Abstract：Winding faults seriously affect the normal operation of permanent magnet synchronous motors. As one of the most widely used fault diagnosis methods, motor current signature analysis (MCSA) can effectively diagnose winding faults. However, its accuracy can be affected by complex operating conditions, sensor errors, and calculation errors. An online diagnosis method based on controller signals is proposed to ensure accurate fault diagnosis under complex working conditions without additional sensors. Firstly, winding faults are analyzed mechanically, and the transmission of fault information among the controller signals is revealed. When a winding failure occurs in the motor, the third harmonic appears in the phase current. After the Clarke and Park transform, the third harmonic component appears in the current in the αβ axis, making the second and fourth current harmonics appear in the dq axis. According to the dq-axis voltage- current equation and Park’s inverse transform, the dq-axis reference voltage has anomalous second and fourth harmonics, and the αβ-axis reference voltage has anomalous third harmonic. Secondly, the fault features are extracted through an adaptive random window based on a fast Fourier transform (FFT). An analysis of fault characteristic distribution under single and complex working conditions reveals that some fault characteristics may fail under low-speed working conditions. Based on the artificial neural network (ANN), a deep optimization ANN is proposed. By the batch normalization (BN) algorithm, the deep network structure is residual to improve network generalization ability and diagnostic accuracy. Finally, a performance index of fault characteristics under complex working conditions is defined. The experimental results show that when the motor operates at 500 r/min to 1 250 r/min and 20 N·m to 40 N·m, the fault feature under single operating conditions approximately meets the normal distribution. The fault feature stability (Sf) under complex working conditions is defined based on the distribution variance. By the 3σ principle, this paper determines the distribution interval of fault features and defines the fault feature effectiveness (Ef) under complex working conditions according to class spacing. Moreover, the aliasing penalty factor is introduced to deepen the impact of aliasing. 13 fault features caused by the third harmonic of the three-phase current are taken as the object, and their Sf and Ef are calculated. When Sf is greater than 95% and Ef is greater than 0, the diagnostic accuracy is greater than 95%. Compared with three traditional diagnostic networks by random forest, the diagnostic accuracy of the deep optimization ANN is better, especially for the multi-fault comprehensive diagnosis of winding faults. The following conclusions can be drawn. (1) During motor operation, fault features can fluctuate seriously, especially at low speeds. Some fault features may not be suitable for online fault diagnosis. (2) Before fault diagnosis, calculating Sf and Ef helps filter out less fluctuating fault features, ensuring the accuracy of online diagnosis. (3) If the fault features are subject to large fluctuations from external factors, the deep optimization ANN exhibits higher diagnostic accuracy and generalization ability than the traditional diagnostic networks.
刘蔚, 李万铨, 王明峤, 郑萍, 赵志衡. 复杂工况下的永磁同步电机典型绕组故障在线诊断[J]. 电工技术学报, 2024, 39(6): 1764-1776.
Liu Wei, Li Wanquan, Wang Mingqiao, Zheng Ping, Zhao Zhiheng. Online Diagnosis of Typical Winding Faults in Permanent Magnet Synchronous Motors under Complex Working Conditions. Transactions of China Electrotechnical Society, 2024, 39(6): 1764-1776.
[1] 刘计龙, 肖飞, 沈洋, 等. 永磁同步电机无位置传感器控制技术研究综述[J]. 电工技术学报, 2017, 32(16): 76-88. Liu Jilong, Xiao Fei, Shen Yang, et al.Position- sensorless control technology of permanent-magnet synchronous motor-a review[J]. Transactions of China Electrotechnical Society, 2017, 32(16): 76-88. [2] Wang Xueqing, Wang Zheng, Xu Zhixian, et al.Comprehensive diagnosis and tolerance strategies for electrical faults and sensor faults in dual three-phase PMSM drives[J]. IEEE Transactions on Power Elec- tronics, 2019, 34(7): 6669-6684. [3] 谢颖, 胡圣明, 陈鹏, 等. 永磁同步电机匝间短路故障温度场分析[J]. 电工技术学报, 2022, 37(2): 322-331. Xie Ying, Hu Shengming, Chen Peng, et al.Thermal field analysis on inter-turn short circuit fault of permanent magnet synchronous motor[J]. Transa- ctions of China Electrotechnical Society, 2022, 37(2): 322-331. [4] 陈勇, 梁洪, 王成栋, 等. 基于改进小波包变换和信号融合的永磁同步电机匝间短路故障检测[J]. 电工技术学报, 2020, 35(增刊1): 228-234. Chen Yong, Liang Hong, Wang Chengdong, et al.Detection of stator inter-turn short-circuit fault in PMSM based on improved wavelet packet transform and signal fusion[J]. Transactions of China Elec- trotechnical Society, 2020, 35(S1): 228-234. [5] Çira F, Arkan M, Gümüş B.A new approach to detect stator fault in permanent magnet synchronous motors[C]//2015 IEEE 10th International Symposium on Diagnostics for Electrical Machines, Power Elec- tronics and Drives (SDEMPED), Guarda, Portugal, 2015: 316-321. [6] Romeral L, Urresty J C, Riba Ruiz J R, et al. Modeling of surface-mounted permanent magnet synchronous motors with stator winding interturn faults[J]. IEEE Transactions on Industrial Electronics, 2011, 58(5): 1576-1585. [7] 张业成, 刘国海, 陈前. 基于电流波动特征的永磁同步电机匝间短路与局部退磁故障分类诊断研究[J]. 电工技术学报, 2022, 37(7): 1634-1643, 1653. Zhang Yecheng, Liu Guohai, Chen Qian.Dis- crimination of interturn short-circuit and local demagnetization in permanent magnet synchronous motor based on current fluctuation characteristics[J]. Transactions of China Electrotechnical Society, 2022, 37(7): 1634-1643, 1653. [8] 阳同光, 桂卫华. 基于变频器网侧电流感应电机定子故障诊断[J]. 电机与控制学报, 2015, 19(12): 101-106. Yang Tongguang, Gui Weihua.Stator fault diagnosis of induction motor based on network side current of converter[J]. Electric Machines and Control, 2015, 19(12): 101-106. [9] 魏东, 刘侃, 丁荣军, 等. 基于多重同步压缩变换的永磁同步电机初期匝间短路故障检测[J]. 电工技术学报, 2022, 37(18): 4651-4663. Wei Dong, Liu Kan, Ding Rongjun, et al.A multi- synchrosqueezing transformation based early stage detection of inter-turn short circuit fault in permanent magnet synchronous machine[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4651-4663. [10] 李睿彧, 刘飞, 梁霖, 等. 基于参数优化变分模态分解的交流变频电机转子断条故障识别方法[J]. 电工技术学报, 2021, 36(18): 3922-3933. Li Ruiyu, Liu Fei, Liang Lin, et al.Fault identi- fication of broken rotor bars for the variable frequency AC motor based on parameter optimized variational mode decomposition[J]. Transactions of China Electrotechnical Society, 2021, 36(18): 3922-3933. [11] 宋向金, 王卓, 胡静涛, 等. Hilbert解调制方法诊断异步电机轴承故障[J]. 电工技术学报, 2018, 33(21): 4941-4948. Song Xiangjin, Wang Zhuo, Hu Jingtao, et al.Diagnosis of bearing fault in induction motors using Hilbert demodulation approach[J]. Transactions of China Electrotechnical Society, 2018, 33(21): 4941-4948. [12] 蒋亦悦, 刘莺, 王玺帏, 等. 基于SDP和SURF特征提取的异步电机故障诊断方法[J]. 微电机, 2022, 55(9): 12-16, 99. Jiang Yiyue, Liu Ying, Wang Xiwei, et al.A fault diagnosis method of asynchronous motor based on SDP and SURF feature extraction[J]. Micromotors, 2022, 55(9): 12-16, 99. [13] 刘凯, 张炳义, 冯桂宏. 基于电枢齿偏移法双面转子永磁同步电机振动噪声特性的研究[J]. 电工技术学报, 2021, 36(增刊1): 95-106. Liu Kai, Zhang Bingyi, Feng Guihong.Research on electromagnetic vibration and noise characteristics of dual sided rotor permanent magnet synchronous motor based on armature offset approach[J]. Transa- ctions of China Electrotechnical Society, 2021, 36(S1): 95-106. [14] Kim K H.Simple online fault detecting scheme for short-circuited turn in a PMSM through current harmonic monitoring[J]. IEEE Transactions on Indu- strial Electronics, 2011, 58(6): 2565-2568. [15] Tang Jing, Ding Xiaojian, Wang Yuanhang, et al.Condition monitoring of permanent magnet syn- chronous motor under different stator fault severity[C]//2021 Global Reliability and Prognostics and Health Management, Nanjing, China, 2021: 1-4. [16] 吴方帮, 贺青川, 陈文华, 等. 一种永磁同步电机定子不对称故障检测方法[J]. 微电机, 2018, 51(6): 11-15. Wu Fangbang, He Qingchuan, Chen Wenhua, et al.A method for detecting stator unsymmetrical fault of PMSM[J]. Micromotors, 2018, 51(6): 11-15. [17] 李兵, 梁舒奇, 单万宁, 等. 基于改进正余弦算法优化堆叠降噪自动编码器的电机轴承故障诊断[J]. 电工技术学报, 2022, 37(16): 4084-4093. Li Bing, Liang Shuqi, Shan Wanning, et al.Motor bearing fault diagnosis based on improved sine and cosine algorithm for stacked denoising auto- encoders[J]. Transactions of China Electrotechnical Society, 2022, 37(16): 4084-4093. [18] Lu Siliang, Qian Gang, He Qingbo, et al.In situ motor fault diagnosis using enhanced convolutional neural network in an embedded system[J]. IEEE Sensors Journal, 2020, 20(15): 8287-8296. [19] 杨战社, 孔晨再, 荣相, 等. 基于EEMD能量熵与ANN的矿用异步电机故障诊断[J]. 微电机, 2021, 54(8): 23-27, 61. Yang Zhanshe, Kong Chenzai, Rong Xiang, et al.Fault diagnosis of mine asynchronous motor based on EEMD energy entropy and ANN[J]. Micromotors, 2021, 54(8): 23-27, 61. [20] 禹杭, 高海波, 付博, 等. 基于PCA-RF的永磁电机故障诊断[J]. 应用科技, 2021, 48(6): 90-96. Yu Hang, Gao Haibo, Fu Bo, et al.Fault diagnosis of permanent magnet motor based on PCA-RF[J]. Applied Science and Technology, 2021, 48(6): 90-96. [21] Seera M, Lim C P, Ishak D, et al.Fault detection and diagnosis of induction motors using motor current signature analysis and a hybrid FMM-CART model[J]. IEEE Transactions on Neural Networks and Learning Systems, 2012, 23(1): 97-108. [22] Chen Zhaodong, Deng Lei, Li Guoqi, et al.Effective and efficient batch normalization using a few uncorrelated data for statistics estimation[J]. IEEE Transactions on Neural Networks and Learning Systems, 2021, 32(1): 348-362. [23] Lin Chengchuang, Zhao Gansen, Yang Zhirong, et al.CIR-net: automatic classification of human chromo- some based on inception-ResNet architecture[J]. IEEE/ACM Transactions on Computational Biology and Bioinformatics, 2022, 19(3): 1285-1293. [24] 赵文祥, 刘桓, 陶涛, 等. 基于虚拟信号和高频脉振信号注入的无位置传感器内置式永磁同步电机MTPA控制[J]. 电工技术学报, 2021, 36(24): 5092-5100. Zhao Wenxiang, Liu Huan, Tao Tao, et al.MTPA control of sensorless IPMSM based on virtual signal and high-frequency pulsating signal injection[J]. Transactions of China Electrotechnical Society, 2021, 36(24): 5092-5100. [25] 李峰, 夏超英. 考虑磁路饱和的IPMSM电感辨识算法及变参数MTPA控制策略[J]. 电工技术学报, 2017, 32(11): 136-144. Li Feng, Xia Chaoying.Inductance identification algorithm and variable-parameters MTPA control strategy for IPMSM considering magnetic circuit saturation[J]. Transactions of China Electrotechnical Society, 2017, 32(11): 136-144. [26] 付兴贺, 陈锐. 电机中ABC到dq0坐标变换的梳理与辨析[J]. 微特电机, 2021, 49(4): 1-8, 13. Fu Xinghe, Chen Rui.Criticism and argument on coordinate transformation from ABC to dq0 in electric machine[J]. Small & Special Electrical Machines, 2021, 49(4): 1-8, 13. [27] 宋战锋, 毛丰羽, 崔严谨, 等. 参考跟踪和扰动抑制解耦的双三相永磁同步电机容错控制策略[J]. 电工技术学报, 2023, 38(2): 435-450. Song Zhanfeng, Mao Fengyu, Cui Yanjin, et al.An fault-tolerant control strategy based on decoupling between reference tracking and periodic disturbance attenuation for dual-three-phase permanent magnet synchronous machine[J]. Transactions of China Elec- trotechnical Society, 2023, 38(2): 435-450. [28] 马文昌. 三相电机故障分析及诊断方法研究[J]. 防爆电机, 2021, 56(4): 61-63. Ma Wenchang.Research on fault analysis and diagnosis method of three-phase motor[J]. Explosion- Proof Electric Machine, 2021, 56(4): 61-63. [29] 叶鹏, 江思敏, 林海, 等. 基于复杂工况的直驱永磁同步电机应用研究[J]. 微电机, 2015, 48(12): 28-31, 39. Ye Peng, Jiang Simin, Lin Hai, et al.Study on the application of direct drive PMSM based on com- plicated conditions[J]. Micromotors, 2015, 48(12): 28-31, 39. [30] 赵志磊, 王雪妹, 刘冬冬, 等. 基于BP-ANN和PLS的近红外光谱无损检测李果实品质的研究[J]. 光谱学与光谱分析, 2022, 42(9): 2836-2842. Zhao Zhilei, Wang Xuemei, Liu Dongdong, et al.Quantitative analysis of soluble solids and titratable acidity content in Angeleno plum by near-infrared spectroscopy with BP-ANN and PLS[J]. Spectroscopy and Spectral Analysis, 2022, 42(9): 2836-2842. [31] 杨茁蓬, 高彦杰. 基于MODWT和ANN的微电网故障诊断[J]. 电力电子技术, 2022, 56(2): 19-22. Yang Zhuopeng, Gao Yanjie.Fault diagnosis in microgrid based on MODWT and ANN network[J]. Power Electronics, 2022, 56(2): 19-22. [32] Ioffe S, Szegedy C.Batch normalization: accelerating deep network training by reducing internal covariate shift[C]//2015 International Conference on Machine Learning, Lille, France, 2015. [33] He Kaiming, Zhang Xiangyu, Ren Shaoqing, et al.Deep residual learning for image recognition[C]// 2016 IEEE Conference on Computer Vision and Pattern Recognition, Las Vegas, NV, USA, 2016: 770-778.
2024, Vol. 39 
