定频控制谐振型单级隔离AC-DC变换器

doi:10.19595/j.cnki.1000-6753.tces.240827

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (2614 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract AC-DC converters are key equipment to interface the AC grid, DC loads, and renewable generation sources. Efficiency and power density are the main factors in the design and implementation of AC-DC converters. The two-stage power conversion has low system efficiency and high cost. A single-stage AC-DC converter achieves AC-side current regulation, DC-side voltage regulation, and high-frequency galvanic isolation simultaneously through only one stage of high-frequency power conversion, which has the potential advantages of high efficiency and power density. However, the design and implementation of single-stage AC-DC converters are difficult.
This paper presents a resonant single-stage isolated AC-DC converter based on a fixed frequency pulse width modulation strategy. When the switching frequency of the converter is set to the resonant frequency of the series-resonant tank, the impedance of the resonant tank always features zero impedance. Therefore, in steady-state, the total voltage applied on the resonant tank must also be zero, which means the fundamental voltage generated by the primary-side and secondary-side switching bridges must be equal. Following this idea, the converter can operate in both voltage step-down and step-up modes, and the equivalent voltage gain of the converter is continuously adjustable in a wide range by adjusting the pulse width of the high-frequency excitation voltages applied on the resonant tank. Hence, the voltage and current regulation requirements of the single-stage AC-DC converter can be satisfied. Voltage step-down regulation can be achieved by adjusting the primary-side duty ratio D_p, while the voltage step-up regulation can be achieved by adjusting the secondary-side duty ratio D_s.
In order to realize the soft-switching of all switches within a wide voltage range, the soft-switching characteristics of the converter are analyzed in detail. It is found that the magnetizing inductance L_m and quality factor Z_r of the resonant tank must be small enough within the entire AC voltage range, leading to much higher conduction losses. When the instantaneous AC voltage is low, the switching losses of switches are also low. Therefore, it is unnecessary to achieve soft-switching within the entire AC voltage range, and trade-offs between switching loss and conduction loss must be made to design the converter’s parameters. Therefore, an optimized parameters design method is proposed for the resonant single-stage AC-DC converter.
An experimental prototype is built and tested. The experimental results indicate that through the fixed-frequency pulse-width modulation strategy, step-up and step-down power conversions, the AC and DC side voltage and current regulation, and high power factor can be realized. With the proposed parameter optimization design method, soft switching of switches can be achieved in a wide input voltage range. The efficiency of the converter is up to 94.2%. In addition, experimental results indicate that the converter has excellent dynamic and steady-state performance.

Key words： Single-stage AC-DC converter resonant converter pulse width modulation soft switching

Received: 21 May 2024

PACS:

TM461

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Chen Laiyang
	Liu Jie
	Xing Yan
	Wu Hongfei

Cite this article:

Chen Laiyang,Liu Jie,Xing Yan等. Fixed Frequency Controlled Resonant Single Stage Isolated AC-DC Converter[J]. Transactions of China Electrotechnical Society, 2025, 40(12): 3943-3952.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.240827 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I12/3943

[1] 董朝阳, 赵俊华, 福拴, 等. 从智能电网到能源互联网: 基本概念与研究框架[J]. 电力系统自动化, 2014, 38(15): 1-11.
Dong Zhaoyang, Zhao Junhua, Fu Shuan, et al.From smart grid to energy internet: basic concept and research framework[J]. Automation of Electric Power Systems, 2014, 38(15): 1-11.
[2] 韩蒙, 吴红飞, 邢岩. 基于隔离升降压变换器的单级软开关功率因数校正变换器[J]. 中国电机工程学报, 2017, 37(8): 2361-2369.
Han Meng, Wu Hongfei, Xing Yan.A single-stage soft-switching power factor correction converter based on an isolated Buck-Boost converter[J]. Pro-ceedings of the CSEE, 2017, 37(8): 2361-2369.
[3] 孟建辉, 吴小龙, 张自力, 等. 三相隔离型AC-DC-DC电源自适应线性自抗扰控制方法及纹波抑制补偿策略[J]. 电工技术学报, 2023, 38(14): 3898-3908.
Meng Jianhui, Wu Xiaolong, Zhang Zili, et al.Adaptive linear active disturbance rejection control method and ripple suppression compensation strategy for three-phase isolated AC-DC-DC power supply[J]. Transactions of China Electrotechnical Society, 2023, 38(14): 3898-3908.
[4] 田崇翼, 李珂, 张承慧, 等. 基于切换模型的双向AC-DC变换器控制策略[J]. 电工技术学报, 2015, 30(16): 70-76.
Tian Chongyi, Li Ke, Zhang Chenghui, et al.Control strategy for bi-directional AC-DC converter based on switched system model[J]. Transactions of China Electrotechnical Society, 2015, 30(16): 70-76.
[5] 高敬祥, 张俊洪, 宋庆国, 等. 一种高功率因数低母线电压单级LLC AC/DC变换器[J]. 电源学报, 2023, 21(3): 1-9.
Gao Jingxiang, Zhang Junhong, Song Qingguo, et al.Single-stage LLC AC/DC converter with high power factor and low bus voltage[J]. Journal of Power Supply, 2023, 21(3): 1-9.
[6] 吴红飞, 张炎锋, 杨帆. 宽输出电压范围集成Buck型无桥PFC变换器[J]. 中国电机工程学报, 2018, 38(22): 6655-6661.
Wu Hongfei, Zhang Yanfeng, Yang Fan.Bridgeless power factor correction converter with integrated Buck converter for wide output voltage range appli-cations[J]. Proceedings of the CSEE, 2018, 38(22): 6655-6661.
[7] 王力, 胡佳成, 曾祥君, 等. 基于混合储能的交直流混联微电网功率分级协调控制策略[J]. 电工技术学报, 2024, 39(8): 2311-2324.
Wang Li, Hu Jiacheng, Zeng Xiangjun, et al.Power hierarchical coordinated control strategy for AC/DC hybrid microgrid based on hybrid energy storage[J]. Transactions of China Electrotechnical Society, 2024, 39(8): 2311-2324.
[8] 卢伟国, 曹琪, 张婷婷, 等. 基于改进谐波注入的单相Boost功率因数校正变换器直流母线电容参数在线检测[J]. 电工技术学报, 2025, 40(8): 2601-2614.
Lu Weiguo, Cao Qi, Zhang Tingting, et al.Online detection of DC-link capacitance parameters of single-phase Boost power factor correction converter based on improved harmonic injection[J]. Transac-tions of China Electrotechnical Society, 2025, 40(8): 2601-2614.
[9] Musavi F, Eberle W, Dunford W G.A high-performance single-phase bridgeless interleaved PFC converter for plug-in hybrid electric vehicle battery chargers[J]. IEEE Transactions on Industry Appli-cations, 2011, 47(4): 1833-1843.
[10] 王章毅, 陆道荣, 李想, 等. 基于移相和调频的单级双向AC-DC变换器临界电流调制策略[J]. 电工技术学报, 2023, 38(14): 3888-3897.
Wang Zhangyi, Lu Daorong, Li Xiang, et al.Boundary current modulation strategy of single-stage bidirectional AC-DC converter based on phase-shift and variable-frequency control[J]. Transactions of China Electrotechnical Society, 2023, 38(14): 3888-3897.
[11] 黄何伟, 曹太强, 潘光绪, 等. 考虑回流功率因素的全桥CLL谐振变换器参数优化设计[J]. 电工技术学报, 2023, 38(20): 5503-5514.
Huang Hewei, Cao Taiqiang, Pan Guangxu, et al.Parameter optimal design of full-bridge CLL resonant converter considering backflow power factor[J]. Transactions of China Electrotechnical Society, 2023, 38(20): 5503-5514.
[12] Wu Hongfei, Sun Kai, Li Yuewei, et al.Fixed-frequency PWM-controlled bidirectional current-fed soft-switching series-resonant converter for energy storage applications[J]. IEEE Transactions on Indu-strial Electronics, 2017, 64(8): 6190-6201.
[13] Jauch F, Biela J. Single-phase single-stage bidi-rectional isolated ZVS AC-DC converter with PFC[C]//2012 15th International Power Electronics and Motion Control Conference (EPE/PEMC), Novi Sad, Serbia, 2012: LS5d.1-1-LS5d.1-8.
[14] Cheng Chunan, Chang C H, Chung T Y, et al.Design and implementation of a single-stage driver for supplying an LED street-lighting module with power factor corrections[J]. IEEE Transactions on Power Electronics, 2015, 30(2): 956-966.
[15] Li Xiang, Guo Liuniu, Lang Tianchen, et al.Steady-state characterization of LLC-based single-stage AC/DC converter based on numerical analysis[J]. IEEE Transactions on Power Electronics, 2021, 36(9): 9970-9983.
[16] Everts J, Krismer F, Van den Keybus J, et al. Optimal ZVS modulation of single-phase single-stage bidi-rectional DAB AC-DC converters[J]. IEEE Transa-ctions on Power Electronics, 2014, 29(8): 3954-3970.
[17] Krishnamoorthy H S, Garg P, Enjeti P N.A matrix converter-based topology for high power electric vehicle battery charging and V2G application[C]//IECON 2012-38th Annual Conference on IEEE Industrial Electronics Society, Montreal, QC, Canada, 2012: 2866-2871.
[18] Hou Ruoyu, Xu Jianchun, Chen Di.A multivariable turn-on/turn-off switching loss scaling approach for high-voltage GaN HEMTs in a hard-switching half-bridge configuration[C]//2017 IEEE 5th Workshop on Wide Bandgap Power Devices and Applications (WiPDA), Albuquerque, NM, USA, 2017: 171-176.
[19] Hou Ruoyu, Lu Juncheng, Chen Di.Parasitic capacitance Eqoss loss mechanism, calculation, and measurement in hard-switching for GaN HEMTs[C]//2018 IEEE Applied Power Electronics Conference and Exposition (APEC), San Antonio, TX, USA, 2018: 919-924.
[20] Liu Wenbo, Yurek A, Sheng Bo, et al.A single stage 1.65kW AC-DC LLC converter with power factor correction (PFC) for on-board charger (OBC) appli-cation[C]//2020 IEEE Energy Conversion Congress and Exposition (ECCE), Detroit, MI, USA, 2020: 4594-4601.
[21] Forouzesh M, Liu Yanfei, Sen P C.Efficiency improvement of single-stage AC-DC LLC converter using a line cycle synchronous rectifier (SR) driving strategy[C]//2022 24th European Conference on Power Electronics and Applications (EPE'22 ECCE Europe), Hanover, Germany, 2022: 1-10.
[22] Li Xiang, Hu Haibing, Guo Liuniu, et al.A matrix-converter-based single-stage AC-DC converter with a LLC resonant tank to realize soft switching[C]//2020 IEEE 9th International Power Electronics and Motion Control Conference (IPEMC2020-ECCE Asia), Nanjing, China, 2020: 1555-1559.
[23] Wang Guangyu, Wen Huiqing.Analysis and reliabi-lity assessment for a bidirectional single-stage DAB-based AC/DC converter[C]//2023 IEEE 14th Inter-national Symposium on Power Electronics for Dis-tributed Generation Systems (PEDG), Shanghai, China, 2023: 5-8.
[24] Liu Bochen, Davari P, Blaabjerg F.A flexible control scheme for single-stage DAB AC/DC converters[C]//2018 IEEE International Power Electronics and Application Conference and Exposition (PEAC), Shenzhen, China, 2018: 1-6.
[25] Liu W, Zhu D, Yan Q, et al.Simplified peak current optimization of DAB converters with dual-phase-shift control[C]//The 16th IET International Conference on AC and DC Power Transmission (ACDC 2020), Online Conference, 2020: 210-214.