术学报, 2013, 28(12): 191-198, 206.
Ji Zhendong, Zhao Jianfeng, Sun Yichao, et al.Interphase DC voltage balancing control of cascaded H-bridge grid-connected inverter with delta configuration[J]. Transactions of China Electrotechnical Society, 2013, 28(12): 191-198, 206.
[31] 王建赜, 伏祥运, 纪延超. 不平衡补偿时静止同步补偿器的分相控制[J]. 电力自动化设备, 2007, 27(9): 27-30.
Wang Jianze, Fu Xiangyun, Ji Yanchao.Individual phase control of D-STATCOM under unbalanced compensation[J]. Electric Power Automation Equipment, 2007, 27(9): 27-30.