Abstract：A novel analysis approach to energy-consumed braking phase trajectory (ECBPT) of induction motor based on Bang-Bang optimal theory is presented in this paper. Because the braking torque is a function of the rotor speed, the phase trajectory of conventional direct-current braking method (CDCB) move along the cluster of the optimal switching curves and converge to the origin, so that the time cost of the CDCB is much more than the optimal time cost. From deep derivation of the ECBPT equation, the variable-current braking method (VCB) which will approach the ECBPT to the optimal switching curve well is proposed. The result of simulation and experiment show that the proposed method VCB works much better than CDCB on time cost, instantaneous peak current and energy loss while braking. Due to the quite small energy loss in braking, VCB is especially suitable to induction motors which have higher power, and it also can effectively prevent the motor from over-current, over-heating and other problems when fast braking.
张寅孩, 葛金法, 汪松松. 基于Bang-Bang最优理论的感应电机能耗制动相轨迹分析[J]. 电工技术学报, 2011, 26(2): 74-80.
Zhang Yinhai, Ge Jinfa, Wang Songsong. Energy-Consumed Braking Phase Trajectory of Induction Motor Based on Bang-Bang Optimal Theory. Transactions of China Electrotechnical Society, 2011, 26(2): 74-80.
[1] 罗德荣, 江岳春, 邓建国. 三相异步电动机能耗制动的数值仿真[J]. 微特电机, 2002(2)：26-28. Luo Derong, Jiang Yuechun, Deng Jianguo. Numerical simulation of energy loss braking for 3-phase asynchronous motor[J]. Small & Special Electrical Machines, 2002(2)：26-28. [2] 张文兵, 黄一彦. 异步电动机制动方式比较[J]. 微电机, 2006, 39(8)：91-92. Zhang Wenbing, Huang Yiyan. The comparison of braking mode of induction motor[J]. Micromotors, 2006, 39(8)：91-92. [3] 张淼, 冯垛生. 一种新颖的能耗制动方法[J]. 电力电子技术, 1996(1)：42-43. Zhang Miao, Feng Duosheng. A novel method of energy consumed braking[J]. Power Electronics, 1996(1)：42-43. [4] Mahesh M Swamy, Tsuneo(Joe) Kume, et al. A novel stopping method for induction motors operating from variable frequency drives[J]. IEEE Trans. on Power Electronics, 2004, 19(4): 1100-1107. [5] Mukul Rastogi, Peter W Hammond. Dual-frequency braking in AC drives[J]. IEEE Trans. on Power Electronics, 2002, 17(6): 1032-1040. [6] 王云飞, 杨耕. 通用变频器-感应电机系统的电机耗能型制动控制方法[J]. 电工技术学报, 2006, 21(1)：12-18. Wang Yunfei, Yang Geng. Power loss braking method for general inverter-fed induction motor drives[J]. Transactions of China Electrotechnical Society, 2006, 21(1)：12-18. [7] Chang S Y, Huang T L, Huang T Y. Fuzzy bang-bang controller for servo systems VIA optimal path estimation method[C]. IEEE Proceedings of International Conference on Power Electronics and Drive systems, 1995: 208-211. [8] Laura Poggiolini, Gianna Stefani. Minmum time optimality of a bang-bang trajectory[C]. IEEE Conference on Decision and Control, 2002: 1922- 1925. [9] Zhang Yinhai, Xiong Yu, Li Yuling, et al. A low-cost time optimum position control system of induction motor[C]. IEEE Power Electronics Specialists Conference, 2004: 3321-3324. [10] Harnefors L, Pietiläinen K, Gertmar L. Torquemaximizing field-weakening control: design, analysis, and parameter selection[J]. IEEE Trans. on Industrial Electronics, 2001, 48(1): 161-168. [11] Marko Hinkkanen, Jorma Luomi. Braking scheme for vector-controlled induction motor drives equipped with diode rectifier without braking resistor[J]. IEEE Trans. on Industry Applications, 2006, 42(5): 1257- 1263.
2011, Vol. 26 
