Running State Analysis of the Electric Arc Furnace Smelting Magnesium Oxide Based on the Noise Signal
Fu You1,Wang Ninghui1,Wang Zhiqiang1,Wang Zhen2,Zhang Xiaoming1
1.School of Electrical Engineering Dalian University of Technology Dalian 116024 China 2.School of Innovation Dalian University of Technology Dalian 116024 China
Abstract：The time integral of the noise sound pressure from the electric arc furnace at a certain point in the space is related to the product of the arc current and the arc voltage.In this work,the noise data at different stages when smelting magnesium oxide with electric arc furnaces were acquired.The waveforms of the noise were converted into time-frequency diagrams.By comparing them with the fluctuation of the three phase currents and analyzing the internal correlation between the noise signal and the running states of the electric arc furnace,it is found that the sound intensity and the frequency characteristics of the noise signal from the electric arc furnace are highly correlated with its working states.The noise intensity of each characteristic frequency increases with the arc current and shows different distributions in different operation states of the electric arc furnace.This conclusion provides the basics for the subsequent work that using the noise signal to control the electric arc furnace during smelting magnesium oxide.
付友,王宁会,王志强,王振,张小明. 基于噪声信号的电弧炉冶炼氧化镁运行状态分析[J]. 电工技术学报, 2015, 30(5): 15-22.
Fu You,Wang Ninghui,Wang Zhiqiang,Wang Zhen,Zhang Xiaoming. Running State Analysis of the Electric Arc Furnace Smelting Magnesium Oxide Based on the Noise Signal. Transactions of China Electrotechnical Society, 2015, 30(5): 15-22.
[1] 任茂胜.电熔镁砂的冶炼工艺及电参数选择[J].工业加热,2011,40(4):75-76. Ren Maosheng.The smelting technology of electric furnace melting magnesite and its electric parameter selection[J].Industrial Heating,2011,40(4):75-76. [2] 吴志伟,柴天佑,付俊,等.电熔镁炉熔炼过程的智能设定值控制[J].控制与决策,2011,26(9):1417-1420. Wu Zhiwei,Chai Tianyou,Fu Jun,et al.Intelligent setpoints control of smelting process of fused magnesium furnace[J].Control and Decision,2011,26(9):1417-1420. [3] 吴永建,吴志伟,张莉,等.电熔镁炉智能优化仿真实验平台[J].系统仿真学报,2011,23(4):676-680. Wu Yongjian,Wu Zhiwei,Zhang Li,et al.Simulation platform for intelligent optimization control of electric-fused magnesia furnace[J].Journal of System Simulation,2011,23(4):676-680. [4] Drouet M G,Nadeau F.Acoustic measurement of the arc voltage applicable to arc welding and arc furnaces[J].Journal of Physics E:Scientific Instruments,1982,15(3):268-269. [5] 刘立君,兰虎,郑红艳,等.MIG焊电弧声信号与熔透状态相关性[J].机械工程学报,2010,46(14):79-84. Liu Lijun,Lan Hu,Zheng Hongyan,et al.Relationship between arc sound signal and penetration status in MIG welding[J].Journal of Mechanical Engineering,2010,46(14):79-84. [6] 刘立君,周滨涛,戴鸿滨,等.管道MIG焊双通道电弧声信号采集与特征分析[J].焊接学报,2012,33(8):41-44. Liu Lijun,Zhou Bintao,Dai Hongbin,et al.MIG arc welding pipe dual channel characteristic acoustic signal acquisition and analysis[J].Transactions of the China Welding Institution,2012,33(8):41-44. [7] Wang J F,Chen B,Chen H B,et al.Analysis of arc sound characteristics for gas tungsten argon welding[J].Sensor Review,2009,29(3):240-249. [8] Lv N,Xu Y,Zhang Z,et al.Audio sensing and modeling of arc dynamic characteristic during pulsed Al alloy GTAW process[J].Sensor Review,2013,33(2):147-156. [9] 杨广华,李玉兰,于莉媛.基于低频噪声的LED寿命衰减研究[J].电工技术学报,2013,28(S2):239-242. Yang Guanghua,Li Yulan,Yu Liyuan.LED life attenuation study based on low frequency noise[J].Transactions of China Electrotechnical Society,2013,28(S2):239-142. [10]吴鹏,汲胜昌,曹涛,等.高压直流换流站交流滤波电容器降噪措施[J].电工技术学报,2011,26(1):162-169. Wu Peng,Ji Shengchang,Cao Tao,et al.Audible noise reduction measures for filter capacitors in HVDC converter station[J].Transactions of China Electrotechnical Society,2011,26(1):162-169. [11]鲍晓华,刘谋志,吴锋,等.基于旋转柔度的汽车发电机安装系统对其噪声的影响分析[J].电工技术学报,2013,28(6):46-51. Bao Xiaohua,Liu Mouzhi,Wu Feng,et al.Influence of alternator’s installation system on its electromagnetic noise based on rotational compliance[J].Transactions of China Electrotechnical Society,2013,28(6):46-51. [12]曹涛,汲胜昌,吴鹏,等.基于振动信号的电容器噪声水平计算方法[J].电工技术学报,2010,25(6):172-177. Cao Tao,Ji Shengchang,Wu Peng,et al.Calculation method of noise level for capacitor based on vibration signal[J].Transactions of China Electrotechnical Society,2010,25(6):172-177. [13]Haering H U,Polthier K,Schmitz J.Noise emission of electric furnace steelworks installations[J].Stahl Und Eisen,1979,99(11):562-568. [14]Mcqueen D H.The electric arc furnace as a noise source[J].Noise Control Engineering,1980,15(2):89-95. [15]梁其和.电弧炉的噪声[J].噪声与振动控制,1983,3(4):28-31. Liang Qihe.Noise of electric arc furnace[J].Noise and Vibration Control,1983,3(4):28-31. [16]刘本永.非平稳信号分析导论[M].北京:国防工业出版社,2006. [17]翁晓明.基于WVD算法的信号分析软件设计[J].信息技术,2009,33(9):66-68. Weng Xiaoming.Design of signal analysis software based on WVD algorithm[J].Information Technology,2009,33(9):66-68. [18]Bailey D H,Swarztrauber P N.The fractional Fourier transform and applications[J].SIAM Review,1991,33(3):389-404. [19]王贺萍,史志鸿,赵虹,等.110 kV矿热炉供电系统高低压无功补偿分析[J].电力系统保护与控制,2011,39(15):84-88. Wang Heping,Shi Zhihong,Zhao Hong,et al.Analysis of high and low voltage power compensation on 110 kV power supply system in submerged arc furnace[J].Power System Protection and Control,2011,39(15):84-88. [20]张恺伦,陈宏伟,江全元.电弧炉负荷的三相综合建模与参数辨识[J].电力系统保护与控制,2012,40(16):77-82. Zhang Kailun,Chen Hongwei,Jiang Quanyuan.Modeling and parameter identification of electric arc furnace load[J].Power System Protection and Control,2012,40(16):77-82. [21]梁志瑞,叶慧强,赵飞.电力系统谐波状态估计研究综述[J].电力系统保护与控制,2010,38(15):157-160. Liang Zhirui,Ye Huiqiang,Zhao Fei.Overview on power system harmonic state estimation[J].Power System Protection and Control,2010,38(15):157-160.
2015, Vol. 30 
