基于拓展型双曲正切函数的全桥LLC变换器大信号建模方法

doi:10.19595/j.cnki.1000-6753.tces.210933

Abstract
Figure/Table
References
Related Citation (7)

Download: PDF (6788 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The accuracy of the continuous model is very important for the characteristic analysis, real time simulation and controller design of power electronic converter. LLC resonant converter operates in continuous current mode and discontinuous current mode respectively in different operating frequency intervals due to its unique cavity structure. Therefore, it is difficult to establish a continuous model which can realize the unified description of various operating modes of LLC resonant converter. Therefore, a large signal modeling method for full bridge LLC resonant converter based on extended hyperbolic tangent function is proposed to establish an accurate large signal continuous model. Firstly, the operating characteristics of full bridge LLC resonant converters in each frequency range are analyzed. Based on this analysis, a large signal discontinuity model of full bridge LLC resonant converter is established by using the symbolic function, the absolute value function and the defined operation mode switching function. The discontinuity model can realize the unified description of continuous current mode and discontinuous current mode of full bridge LLC resonant converter. Then, two kinds of extended hyperbolic tangent functions including steepness factor and pulse coefficient are constructed, and the standardized selection methods of steepness factor and pulse coefficient are provided. By changing the steepness factor and pulse coefficient, the dead time and device switching delay time of the full bridge LLC resonant converter can be approximated with high precision, thus realizing accurate large signal modeling. Based on the extended hyperbolic tangent function, the discontinuous model is continuous, and the large signal continuous model of the full bridge LLC converter is established. Based on this model, the method of continuous system can be applied directly to realize the characteristic analysis and controller design of converter. At the same time, compared with the existing LLC resonant converter large signal continuous model, the model has lower order and higher accuracy. In addition, the large signal continuous model established in this paper can provide highly accurate switching information of the secondary power components of the full bridge LLC resonant converter in the time domain, which is convenient to be used as a reference for the design of synchronous rectifier controller. Finally, the accuracy and effectiveness of the proposed large signal continuous model are verified by building the MATLAB / Simulink simulation model and the experimental prototype with rated power of 5kW. In the full range of operating frequency, the large signal continuous model is presented with high accuracy. Compared with the light load condition, the model proposed in the heavy load condition can describe the operating characteristics of the full bridge LLC resonant converter more accurately. The computing time and resource consumption are slightly higher than the existing large signal continuous model, but the proposed large signal continuous model has higher accuracy. Although the continuous model based on the extended description function method is easier to carry out linearization and small signal perturbation than the proposed large signal continuous model, the order of the model is usually higher, while the proposed large signal continuous model proposed has a lower order. In addition, the proposed large signal continuous model can accurately describe the dynamic characteristics of the full bridge LLC resonant converter.

Key words： Full-bridge LLC converter continuous system large-signal model extended hyperbolic tangent function

Received: 30 June 2021

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Sun Chenghao
	Sun Qiuye
	Wang Rui
	Hu Jie

Cite this article:

Sun Chenghao,Sun Qiuye,Wang Rui等. Large-Signal Modeling Method of Full-Bridge LLC Converter Based on Extended Hyperbolic Tangent Function[J]. Transactions of China Electrotechnical Society, 2023, 38(1): 234-245.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.210933 OR https://dgjsxb.ces-transaction.com/EN/Y2023/V38/I1/234

[1] 孙加祥, 吴红飞, 汤欣喜, 等. 基于整流侧辅助调控的交错并联LLC谐振变换器[J]. 电工技术学报, 2021, 36(10): 2072-2080.
Sun Jiaxiang, Wu Hongfei, Tang Xinxi, et al.Interleaved LLC resonant converter with auxiliary regulation of rectifier[J]. Transactions of China Electrotechnical Society, 2021, 36(10): 2072-2080.
[2] 陈梦颖, 王议锋, 陈庆, 等. 一种可变结构型高效宽增益多谐振软开关直流变换器[J]. 电工技术学报, 2021, 36(20): 4225-4236.
Chen Mengying, Wang Yifeng, Chen Qing, et al.A variable topology multi-resonant soft-switching DC-DC converter with high efficiency and wide gain[J]. Transactions of China Electrotechnical Society, 2021, 36(20): 4225-4236.
[3] 周国华, 冷敏瑞, 李媛, 等. 开关变换器及其控制环路的建模综述[J]. 中国电机工程学报, 2020, 40(1): 183-199, 386.
Zhou Guohua, Leng Minrui, Li Yuan, et al.A review on modeling of switching converters and their control loops[J]. Proceedings of the CSEE, 2020, 40(1): 183-199, 386.
[4] Bhat A K S. A unified approach for the steady-state analysis of resonant converters[J]. IEEE Transactions on Industrial Electronics, 1991, 38(4): 251-259.
[5] De Simone S, Adragna C, Spini C, et al.Design-oriented steady-state analysis of LLC resonant converters based on FHA[C]//2006International Symposium on Power Electronics, Electrical Drives, Automation and Motion, Taormina, Italy, 2006: 200-207.
[6] 丁超, 李勇, 姜利, 等. 电动汽车直流充电系统LLC谐振变换器软开关电压边界分析[J]. 电工技术学报, 2022, 37(1): 3-11.
Ding Chao, Li Yong, Jiang Li, et al.Analysis of soft switching voltage boundary of LLC resonant converter for EV DC charging system[J]. Transactions of China Electrotechnical Society, 2022, 37(1): 3-11.
[7] Ivensky G, Bronshtein S, Abramovitz A.Approximate analysis of resonant LLC DC-DC converter[J]. IEEE Transactions on Power Electronics, 2011, 26(11): 3274-3284.
[8] Liu Jianqiang, Zhang Jiepin, Zheng T Q, et al.A modified gain model and the corresponding design method for an LLC resonant converter[J]. IEEE Transactions on Power Electronics, 2017, 32(9): 6716-6727.
[9] Agarwal V, Bhat A K S. Small signal analysis of the LCC-type parallel resonant converter using discrete time domain modeling[C]//Proceedings of 1994 Power Electronics Specialist Conference-PESC'94, Taipei, China, 1994: 805-813.
[10] Song Zhanfeng, Zhou Fengjiao.Observer-based predictive vector-resonant current control of permanent magnet synchronous machines[J]. IEEE Transactions on Power Electronics, 2019, 34(6): 5969-5980.
[11] Qin Hengsi, Kimball J W.Generalized average modeling of dual active bridge DC-DC converter[J]. IEEE Transactions on Power Electronics, 2012, 27(4): 2078-2084.
[12] Shang Fei, Wu Haowen, Niu Geng, et al.Dynamic analysis and control approach for a high-gain step-up converter for electrified transportation[J]. IEEE Transactions on Transportation Electrification, 2017, 3(3): 656-667.
[13] Menke M F, Seidel Á R, Tambara R V.LLC LED driver small-signal modeling and digital control design for active ripple compensation[J]. IEEE Transactions on Industrial Electronics, 2019, 66(1): 387-396.
[14] Buccella C, Cecati C, Latafat H, et al.Observer-based control of LLC DC/DC resonant converter using extended describing functions[J]. IEEE Transactions on Power Electronics, 2015, 30(10): 5881-5891.
[15] 徐玉珍, 郭跃森, 林维明. 一种具有自动均流特性的并联LLC谐振变换器[J]. 中国电机工程学报, 2018, 38(22): 6671-6683.
Xu Yuzhen, Guo Yuesen, Lin Weiming.A parallel LLC resonant converter with automatic current sharing characteristics[J]. Proceedings of the CSEE, 2018, 38(22): 6671-6683.
[16] Tian Shuilin, Lee F C, Li Qiang.Equivalent circuit modeling of LLC resonant converter[C]//2016 IEEE Applied Power Electronics Conference and Exposition, Long Beach, CA, USA, 2016: 1608-1615.
[17] Tian Shuilin, Lee F C, Li Qiang.Equivalent circuit modeling of LLC resonant converter[J]. IEEE Transactions on Power Electronics, 2020, 35(8): 8833-8845.
[18] Mansour A, Hajer M, Faouzi B, et al.Analysis and modeling of LLC resonant converter used in electric vehicle[C]//2019 International Conference on Advanced Systems and Emergent Technologies (IC_ASET), Hammamet, Tunisia, 2019: 357-362.
[19] Lu Yimin, Huang Xianfeng, Huang Yizheng, et al.Sigmoid function model for a PFM power electronic converter[J]. IEEE Transactions on Power Electronics, 2020, 35(4): 4233-4241.
[20] Hsu J D, Ordonez M, Eberle W, et al.LLC synchronous rectification using resonant capacitor voltage[J]. IEEE Transactions on Power Electronics, 2019, 34(11): 10970-10987.
[21] Kim J H, Kim C E, Kim J K, et al.Analysis on load-adaptive phase-shift control for high efficiency full-bridge LLC resonant converter under light-load conditions[J]. IEEE Transactions on Power Electronics, 2016, 31(7): 4942-4955.
[22] 焦健, 郭希铮, 游小杰, 等. LLC谐振变换器的改进型电流解析方法[J]. 电工技术学报, 2021, 36(23): 5002-5013.
Jiao Jian, Guo Xizheng, You Xiaojie, et al.An improved current analytical method for LLC resonant converter[J]. Transactions of China Electrotechnical Society, 2021, 36(23): 5002-5013.
[23] 袁义生, 易尘宇, 彭能. L-R复合调制T型半桥LCC谐振变换器[J]. 电工技术学报, 2022, 37(4): 892-904.
Yuan Yisheng, Yi Chenyu, Peng Neng.T-type half-bridge LCC resonant converter with L-R composite modulation[J]. Transactions of China Electrotechnical Society, 2022, 37(4): 892-904.