宽增益高效率CLLLC变换器的变频双移相调制策略

doi:10.19595/j.cnki.1000-6753.tces.230147

Abstract
Figure/Table
References
Related Citation (12)

Download: PDF (4398 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract In the DC microgrid, a bidirectional isolated DC-DC converter with a wide range of input voltage is required to ensure the safety and efficiency of power conversion. The CLLLC converter was selected by discussing the advantages and disadvantages of various DC-DC converters. Aiming at the problem of large secondary switch loss and limited step-down range of variable-frequency phase-shift modulated CLLLC converter, this paper proposes a variable-frequency dual-phase-shift (VF-DPS) modulation strategy. The proposed VF-DPS modulation strategy can enhance the voltage gain and efficiency of the CLLLC converter by simultaneously adjusting the switching frequency, phase-shift angle in the primary side full bridge, and phase-shift angle between the primary and secondary sides.
The proposed strategy operates in two modes: the buck mode and the boost mode. In the buck mode, when the input voltage exceeds the rated input voltage, adjustments in the phase-shift angle in the primary side full bridge achieve a voltage gain of less than 1. In the boost mode, when the input voltage is below the rated input voltage, adjustments in the phase-shift angle in the secondary side full bridge result in a voltage gain greater than 1. According to these two modes, VF-DPS modulation is adopted for the CLLLC converter. The waveform shapes of the resonant inductor current and excitation inductor current are changed by VF-DPS modulation, achieving zero voltage switching (ZVS) for all switches. The modal analysis of the VF-DPS modulated CLLLC converter is conducted. Time domain analysis method is used to solve the voltage gain and resonant inductor current. Furthermore, the influence of different frequencies and phase-shift angles on the voltage gain and root mean square of the resonant inductor current is analyzed.
An experimental prototype was designed with an input voltage of 100~300 V and an output of 400 W/ 48V. The experiments tested the wide input range, working mode, soft switching, and efficiency of the CLLLC converter. The peak efficiency is 95.1% in the buck mode and 94.4% in the boost mode, confirming soft switching in both operating modes. The VF-DPS modulated CLLLC converter has a wider gain range and higher efficiency than the variable-frequency phase-shift modulation.
The proposed VF-DPS modulated CLLLC converter addresses challenges of wide switching frequency variations and ZVS losses in the wide input voltage of the variable-frequency modulated CLLLC converter and the phase-shift modulated CLLLC converter, respectively. The VF-DPS modulated CLLLC converter realizes the soft switching of all switches. Moreover, the converter achieves a voltage gain range of 3 times and a peak efficiency of 95.1%. Future research will focus on integrated magnetic design to further enhance efficiency and reduce the volume of the converter.

Key words： Variable-frequency dual-phase-shift modulation wide input voltage CLLLC converter time domain analysis zero voltage switching

Received: 09 February 2023

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Zhou Guohua
	Wang Qi
	Deng Lunbo

Cite this article:

Zhou Guohua,Wang Qi,Deng Lunbo. Variable-Frequency Dual-Phase-Shift Modulation Strategy for CLLLC Converter with Wide Voltage Gain and High Efficiency[J]. Transactions of China Electrotechnical Society, 2024, 39(8): 2511-2522.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.230147 OR https://dgjsxb.ces-transaction.com/EN/Y2024/V39/I8/2511

[1] Azizi I, Radjeai H.A bidirectional DC-DC converter fed DC motor for electric vehicle application[C]// 2015 4th International Conference on Electrical Engineering (ICEE), Boumerdes, Algeria, 2016: 1-5.
[2] 王攀攀, 徐泽涵, 王莉, 等. 基于三重移相的双有源桥DC-DC变换器效率与动态性能混合优化控制策略[J]. 电工技术学报, 2022, 37(18): 4720-4731.
Wang Panpan, Xu Zehan, Wang Li, et al.A hybrid optimization control strategy of efficiency and dynamic performance of dual-active-bridge DC-DC converter based on triple-phase-shift[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4720-4731.
[3] Hu Yan, Zhang Yu, Chen Qing, et al.Efficiency evaluation for DAB converter with reactive power minimization strategy and full ZVS operation[C]// 2019 IEEE Energy Conversion Congress and Exposition (ECCE), Baltimore, MD, USA, 2019: 4274-4280.
[4] Tong Anping, Hang Lijun, Li Guojie, et al.Modeling and analysis of a dual-active-bridge-isolated bidire- ctional DC/DC converter to minimize RMS current with whole operating range[J]. IEEE Transactions on Power Electronics, 2018, 33(6): 5302-5316.
[5] 杨向真, 王锦秀, 孔令浩, 等. 电压不匹配运行条件下双有源桥变换器的效率优化方法[J]. 电工技术学报, 2022, 37(24): 6239-6251.
Yang Xiangzhen, Wang Jinxiu, Kong Linghao, et al.Efficiency optimization method of DAB converters under wide-voltage operating conditions[J]. Transa- ctions of China Electrotechnical Society, 2022, 37(24): 6239-6251.
[6] 高宇, 李若愚, 李林柘, 等. 三重移相调制模式下双有源变换器的直接功率控制[J]. 电工技术学报, 2022, 37(18): 4707-4719.
Gao Yu, Li Ruoyu, Li Linzhe, et al.Triple phase shift modulation-based direct power control strategy for a dual active bridge converter[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4707-4719.
[7] Chen Xiaoying, Xu Guo, Han Hua, et al.Light-load efficiency enhancement of high-frequency dual- active-bridge converter under SPS control[J]. IEEE Transactions on Industrial Electronics, 2021, 68(12): 12941-12946.
[8] Jung J H, Kim H S, Ryu M H, et al.Design metho- dology of bidirectional CLLC resonant converter for high-frequency isolation of DC distribution systems[J]. IEEE Transactions on Power Electronics, 2013, 28(4): 1741-1755.
[9] Zahid Z U, Dalala Z, Lai J S J. Design and control of bidirectional resonant converter for vehicle-to-grid (V2G) applications[C]//IECON 2014-40th Annual Conference of the IEEE Industrial Electronics Society, Dallas, TX, USA, 2015: 1370-1376.
[10] Chen Wei, Rong Ping, Lu Zhengyu.Snubberless bidirectional DC-DC converter with new CLLC resonant tank featuring minimized switching loss[J]. IEEE Transactions on Industrial Electronics, 2010, 57(9): 3075-3086.
[11] Liu Chaohui, Wang Jiabin, Colombage K, et al.A CLLC resonant converter based bidirectional EV charger with maximum efficiency tracking[C]//8th IET International Conference on Power Electronics, Machines and Drives (PEMD 2016), Glasgow, UK, 2016: 1-6.
[12] 赵子先, 康龙云, 于玮, 等. 基于简化时域模型的CLLC直流变换器参数设计[J]. 电工技术学报, 2022, 37(5): 1262-1274.
Zhao Zixian, Kang Longyun, Yu Wei, et al.Parameter design method of CLLC DC-DC converter based on simplified time domain model[J]. Transactions of China Electrotechnical Society, 2022, 37(5): 1262-1274.
[13] 文伟仲, 舒杰, 王浩, 等. 高效宽电压增益CLLC谐振变换器分段控制研究[J]. 电源技术, 2021, 45(11): 1500-1504.
Wen Weizhong, Shu Jie, Wang Hao, et al.Study of piecewise-control of high efficiency and wide voltage gain CLLC resonant converter[J]. Chinese Journal of Power Sources, 2021, 45(11): 1500-1504.
[14] 曲璐, 王昕, 许家誉, 等. 用于车载充电的双向CLLC变换器设计[J]. 哈尔滨工业大学学报, 2021, 53(9): 144-155.
Qu Lu, Wang Xin, Xu Jiayu, et al.Design method of bidirectional CLLC resonant converter for on-board charger applications[J]. Journal of Harbin Institute of Technology, 2021, 53(9): 144-155.
[15] Twiname R P, Thrimawithana D J, Madawala U K, et al.A dual-active bridge topology with a tuned CLC network[J]. IEEE Transactions on Power Electronics, 2015, 30(12): 6543-6550.
[16] Malan W L, Vilathgamuwa D M, Walker G R.Modeling and control of a resonant dual active bridge with a tuned CLLC network[J]. IEEE Transactions on Power Electronics, 2016, 31(10): 7297-7310.
[17] Kim J H, Kim C E, Kim J K, et al.Analysis on load-adaptive phase-shift control for high efficiency full-bridge LLC resonant converter under light-load conditions[J]. IEEE Transactions on Power Elec- tronics, 2016, 31(7): 4942-4955.
[18] Lo Y K, Lin C Y, Hsieh M T, et al.Phase-shifted full-bridge series-resonant DC-DC converters for wide load variations[J]. IEEE Transactions on Indu- strial Electronics, 2011, 58(6): 2572-2575.
[19] Li Kai, Wang Yue, Xu Jinghui, et al.Modeling and hybrid controller design of CLLLC[C]//2019 IEEE 10th International Symposium on Power Electronics for Distributed Generation Systems (PEDG), Xi'an, China, 2019: 168-172.
[20] 陶文栋, 王玉斌, 张丰一, 等. 双向LLC谐振变换器的变频-移相控制方法[J]. 电工技术学报, 2018, 33(24): 5856-5863.
Tao Wendong, Wang Yubin, Zhang Fengyi, et al.Pulse frequency modulation and phase shift combined control method for bidirectional LLC resonant converter[J]. Transactions of China Electrotechnical Society, 2018, 33(24): 5856-5863.
[21] 李小双, 田钦元, 王正仕. 双向CLLLC谐振变换器的混合控制策略[J]. 电力电子技术, 2022, 56(6): 111-114, 140.
Li Xiaoshuang, Tian Qinyuan, Wang Zhengshi.Hybrid control strategy of bidirectional CLLLC resonant converter[J]. Power Electronics, 2022, 56(6): 111-114, 140.
[22] 吕正, 颜湘武, 孙磊. 基于变频-移相混合控制的L-LLC谐振双向DC-DC变换器[J]. 电工技术学报, 2017, 32(4): 12-24.
Lü Zheng, Yan Xiangwu, Sun Lei.A L-LLC resonant bidirectional DC-DC converter based on hybrid control of variable frequency and phase shift[J]. Transactions of China Electrotechnical Society, 2017, 32(4): 12-24.
[23] Ryu S H, Kim D H, Kim M J, et al.Adjustable frequency-duty-cycle hybrid control strategy for full-bridge series resonant converters in electric vehicle chargers[J]. IEEE Transactions on Industrial Electronics, 2014, 61(10): 5354-5362.
[24] 曹靖, 许建平, 陈一鸣, 等. PWM-PFM混合控制LCC谐振变换器研究[J]. 中国电机工程学报, 2018, 38(12): 3629-3637, 23.
Cao Jing, Xu Jianping, Chen Yiming, et al.Study of PWM-PFM hybrid controlled LCC resonant con- verter[J]. Proceedings of the CSEE, 2018, 38(12): 3629-3637, 23.
[25] Hua Wenmin, Wu Hongfei, Yu Zhiyuan, et al.A phase-shift modulation strategy for a bidirectional CLLC resonant converter[C]//2019 10th International Conference on Power Electronics and ECCE Asia (ICPE 2019-ECCE Asia), Busan, Korea (South), 2019: 1-6.
[26] Zhu Tianhua, Zhuo Fang, Zhao Fangzhou, et al.Optimization of extended phase-shift control for full-bridge CLLC resonant converter with improved light-load efficiency[J]. IEEE Transactions on Power Electronics, 2020, 35(10): 11129-11142.