|
|
|
| Analysis and Calculation of Zigzag Leakage Flux in Surface Mounted Axial Flux Permanent Magnet Machines |
| Sun Mingcan1, 2, Tang Renyuan1, Han Xueyan, Tong Wenming1, Jia Jianguo1 |
1. National Engineering Research Center for Rare Earth Permanent Magnet Machine Shenyang University of Technology Shenyang 110870 China;
2. School of Electrical and Engineering Qilu University of Technology Jinan 250353 China |
|
|
|
|
Abstract The zigzag leakage flux of axial flux permanent magnet (AFPM) machine with fractional slot windings is bigger than other kinds of AFPM machine. Accurate calculation of leakage flux factor is very important during designing machines by equivalent magnetic lumped circuit method, however, accurate calculation of leakage flux factor is on the premise of accurate calculation of zigzag leakage flux factor. Based on the magnetic flux distribution characteristics of AFPM machine, the analytic formulas of zigzag leakage flux were derived at different position angles between teeth and poles. In order to evaluate validity of the analytic formulas, the leakage flux factors were calculated with analytic method and finite element method (FEM) by taking a machine scheme as an example. The calculated results by analytic method are accordant with the ones by FEM. The relationship of zigzag leakage flux and poles was given in this paper, it provides a reference for the designers who design and optimize the machine design schemes.
|
|
Received: 12 May 2016
Published: 14 September 2017
|
|
|
|
|
|
[1] 汪春, 吴可, 张祥文, 等. 规模化电动汽车和风电协同调度的机组组合问题研究[J]. 电力系统保护与控制, 2015, 43(11): 41-48.
Wang Chun, Wu Ke, Zhang Xiangwen, et al. Unit commitment considering coordinated dispatch of large scale electric vehicles and wind power generation[J]. Power System Protection and Control, 2015, 43(11): 41-48.
[2] 刘敏, 周晓霞, 陈慧春, 等. 采用三相不可控整流充电机的电动汽车充电站谐波放大效应分析与计算[J]. 电力系统保护与控制, 2016, 44(4): 36-43.
Liu Min, Zhou Xiaoxia, Chen Huichun, et al. Analysis and calculation on harmonic amplification effect of electric vehicle charging station using three-phase uncontrolled rectification charger[J]. Power System Protection and Control, 2016, 44(4): 36-43.
[3] 王星华, 彭智乐, 彭显刚, 等. 电动汽车接入对风电穿透功率极限的影响研究[J]. 电力系统保护与控制, 2016, 44(14): 147-153.
Wang Xinghua, Peng Zhile, Peng Xiangang, et al. Influence research of electric vehicle accessing on the wind penetration limit[J]. Power System Protection and Control, 2016, 44(14): 147-153.
[4] 王晓远, 王晓光. 盘式无铁心永磁同步电机矢量控制技术分析[J]. 中国电机工程学报, 2014, 34(18): 2952-2959.
Wang Xiaoyuan, Wang Xiaoguang. Analysis on vector control for disc coreless permanent magnet synchronous motors[J]. Proceedings of the CSEE, 2014, 34(18): 2952-2959.
[5] 宫晓, 徐衍亮, 冯开杰. 新型盘式横向磁通永磁电机及其空载电动势波形的解析计算[J]. 电工技术学报, 2014, 29(7): 77-82.
Gong Xiao, Xu Yanliang, Feng Kaijie. A novel disc transverse-flux permanent magnet machine and analytical expression of its no-load EMF waveform[J]. Transactions of China Electrotechnical Society, 2014, 29(7): 77-82.
[6] 沈启平, 韩雪岩. 变频器供电下定子磁动势引起的永磁同步电机转子损耗分析[J]. 电工技术学报, 2016, 31(4): 51-57.
Shen Qiping, Han Xueyan. Rotor loss analysis of the permanent magnet synchronous machine caused by stator magnetomotive force with converter powering [J]. Transactions of China Electrotechnical Society, 2016, 31(4): 51-57.
[7] 康惠林, 周理兵, 王晋, 等. 多相分数槽集中绕组表贴式永磁电机谐波电流的确定及其影响[J]. 电工技术学报, 2015, 30(9): 22-29.
Kang Huilin, Zhou Libing, Wang Jin, et al. Harmonic currents determination and their impacts on multiphase fractional-slot concentrated winding surface-mounted permanent magnet machine[J]. Transactions of China Electrotechnical Society, 2015, 30(9): 22-29.
[8] 唐任远, 陈萍, 佟文明, 等. 考虑涡流反作用的永磁体涡流损耗解析计算[J]. 电工技术学报, 2015, 30(24): 1-10.
Tang Renyuan, Chen Ping, Tong Wenming, et al. Analytical calculation of eddy current loss accounting for eddy current reaction[J]. Transactions of China Electrotechnical Society, 2015, 30(24): 1-10.
[9] 唐任远. 现代永磁电机理论与设计[M]. 北京: 机械工业出版社, 1997.
[10] 王秀和. 永磁电机[M]. 北京: 中国电力出版社, 2007.
[11] Tsai W B, Chang T Y. Analysis of flux leakage in a brushless permanent-magnet motor with embedded magnets[J]. IEEE Transactions on Magnetics, 1999, 35(1): 543-547.
[12] Liu Ye, Zhang Zhuoran, Dai Ji. Feature investigation of axial flux leakage of a hybrid excitation synchronous machine[C]//2014 17th International Conference on Electrical Machines and Systems, Hangzhou, China, 2014: 1971-1976.
[13] Ma Yilai, Lin Li, Jiang Kaiwen, et al. The application of magnetic shielding effect in drill pipe magnetic leakage flux testing[C]//International Conference on Measuring Technology and Mechatronics Automation, 2013: 1135-1138.
[14] 宫晓, 徐衍亮. 轴向磁场盘式永磁电机等效磁路网络及气隙漏磁的分析计算[J]. 电机与控制学报, 2013, 17(10): 59-64.
Gong Xiao, Xu Yanliang. Lumped parameter magnetic circuit analysis of axial flux permanent magnet motor and its analytical calculation of air gap leakage[J]. Electric Machines and Control, 2013, 17(10): 59-64.
[15] Qu Ronghai, Lipo T A. Analysis and modeling of air-gap and zigzag leakage fluxes in a surface-mounted permanent-magnet machine[J]. IEEE Transactions on Industry Applications, 2004, 40(1): 121-127.
[16] 彭兵, 夏加宽, 王成元, 等. 近极槽数表贴式永磁同步电机齿顶漏磁分析与计算[J]. 电工技术学报, 2012, 27(1): 114-118.
Peng Bing, Xia Jiakuan, Wang Chengyuan, et al. Analysis and calculation of zigzag leakage flux in surface-mounted PM synchronous machines with similar number of poles and slots[J]. Transactions of China Electrotechnical Society, 2012, 27(1): 114-118.
[17] 孙昕, 韩雪岩, 李岩. 极槽数相近的永磁同步电动机漏磁因数分析与计算[J]. 微电机, 2008, 41(1): 7-9.
Sun Xin, Han Xueyan, Li Yan. Analysis and calculation of leakage factor in permanent magnet synchronous motors with adjacent number of poles and slots[J]. Micromotors, 2008, 41(1): 7-9. |
|
|
|
2017, Vol. 32 
