Abstract：This paper proposed a transverse flux permanent magnet linear machine (PMLM) with the class distribution of the stator core group arrangement in the axial direction, due to the problem of larger thrust force ripple in transverse flux PMLM, which has some merits higher force density and better controllable characteristic etc. Firstly, the structure and operating principle of transverse flux PMLM was presented. Secondly, the influence of the class distribution of the stator core group arrangement on the motor performance is analyzed in detail. Special attention was paid to the back-EMF, cogging force and electromagnetic force etc. The paper investigated the influence of different arrangements in transverse flux PMLM, including theoretical analysis and numerical calculation. The results show that the thrust ripple can be decreased by the class distribution of the stator core group arrangement in transverse flux PMLM.
赵玫, 邹继斌, 王骞. 定子单元铁心轴向类分布排列的横向磁通永磁直线电机[J]. 电工技术学报, 2013, 28(11): 106-111.
Zhao Mei, Zou Jibin, Wang Qian. Transverse Flux PMLM with Class Distribution of the Stator Core Group Arrangement in the Axial Direction. Transactions of China Electrotechnical Society, 2013, 28(11): 106-111.
[1] 罗宏浩, 吴峻, 常文森. 动磁式永磁无刷直流直线电机的齿槽力最小化[J]. 中国电机工程学报, 2007, 27(6): 12-16. Luo Honghao, Wu Jun, Chang Wensen. Minimization of cogging force in moving magnet type PMBLDCLM [J]．Proceedings of the CSEE, 2007, 27(6): 12-16. [2] Zou Jibin, Wang Qian, Xu Yongxiang. Influence of permanent magnet magnetization length on the performance of a tubular transverse flux permanent magnet linear machine used for electromagnetic launch[J]. IEEE Transactions on Plasma Science, 2011, 39(1): 241-246. [3] Zhao Mei, Zou Jiming, Xu Yongxiang, et al. The thrust characteristic investigation of transverse flux tubular linear machine for electromagnetic launcher[J]. IEEE Transactions on Plasma Science, 2011, 39(3): 925-930. [4] Do Hyun Kang, Herbert Weh. Design of an integrated propulsion, guidance, and levitation system by magnetically excited transverse flux linear motor[J]. IEEE Transactions on Energy Converters, 2004, 19(3): 477-484. [5] Chang J H, Kang D H, Lee J Y, et al. Development of transverse flux linear motor with permanent magnet excitation for direct drive applications[J]. IEEE Transactions on Magnetics, 2005, 41(5): 1936-1939. [6] Do Kwan Hong, Byung Chul Woo, Dae Hyun Koo, et al. Optimum design of transverse flux linear motor for weight reduction and improvement thrust force using response surface methodology[J]. IEEE Transactions on Magnetics, 2008, 44(11): 4317-4320. [7] 李鹏. 双向交链横向磁通圆筒型直线永磁同步电机的基础研究[D]. 哈尔滨: 哈尔滨工业大学, 2011. [8] 寇宝泉, 杨国龙, 周维正, 等. 双向交链横向磁通平板型永磁直线同步电机[J]. 中国电机工程学报, 2012, 32(33): 75-81. Kou Baoquan, Yang Guolong, Zhou Weizheng, et al. Bidirectional crosslinking transverse flux flat type permanent magnet linear synchronous motor[J]. Proceedings of the CSEE, 2012, 32(33): 75-81. [9] Zou Jibin, Zhao Mei. Development and analysis of tubular transverse flux machine with permanent magnet excitation[J]. IEEE Transactions on Industrial Electronics, 2012, 59(5): 2198-2207. [10] 邹继斌, 王骞, 张洪亮. 横向磁场永磁直线电机电磁力的分析与计算[J]．电工技术学报, 2007, 22(8): 126-130. Zou Jibin, Wang Qian, Zhang Hongliang. Analysis and calculation of the electromagnetic force of transverse flux permanent magnet linear machines [J]．Transactions of China Electrotechnical Society, 2007, 22(8): 126-130. [11] Anpalaham P. Design of transverse flux machines using analytical calculations and finite element analysis[D]. Stockholm: Royal Institute of Technology (KTH), 1999. [12] 李庆雷, 王先逵. 永磁同步直线电机推力波动分析及改善措施[J]. 清华大学学报, 2000, 40(5): 33-36. Li Qinglei, Wang Xiankui. Analysis of thrust force ripple in permanent magnet synchronous linear motor[J]. Journal of Tsinghua University(Sci& Tech), 2000, 40(5): 33-36.
2013, Vol. 28 
