High Step-Up Integrated Boost-Zeta Converter with Coupled Inductor and Resonant Soft-Switching
Sun Xuanjin1, Rong Desheng1, Wang Ning2
1. Faculty of Electrical and Control Engineering Liaoning Technical University Huludao 125105 China; 2. School of Mechanical Electronic and Information Engineering China University of Mining and Technology Beijing 100083
Abstract：The output voltage generated by the photovoltaic array and fuel cell is very low, which needs to be boosted to a high DC-bus voltage for inverting or grid connection. In order to obtain a DC-DC converter with high step-up capability, various boosting techniques, such as switched inductor, switched capacitor, and cascade techniques, have been proposed. However, their related converters have a large number of components and work in a hard-switching model, resulting in increased cost and reduced efficiency. Therefore, a high step-up coupled inductor integrated Boost-Zeta converter with coupled inductor and resonant soft-switching for photovoltaic/fuel cell systems has been proposed. The proposed converter achieves higher voltage gain with fewer components. Meanwhile, the resonant soft switching technique reduces the switching losses. Firstly, the integrated Boost-Zeta converter topology is obtained by integrating the Boost converter and the Zeta converter using the topology combination technique. The voltage gain of the Boost-Zeta converter is the sum of the Boost converter and the Zeta converter. At the same time, continuous input and output currents are obtianed. Then, based on this topology, a novel converter is proposed by replacing the diodes with switches. The proposed converter has a high voltage gain using a resonantly coupled inductor voltage multiplier cell. The zero voltage switching (ZVS) turn-on of all switches is achieved by active clamp branches, which reduces voltage stress and switching losses. Meanwhile, the zero current switching (ZVS) turn-off of all diodes is achieved by resonating the secondary winding with the resonant capacitor, effectively solving the diode reverse recovery problem. Thirdly, the operation principle of the converter is analyzed, and the performance parameters of the converter and the conditions of soft switching are given. Finally, the general topology of the proposed converter is given and compared with other converters proposed in the literature. An experimental prototype with 24 V to 32 V input and 200 V-200 W output was built. It can be seen that the ZVS turn-on of both switches is achieved. The blocking voltages of the switches are around 54 V, much lower than the output voltage. The ZCS turn-off of diodes is realized through resonance between the leakage inductor and resonant capacitor, effectively reducing the reverse recovery loss. The voltage stress of diodes is around 145 V, also lower than the output voltage. The measured efficiency of the prototype at full load is 97.1 % (32 V input), demonstrating the better performance of the proposed converter. The conclusions can be drawn as follows. (1) The proposed converter has higher voltage gain and lower switch voltage stress using the combination and coupling multiplier techniques. (2) All switches can achieve ZVS turn-on by the active clamp branch. (3) All diodes achieve ZCS shutdown by the resonance of the secondary winding multiplier branch, which effectively alleviates the reverse recovery problem of the diodes. (4) The control of the proposed converter is simple, and the resonance does not affect the voltage gain. (5) Adding multiple voltage cells can further expand the proposed converter. The proposed converter is suitable for high step-up applications such as PV power generation and fuel cell systems.
孙瑄瑨, 荣德生, 王宁. 具有谐振软开关的高增益耦合电感组合Boost-Zeta变换器[J]. 电工技术学报, 2024, 39(6): 1830-1842.
Sun Xuanjin, Rong Desheng, Wang Ning. High Step-Up Integrated Boost-Zeta Converter with Coupled Inductor and Resonant Soft-Switching. Transactions of China Electrotechnical Society, 2024, 39(6): 1830-1842.
[1] 王灿, 张雅欣. 碳中和愿景的实现路径与政策体系[J]. 中国环境管理, 2020, 12(6): 58-64. Wang Can, Zhang Yaxin.Implementation pathway and policy system of carbon neutrality vision[J]. Chinese Journal of Environmental Management, 2020, 12(6): 58-64. [2] 姜淞瀚, 彭克, 徐丙垠, 等. 直流配电系统示范工程现状与展望[J]. 电力自动化设备, 2021, 41(5): 219-231. Jiang Songhan, Peng Ke, Xu Bingyin, et al.Current situation and prospect of demonstration projects of DC distribution system[J]. Electric Power Automation Equipment, 2021, 41(5): 219-231. [3] 陈红星, 林维明, 曾涛. 一种可扩展单元的高增益升压Cuk电路[J]. 中国电机工程学报, 2019, 39(23): 7013-7022, 7114. Chen Hongxing, Lin Weiming, Zeng Tao.A high gain step-up Cuk circuit with scalable cell[J]. Proceedings of the CSEE, 2019, 39(23): 7013-7022, 7114. [4] 候虚虚, 秦岭, 熊俊峰, 等. 光伏-蓄电池联合供电水泵系统用集成式单管DC/DC变换器[J]. 电网技术, 2018, 42(1): 210-219. Hou Xuxu, Qin Ling, Xiong Junfeng, et al.Single- switch integrated DC/DC converter for photovoltaic- battery-powered water pumping system[J]. Power System Technology, 2018, 42(1): 210-219. [5] Schmitz L, Martins D C, Coelho R F.Generalized high step-up DC-DC Boost-based converter with gain cell[J]. IEEE Transactions on Circuits and Systems I: Regular Papers, 2017, 64(2): 480-493. [6] Forouzesh M, Siwakoti Y P, Gorji S A, et al.Step-up DC-DC converters: a comprehensive review of voltage- boosting techniques, topologies, and applications[J]. IEEE Transactions on Power Electronics, 2017, 32(12): 9143-9178. [7] Axelrod B, Berkovich Y, Ioinovici A.Switched- capacitor/switched-inductor structures for getting transformerless hybrid DC-DC PWM converters[J]. IEEE Transactions on Circuits and Systems I: Regular Papers, 2008, 55(2): 687-696. [8] 刘树林, 王斌, 朱高中, 等. 基于开关电感的二次型Buck-Boost变换器[J]. 电工技术学报, 2022, 37(增刊1): 190-197. Liu Shulin, Wang Bin, Zhu Gaozhong, et al.Quadratic Buck-Boost converter based on switched inductance[J]. Transactions of China Electrotechnical Society, 2022, 37(S1): 190-197. [9] Yang L S, Liang T J, Chen J F.Transformerless DC-DC converters with high step-up voltage gain[J]. IEEE Transactions on Industrial Electronics, 2009, 56(8): 3144-3152. [10] 郭英军, 孔德楷, 汤雨, 等. 考虑寄生参数的双管升压变换器高频工作特性分析[J]. 电工技术学报, 2022, 37(6): 1431-1441. Guo Yingjun, Kong Dekai, Tang Yu, et al.Analysis of operating characteristics of dual-switch Boost converter considering parasitic parameters under high frequency conditions[J]. Transactions of China Elec- trotechnical Society, 2022, 37(6): 1431-1441. [11] Prabhala V A K, Fajri P, Gouribhatla V S P, et al. A DC-DC converter with high voltage gain and two input Boost stages[J]. IEEE Transactions on Power Electronics, 2016, 31(6): 4206-4215. [12] 周悦, 耿晓珑, 孙孝峰, 等. 基于开关电容的高增益双输入Boost变换器[J]. 太阳能学报, 2018, 39(3): 797-806. Zhou Yue, Geng Xiaolong, Sun Xiaofeng, et al.The double-input Boost converter with high-gain based on switched-capacitor[J]. Acta Energiae Solaris Sinica, 2018, 39(3): 797-806. [13] 余振海, 胡雪峰, 徐紫俊, 等. 单开关高增益低电压应力直流变换器[J]. 电气技术, 2022, 23(7): 34-41. Yu Zhenhai, Hu Xuefeng, Xu Zijun, et al.Single switch high gain low voltage stress DC converter[J]. Electrical Engineering, 2022, 23(7): 34-41. [14] Santos Spencer, Andrade A M, Faistel T M K, et al. Hybrid high voltage gain transformerless DC-DC converter[J]. IEEE Transactions on Industrial Elec- tronics, 2022, 69(3): 2470-2479. [15] Kumar G G, Sundaramoorthy K, Karthikeyan V, et al.Switched capacitor-inductor network based ultra- gain DC-DC converter using single switch[J]. IEEE Transactions on Industrial Electronics, 2020, 67(12): 10274-10283. [16] Wai R J, Duan Rouyong.High step-up converter with coupled-inductor[J]. IEEE Transactions on Power Electronics, 2005, 20(5): 1025-1035. [17] Tang Yu, Fu Dongjin, Wang Ting, et al.Analysis of active-network converter with coupled inductors[J]. IEEE Transactions on Power Electronics, 2015, 30(9): 4874-4882. [18] 丁杰, 高双, 赵世伟, 等. 基于耦合电感的对称式交错并联低输入电流纹波高增益DC-DC变换器[J].电工技术学报, 2021, 36(7): 1507-1515. Ding Jie, Gao Shuang, Zhao Shiwei, et al.Symmetrical interleaved low input current ripple high step-up DC-DC converter based on coupled indu- ctor[J]. Transactions of China Electrotechnical Society, 2021, 36(7): 1507-1515. [19] 李洪珠, 程利弘, 魏昕, 等. 耦合电感倍压解耦磁集成高电压增益变换器[J]. 电工技术学报, 2023, 38(6): 1584-1595. Li Hongzhu, Cheng Lihong, Wei Xin, et al.Coupled inductance voltage doubling decoupling magnetic integrated high voltage gain converter[J]. Transa- ctions of China Electrotechnical Society, 2023, 38(6): 1584-1595. [20] Zheng Yifei, Smedley K M.Analysis and design of a single-switch high step-up coupled-inductor Boost converter[J]. IEEE Transactions on Power Electronics, 2020, 35(1): 535-545. [21] Dobakhshari S S, Fathi S H, Milimonfared J, et al.A dual active clamp DC-DC converter with high voltage gain[J]. IEEE Transactions on Power Electronics, 2021, 36(1): 597-606. [22] 凡绍桂, 巩冰, 游江, 等. 低电压电流应力的有源钳位ZVS软开关技术[J]. 中国电机工程学报, 2021, 41(13): 4616-4628. Fan Shaogui, Gong Bing, You Jiang, et al.Active clamped ZVS soft switching technology with low voltage and current stress[J]. Proceedings of the CSEE, 2021, 41(13): 4616-4628. [23] 田民, 秦岭, 周磊. 少器件数量和低开关管电压应力的ZVS高增益光伏直流模块[J]. 电网技术, 2021, 45(10): 4134-4141. Tian Min, Qin Ling, Zhou Lei.ZVS high voltage gain photovoltaic DC-module with reduced number of components and lower voltage stress[J]. Power System Technology, 2021, 45(10): 4134-4141. [24] Mirzaee A, Moghani J S.Coupled inductor-based high voltage gain DC-DC converter for renewable energy applications[J]. IEEE Transactions on Power Electronics, 2020, 35(7): 7045-7057. [25] 林雪凤, 许建平, 周翔. 谐振软开关耦合电感高增益DC-DC变换器[J]. 电工技术学报, 2019, 34(4): 747-755. Lin Xuefeng, Xu Jianping, Zhou Xiang.Soft-switched high step-up DC-DC converter with coupled inductor of resonance[J]. Transactions of China Electro- technical Society, 2019, 34(4): 747-755. [26] 陈梦颖, 王议锋, 陈庆, 等. 一种可变结构型高效宽增益多谐振软开关直流变换器[J]. 电工技术学报, 2021, 36(20): 4225-4236. Chen Mengying, Wang Yifeng, Chen Qing, et al.A variable topology multi-resonant soft-switching DC- DC converter with high efficiency and wide gain[J]. Transactions of China Electrotechnical Society, 2021, 36(20): 4225-4236. [27] 李彬彬, 王志远, 张丙旭, 等. 采用辅助变压器的可调压谐振零电压零电流开关变换器[J]. 电力系统自动化, 2022, 46(7): 160-169. Li Binbin, Wang Zhiyuan, Zhang Bingxu, et al.Voltage-regulatable resonant zero-voltage zero- current switching converter with auxiliary trans- former[J]. Automation of Electric Power Systems, 2022, 46(7): 160-169. [28] 朱小全, 刘康, 叶开文, 等. 基于SiC器件的隔离双向混合型LLC谐振变换器[J]. 电工技术学报, 2022, 37(16): 4143-4154. Zhu Xiaoquan, Liu Kang, Ye Kaiwen, et al.Isolated bidirectional hybrid LLC converter based on SiC MOSFET[J]. Transactions of China Electrotechnical Society, 2022, 37(16): 4143-4154.
2024, Vol. 39 
