电容器组投切用SF<sub>6</sub>断路器介质恢复特性数值计算与试验研究

摘要
图/表
参考文献
相关文章 (14)

全文: PDF (3007 KB)
输出: BibTeX | EndNote (RIS)

摘要针对126 kV电容器组专用SF₆断路器介质恢复特性进行数值计算与试验研究。对断路器灭弧室电场和气流场进行数值计算,依据流注理论,得到断路器触头间击穿电压曲线;搭建试验回路对断路器触头间隙动态击穿特性进行试验,测量断路器合闸和分闸过程中的击穿电压;结合数值计算与试验结果,分析不同压强对断路器合、分闸过程击穿电压的影响,给出高压SF₆断路器介质恢复特性的变化规律。研究结果表明:对于同样的触头间隙,合闸过程(平均速度4.7 m/s)击穿电压大于分闸过程(平均速度9.6 m/s)。

	服务

	把本文推荐给朋友
	加入我的书架
	加入引用管理器
	E-mail Alert
	RSS
	作者相关文章
	林莘
	夏亚龙
	刘卫东
	王飞鸣
	徐建源
	李志兵

关键词 ： SF₆断路器, 气流场, 动态击穿, 介质恢复

Abstract：The dielectric recovery characteristics of the capacitor bank SF₆ circuit breaker is studied through numerical computation and experiment.The electric field and the flow field of the arc quenching chamber is calculated,and then the breakdown voltage curve between contacts can be obtained based on the stream theory.The experimental circuit is set up for the experiment of gap dynamic breakdown characteristics between arc contacts,and the breakdown voltage is measured during the closing and breaking process of the circuit breaker.The numerical and experimental results are then combined to acquire the dielectric recovery characteristics of the SF₆ circuit breaker by analyzing the influence of different pressure on the breakdown voltage between contacts.The results show that the breakdown voltage of the closing process (with 4.7 m/s average speed) is greater than that of the breaking process (with 9.6 m/s average speed) for the same contact gap.

Key words： SF₆ circuit breaker gas flow field dynamic breakdown dielectric recovery

收稿日期: 2015-02-05 出版日期: 2015-12-07

PACS:

TM561

基金资助:国家自然科学基金(51277123、51177104)和国家电网公司科技项目(GY17201200063)资助。

作者简介: 林莘女,1961年生,教授,博士生导师,研究方向为高压电器、高电压与绝缘技术、智能电器。夏亚龙男,1989年生,博士研究生,研究方向为高压电器理论及电工装备的设计。(通信作者)

引用本文:

林莘,夏亚龙,刘卫东,王飞鸣,徐建源,李志兵. 电容器组投切用SF₆断路器介质恢复特性数值计算与试验研究[J]. 电工技术学报, 2015, 30(17): 161-171. Lin Xin,Xia Yalong,Liu Weidong,Wang Feiming,Xu Jianyuan,Li Zhibing. The Numerical Computation and Experiment Research on Dielectric Recovery Characteristics of SF₆ Circuit Breaker for Switching Capacitor Bank. Transactions of China Electrotechnical Society, 2015, 30(17): 161-171.

链接本文:

https://dgjsxb.ces-transaction.com/CN/Y2015/V30/I17/161

[1] 刘振亚.中国特高压交流输电技术创新[J].电网技术,2013,37(3):566-574.
Liu Zhenya.Innovation of UHVAC transmission technology in China[J].Power System Technology,2013,37(3):566-574.
[2] 刘振亚.中国电力与能源[M].北京:中国电力出版社,2012.
[3] 荣命哲,杨飞,吴翊,等.直流断路器电弧研究的新进展[J].电工技术学报,2014,29(1):1-8.
Rong Mingzhe,Yang Fei,Wu Yi,et al.New developments in switching arc research in DC circuit breaker[J].Transactions of China Electrotechnical Society,2014,29(1):1-8.
[4] 管瑞良,刘洪武.有源配电网中的断路器应用研究[J].电力系统保护与控制,2015,43(3):127-130.
Guan Ruiliang,Liu Hongwu.Application study on low voltage circuit breakers used for active electric network[J].Power System Protection and Control,2015,43(3):127-130.
[5] 林莘.现代高压电器技术[M].北京:机械工业出版社,2011.
[6] 李鑫涛,林莘,徐建源,等.基于FEM-FCT法的均匀电场下SF₆气体击穿特性[J].高电压技术,2014,40(10):3046-3053.
Li Xintao,Lin Xin,Xu Jianyuan,et al.Breakdown characteristics of SF₆ in uniform electric field using FEM-FCT[J].High Voltage Engineering,2014,40(10):3046-3053.
[7] 吴翊,荣命哲,王小华,等.触头打开过程中低压空气电弧等离子体的动态分析[J].电工技术学报,2008,23(5):12-17.
Wu Yi,Rong Mingzhe,Wang Xiaohua,et al.Dynamic analysis of low-voltage air arc plasma during contact opening process[J].Transactions of China Electrotechnical Society,2008,23(5):12-17.
[8] Uhm H S,Byeon Y S,Song K B,et al.Analytical investigation of electrical breakdown properties in a nitrogen-SF₆ mixture gas[J].Physics of Plasmas,2010,17(11):113510-113510-8.
[9] Bini R,Mahdizadeh N,Seeger M,et al.Measurements and simulation of the dielectric recovery in a SF₆ circuit breaker[C].17th International Conference on Gas Discharges and Their Applications,Cardiff,2008:113-116.
[10]Wu Yi,Rong Mingzhe,Sun Zhiqiang,et al.Numerical analysis of arc plasma behavior during contact opening process in low-voltage switching device[J].Journal of Physics D:Applied Physics,2007,40(3):795-802.
[11]荣命哲,杨茜,范春朵.高压自能式SF₆断路器电弧能量作用过程仿真[J].中国电机工程学报,2004,24(2):92-97.
Rong Mingzhe,Yang Qian,Fan Chunduo.Simulation of the process of arc energy-effect in H.V.auto-expansion SF₆ circuit breaker[J].Power of the CSEE,2004,24(2):92-97.
[12]刘卫东,吴俊勇,黄瑜珑,等.SF₆断路器强电流开断喷管内压力测量[J].中国电机工程学报,2010,30(7):131-136.
Liu Weidong,Wu Junyong,Huang Yulong,et al.Pressure measurement in SF₆ circuit breaker’s nozzle in heavy current interruption[J].Power of the CSEE,2010,30(7):131-136.
[13]林莘,钟建英.自能式断路器灭弧室气流场计算的一种新思路[J].中国电机工程学报,2003,23(10):164-168.
Lin Xin,Zhong Jianying.A new thought for computation of gas flow field in the arc-quenching chamber of self-blasting circuit breaker[J].Proceeding of the CSEE,2003,23(10):164-168.
[14]林莘,刘克彬.自能式SF₆断路器在不同气压和操作功下灭弧室压力特性计算[J].电网技术,2007,40(10):22-25.
Lin Xin,Liu Kebin.Puffer characteristic calculation in different initial gas pressure and operating force of self-extinguishing SF₆ circuit breaker[J].Power System Technology,2007,40(10):22-25.
[15]马强,荣命哲,Murphy Anthony B,等.考虑器壁侵蚀影响的低压断路器电弧运动特性仿真及实验[J].电工技术学报,2009,24(12):74-81.
Ma Qiang,Rong Mingzhe,Murphy Anthony B,et al.Simulation and experiment on air arc characteristics in low-voltage circuit breaker considering wall ablation[J].Transactions of China Electrotechnical Society,2009,24(12):74-81.
[16]荣命哲,刘定新,李美,等.非平衡态等离子体的仿真研究现状与新进展[J].电工技术学报,2014,29(6):271-282.
Rong Mingzhe,Liu Dingxin,Li Mei,et al.Research status and new progress on the numerical simulation of non-equilibrium plasmas[J].Transactions of China Electrotechnical Society,2014,29(6):271-282.
[17]Isaac L T,Jones G R,Humphries J E,et al.Monitoring particle concentrations produced by arcing in SF₆ circuit breakers using a chromatic modulation probe[J].IEEE Proceedings Science Measurement and Technology,1999,146(4):199-204.
[18]Schade E,Regaller K.Dielectric recovery of an axially blown SF₆ arc after current zero:Part I-experimental investigations[J].IEEE Transactions on Plasma Science,1982,10(3):141-153.
[19]Regaller K,Egli W, Brand K P.Dielectric recovery of an axially blown SF₆ arc after current zero:Part Ⅱ-theoretical investigations[J].IEEE Transactions on Plasma Science,1982,10(3):154-162.
[20]王飞鸣,林莘,徐建源.高压SF₆断路器非平衡态等离子体电弧的熄弧特性[J].高电压技术,2014,40(10):3073-3084.
Wang Feiming,Lin Xin,Xu Jianyuan.Extinction characteristics of non-equilibrium plasma arc in high-voltage SF₆ circuit breaker[J].High Voltage Engineering,2014,40(10):3073-3084.
[21]林莘,李鑫涛,王飞鸣,等.触头烧损对SF₆断路器介质恢复特性的影响[J].高电压技术,2014,40(10):3125-3134.
Lin Xin,Li Xintao,Wang Feiming,et al.Dielectric recovery characteristics of SF₆ circuit breaker considering contact burning loss[J].High Voltage Engineering,2014,40(10):3125-3134.
[22]魏俊梅.800kV SF₆高压断路器的研究与开发[D].沈阳:沈阳工业大学,2008.
[23]马强,荣命哲,Murphy Anthony B,等.考虑电机烧蚀影响的低压断路器电弧运动特性仿真及实验[J].中国电机工程学报,2009,29(3):115-120.
Ma Qiang,Rong Mingzhe,Murphy Anthony B,et al.Simulation and experiment research on air arc movement characteristics in low-voltage circuit breaker considering electrodes erosion[J].Power of the CSEE,2009,29(3):115-120.
[24]Vahid A,Ahmad G,Kaveh N.Three-dimensional simulation of plasma deformation during contact opening in a circuit breaker,including the analysis of kink instability and sausage instability[J].Plasma Science and Technology,2012,14(11):996-1001.
[25]朱凯,李兴文,赵虎,等.高压气体断路器弧后电流特性的实验研究[J].中国电机工程学报,2014,34(21):3512-3517.
Zhu Kai,Li Xingwen,Zhao Hu,et al.Experimental study on characteristics of post-arc current of high voltage gas circuit breaker[J].Power of the CSEE,2014,34(21):3512-3517.
[26]方春恩,梁鸣华,庞力,等.断路器相控开断短路电流智能控制装置研究[J].电力系统保护与控制,2012,40(23):138-144.
Fang Chunen,Liang Minghua,Pang Li,et al.Research on intelligent control unit for circuit breakers controlled fault interruption[J].Power System Protection and Control,2012,40(23):138-144.
[27]杜书平,吴俊芳,赵敏,等.SF₆弹簧操作机构断路器与重合闸配合问题的浅析[J].电力系统保护与控制,2009,37(19):122-126.
Du Shuping,Wu Junfang,Zhao Min,et al.Analysis of SF₆ circuit breaker with spring operating mechanism fitting for reclosure[J].Power System Protection and Control,2009,37(19):122-126.
[28]Anderson John D,Jr.Computational fluid dynamics:the basics with applications[M].New York:R.R.Donnelley & Sons Company,1995.