|
|
|
| Research on Symmetrical Controlled Full-Bridge Resonant PWM Converter |
| Cao Taiqiang1,2, Gan Xue2, Zhou Chuan2, Guo Xiaoying3, Xia Yucheng4 |
1. Key Laboratory of Fluid and Power Machinery, Ministry of Education Xihua University Chengdu 610039 China;
2. School of Electric Information Xihua University Chengdu 610039 China;
3. School of Electronics and Information Engineering Panzhihua University Panzhihua 617000 China;
4. UOG-UESTC Joint School Chengdu 611731 China |
|
|
|
|
Abstract The traditional symmetrical controlled full bridge DC-DC converter fails to achieve soft switching. Thus, this paper proposes a full bridge resonant PWM (FB-RPWM) converter. Its operation modes and steady state characteristics are analyzed. The analysis results show that FB-RPWM converter exhibits the characteristics of DC-DC transformer (DCX), and its DC voltage conversion ratio is independent of load, switching frequency and duty ratios. The proposed FB-RPWM converter can realize zero-voltage turn-on switching (ZVS) of switches in the full load range and zero-current turn-off switching (ZCS) of the diode. Compared with the traditional phase-shift full bridge (PSFB) converter, FB-RPWM converter has reduced switch current stress and turn-off current of the main switch. It has also completely eliminated current offset of magnetizing inductor, and thus improved the efficiency of the converter. Finally, a 400V input, 50V/10A output experimental prototype is established to verify the theoretical analysis.
|
|
Received: 15 November 2015
Published: 13 October 2016
|
|
|
|
|
|
[1] 阮新波, 严仰光. 直流开关电源的软开关技术[M]. 北京: 科学出版社, 2000.
[2] 陈仲, 史良辰, 季锋, 等. 一种新颖的ZVS全桥变换器寄生振荡抑制方法[J]. 中国电机工程学报, 2012, 32(21): 38-45.
Chen Zhong, Shi Liangchen, Ji Feng, et al. A new parasitic oscillation reduction method for ZVS full bridge converters[J]. Proceedings of the CSEE, 2012, 32(21): 38-45.
[3] 王金平, 许建平, 兰燕妮, 等. 基于输入电压前馈补偿的开关变换器恒定导通时间控制技术[J]. 电工技术学报, 2012, 27(2): 18-22.
Wang Jinping, Xu Jianping, Lan Yanni, et al. Constant on-time control of swithcing DC-DC con- verters based on input voltage feed-forward com- pensation[J]. Transactions of China Electrotechnical Society, 2012, 27(2): 18-22.
[4] 陈威, 戎萍, 张伟, 等. DC-DC变流器整流二极管零电流软关断方法[J]. 中国电机工程学报, 2010, 30(15): 24-31.
Chen Wei, Rong Ping, Zhang Wei, et al. Method of zero current turn-off technique for rectifier diode in DC-DC converters[J]. Proceedings of the CSEE, 2010, 30(15): 24-31.
[5] 杨平, 许建平, 张士宇, 等. 峰值电流控制二次型Boost变换器[J]. 电工技术学报, 2011, 26(5): 101-107.
Yang Ping, Xu Jianping, Zhang Shiyu, et al. The peak current control-mode for quadratic Boost converter[J]. Transactions of China Electrotechnical Society, 2011, 26(5): 101-107.
[6] 陈道炼. 双向大升压比直流变换器型逆变器[J]. 电工技术学报, 2010, 25(6): 55-62.
Chen Daolian. Bi-directional DC/DC converter mode inverter with high voltage transmission ratio[J]. Transactions of China Electrotechnical Society, 2010, 25(6): 55-62.
[7] 孙铁成, 郭超, 娜仁图亚, 等. 具有移相控制的ZVS全桥DC-DC斩波变换器[J]. 电工技术学报, 2014, 29(12): 66-72.
Sun Tiecheng, Guo Chao, Nanren Tuya, et al. A novel DC-DC ZVS full-bridge converter based on phase-shift control[J]. Transactions of China Electro- technical Society, 2014, 29(12): 66-72.
[8] 王聪, 沙广林, 王俊, 等. 基于双重移相控制的双有源桥DC-DC变换器的软开关[J]. 电工技术学报, 2015, 30(12): 106-113.
Wang Cong, Sha Guanglin, Wang Jun, et al. The analysis of zero voltage switching dual active bridge DC-DC converters based on dual-phase-shifting control[J]. Transactions of China Electrotechnical Society, 2015, 30(12): 106-113.
[9] Il Oun Lee, Gun Woo Moon. A new asymmetrical half-bridge converter with zero DC-offset current in transformer[J]. IEEE Transactions on Power Elec- tronics, 2013, 28(5): 2297-2306.
[10] 陈仲, 汪洋, 李梦南. 一种低环流损耗的宽范围ZVS移相全桥变换器[J]. 电工技术学报, 2015, 30(22): 71-79.
Chen Zhong, Wang Yang, Li Mengnan. Wide-range zero voltage switching phase-shifted full-bridge converter with low circulation loss[J]. Transactions of China Electrotechnical Society, 2015, 30(22): 71-79.
[11] Je-Hyung Cho, Ki-Bum Park, Jin-Sik Park, et al. Design of a digital offset compensator eliminating transformer magnetizing current offset of a phase- shift full-bridge converter[J]. IEEE Transactions on Power Electronics, 2012, 27(1): 331-341.
[12] 邢岩, 黄立培, 孙晓东. 组合式前端DC-DC变换器[J]. 中国电机工程学报, 2004, 24(6): 157-161.
Xing Yan, Huang Lipei, Sun Xiaodong. A combined topology with Buck-Boost and asymmetrical half- bridge for front-end DC-DC converter[J]. Pro- ceedings of the CSEE, 2004, 24(6): 157-161.
[13] Jun-Young Lee, Yu-Seok Jeong, Byung-Moon Han. An isolated DC/DC converter using high-frequency unregulated LLC resonantconverter for fuel cell applications[J]. IEEE Transactions on Industrial Electronics, 2011, 58(7): 2926-2934.
[14] Ren Yuancheng. High frequency, high efficiency two-stage approach for future microprocessors[D]. Blacksburg: Virginia Tech, 2005.
[15] 赵晋斌, 刘金彪, 梁晓霞, 等. 一种新型交错式反激变换器分析与设计[J]. 电力系统保护与控制, 2015, 43(18): 129-137.
Zhao Jinbin, Liu Jinbiao, Liang Xiaoxia, et al. Analysis and design of a new interleaved flyback converter[J]. Power System Protection and Control, 2015, 43(18): 129-137.
[16] Julu Sun. Investigation of alternative power archite- ctures for CPU voltage regulators[D]. Blacksburg: Virginia Tech, 2008.
[17] 王金平, 许建平, 兰燕妮. 恒定导通时间双频率控制开关变换器[J]. 电工技术学报, 2011, 26(11): 1-7.
Wang Jinping, Xu Jianping, Lan Yanni. Study of constant on-time bi-frequency control technique for switching converters[J]. Transactions of China Elec- trotechnical Society, 2011, 26(11): 1-7.
[18] Feng Weiyi, Paolo Mattavelli, Fred C Lee. Pulse- width locked loop (PWLL) for automatic resonant frequency tracking in LLC DC-DC transformer (LLC-DCX)[J]. IEEE Transactions on Power Elec- tronics, 2013, 28(4): 1862-1869.
[19] Woo-Young Choi. High-efficiency DC-DC converter with fas dynamic response for low-voltage photo- voltaic sources[J]. IEEE Transactions on Power Electronics, 2013, 28(2): 706-716.
[20] Lin B R, Dong J Y. Analysis and implementation of an active clamping zero-voltage turn-on switching/ zero-current turn-off switching converter[J]. IET Power Electronics, 2010, 3(3): 429-437.
[21] Eung-Ho Kim, Bong-Hwan Kwon. Zero-switching and zero-current-switching full-bridge converter with secondary resonance[J]. IEEE Transactions on Industrial Electronics, 2010, 57(3): 1017-1025. |
|
|
|
2016, Vol. 31 
