Abstract：Sensorless control technology is applied to improve the reliability of permanent magnet synchronous motor (PMSM) drive system and reduce system cost, which has become a hot topic and cutting-edge technology. The high-frequency signal injection method utilizes the motor saliency to estimate the rotor position. It is independent on the back electromotive force, and is very suitable for zero and low speed operation of PMSM drives. In this paper, the high-frequency voltage signal injection methods are investigated and summarized, which can be classified into three catalogues, i.e., conventional high-frequency sinusoidal injection method, improved high-frequency sinusoidal injection method and high-frequency non-sinusoidal injection method. The typical implementation scheme of each method is introduced, meanwhile the advantages and disadvantages of the scheme are pointed out. Then, the similarities and differences of these three kinds of methods are analyzed and compared. Finally, the development trend of the sensorless control technology of PMSM drives based on high-frequency signal injection is prospected.
李浩源, 张兴, 杨淑英, 李二磊. 基于高频信号注入的永磁同步电机无传感器控制技术综述[J]. 电工技术学报, 2018, 33(12): 2653-2664.
Li Haoyuan, Zhang Xing, Yang Shuying, Li Erlei. Review on Sensorless Control of Permanent Magnet Synchronous Motor Based on High-Frequency Signal Injection. Transactions of China Electrotechnical Society, 2018, 33(12): 2653-2664.
[1] Lee J H, Lee J H, Park J H, et al.Field-weakening strategy in condition of DC-link voltage variation using on electric vehicle of IPMSM[C]//International Conference on Electrical Machines and Systems, Beijing, 2011: 1-6. [2] 李旭春, 张鹏, 严乐阳, 等. 具有参数辨识的永磁同步电机无位置传感器控制[J]. 电工技术学报, 2016, 31(14): 139-147. Li Xuchun, Zhang Peng, Yan Leyang, et al.Sensor- less control of permanent magnet synchronous motor with online parameter identification[J]. Transactions of China Electrotechnical Society, 2016, 31(14): 139-147. [3] 李和明, 董淑惠, 王毅, 等. 永磁直驱风电机组低电压穿越时的有功和无功协调控制[J]. 电工技术学报, 2013, 28(5): 73-81. Li Heming, Dong Shuhui, Wang Yi, et al.Coordinated control of active and reactive power of PMSG-based wind turbines for low voltage ride through[J]. Transactions of China Electrotechnical Society, 2013, 28(5): 73-81. [4] 王子辉. 永磁同步电机全速度范围无位置传感器控制策略研究[D]. 杭州: 浙江大学, 2012. [5] Sun W, Yu Y, Wang G L, et al.Design method of adaptive full order observer with or without estimated flux error in speed estimation algorithm[J]. IEEE Transactions on Power Electronics, 2016, 31(3): 2609-2626. [6] 祝晓辉, 李颖晖, 陈亚滨. 基于非线性状态观测器的永磁同步电动机无位置传感器矢量控制[J]. 电工技术学报, 2010, 25(1): 50-57. Zhu Xiaohui, Li Yinghui, Chen Yabin.Sensorless vector control for PMSM based on nonlinear state observer[J]. Transactions of China Electrotechnical Society, 2010, 25(1): 50-57. [7] 陆婉泉, 林鹤云, 韩俊林. 永磁同步电机的扰动观测器无位置传感器控制[J]. 中国电机工程学报, 2016, 36(5): 1387-1394. Lu Wanquan, Lin Heyun, Han Junlin.Position sensorless control of permanent magnet synchronous machine using a disturbance observer[J]. Proceedings of the CSEE, 2016, 36(5): 1387-1394. [8] Zhao Yue, Zhang Zhe, Qiao Wei, et al.An extended flux model-based rotor position estimator for sensorless control of salient-pole permanent magnet synchronous machines[J]. IEEE Transactions on Power Electronics, 2015, 30(8): 4412-4422. [9] 魏海峰, 韦汉培, 张懿. 考虑逆变器输出谐波的永磁同步电机转子位置估计误差分析[J]. 电工技术学报, 2018, 33(4): 900-909. Wei Haifeng, Wei Hanpei, Zhang Yi.Error analysis of rotor position estimation for permanent magnet synchronous motor considering output harmonics of inverter[J]. Transactions of China Electrotechnical Society, 2018, 33(4): 900-909. [10] 刘计龙, 肖飞, 沈洋, 等. 永磁同步电机无位置传感器控制技术研究综述[J]. 电工技术学报, 2017, 32(16): 76-88. Liu Jilong, Xiao Fei, Shen Yang, et al.Position- sensorless control technology of permanent-magnet synchronous motor-a review[J]. Transactions of China Electrotechnical Society, 2017, 32(16): 76-88. [11] 李槐树. 永磁同步电机开环控制系统稳定性的数学推导与分析[J]. 电工技术学报, 2014, 29(1): 36-43. Li Huaishu. Mathematical deduction and stability analysis of PMSM open-loop control system[J]. Transactions of China Electrotechnical Society, 2014, 29(1): 36-43. [12] 张国强, 王高林, 徐殿国, 等. 基于自适应陷波滤波器的内置式永磁电机转子位置观测方法[J]. 中国电机工程学报, 2016, 36(9): 2521-2527. Zhang Guoqiang, Wang Gaolin, Xu Dianguo, et al.Adaptive notch filter based rotor position estimation for interior permanent magnet synchronous motors[J]. Proceedings of the CSEE, 2016, 36(9): 2521-2527. [13] 刘景林, 鲁家栋. 基于相电流正负序分量相角差的高精度内置式永磁同步电机转子初始位置检测方法[J]. 电工技术学报, 2016, 31(23): 63-69. Liu Jinglin, Lu Jiadong.High-precision estimation method of initial rotor position for IPMSM based on phase difference of positive and negative sequence current component[J]. Transactions of China Elec- trotechnical Society, 2016, 31(23): 63-69. [14] Jansen P L, Lorenz R D.Transducerless position and velocity estimation in induction and salient AC machines[J]. IEEE Transactions on Industry Appli- cations, 1995, 31(2): 240-247. [15] Jang I H, Sul S K, Ha J I, et al.Sensorless drive of surface-mounted permanent-magnet motor by high- frequency signal injection based on magnetic saliency[J]. IEEE Transactions on Industry Applications, 2003, 39(4): 1031-1039. [16] 尹忠刚, 张彦平, 张延庆, 等. 采用免疫高频脉动信号注入的PMSM转速辨识方法[J]. 电工技术学报, 2016, 31(2): 243-254. Yin Zhonggang, Zhang Yanping, Zhang Yanqing, et al.High frequency pulsating signal injection for permanent magnets synchronous machines based o immune altorithm[J]. Transactions of China Elec- trotechnical Society, 2016, 31(2): 243-254. [17] 刘颖. 永磁同步电机脉振高频信号注入无位置传感器技术研究[D]. 南京: 南京航空航天大学, 2012. [18] 田士侠. 高频注入法永磁同步电机转子位置检测方法研究[D]. 济南: 山东大学, 2010. [19] Raca D, Harke M C, Lorenz R D.Robust magnet polarity estimation for initialization of PM synchronous machines with near-zero saliency[J]. IEEE Transactions on Industry Applications, 2008, 44(4): 1199-1209. [20] Liu J M, Zhu Z Q.Novel sensorless control strategy with injection of high-frequency pulsating carrier signal into stationary reference frame[J]. IEEE Transactions on Industry Applications, 2014, 50(4): 2574-2583. [21] Liu J M, Zhu Z Q.Sensorless control strategy by square-waveform high-frequency pulsating signal injection into stationary reference frame[J]. IEEE Journal of Emerging & Selected Topics in Power Electronics, 2014, 2(2): 171-180. [22] Tang Q, Shen A, Luo X, et al.IPMSM sensorless control by injecting bi-directional rotating HF carrier signals[J]. IEEE Transactions on Power Electronics, 2018, DOI: 10.1109/TPEL.2018.2811126. [23] Luo X, Tang Q, Shen A, et al.PMSM sensorless control by injecting HF pulsating carrier signal into estimated fixed-frequency rotating reference frame[J]. IEEE Transactions on Industrial Electronics, 2016, 63(4): 2294-2303. [24] Raca D, Garcia P, Reigosa D, et al, A comparative analysis of pulsating vs. rotating vector carrier signal injection-based sensorless control[C]//Twenty-Third Annual IEEE Applied Power Electronics Conference and Exposition, Austin, TX, 2008: 879-885. [25] 刘颖, 周波, 冯瑛, 等. 基于脉振高频电流注入SPMSM低速无位置传感器控制[J]. 电工技术学报, 2012, 27(7): 139-145. Liu Ying, Zhou Bo, Feng Ying, et al.Sensorless control of SPMSM based on high frequency current signal injection in the direct axis at low and zero speed[J]. Transactions of China Electrotechnical Society, 2012, 27(7): 139-145. [26] 刘兵, 周波, 倪天恒, 等. 基于广义二阶积分器的表贴式永磁同步电机低速转子位置检测方法[J]. 电工技术学报, 2017, 32(23): 23-33. Liu Bing, Zhou Bo, Ni Tianheng, et al.A novel position observer for SPMSM sensorless control based on second-order generalized integrators[J]. Transactions of China Electrotechnical Society, 2017, 32(23): 23-33. [27] Tang Q, Shen A, Luo X, et al.PMSM sensorless control by injecting HF pulsating carrier signal into ABC frame[J]. IEEE Transactions on Power Elec- tronics, 2017, 32(5): 3767-3776. [28] 李孟秋,王龙. 一种改进的永磁同步电机低速无位置传感器控制策略[J]. 电工技术学报, 2018, 33(9): 1967-1974. Li Mengqiu, Wang Long.An improved low speed sensorless control strategy for permanent magnet synchronous motor[J]. Transactions of China Electro- technical Society, 2018, 33(9): 1967-1974. [29] 吕晓源, 刘刚, 毛琨, 等. 基于虚拟脉振高频注入法的永磁电机初始位置检测[J]. 电工技术学报, 2017, 32(23): 34-41. Lü Xiaoyuan, Liu Gang, Mao Kun, et al.Initial position detection of permanent magnet motor based on virtual pulsating high-frequency injection method[J]. Transactions of China Electrotechnical Society, 2017, 32(23): 34-41. [30] Xu P L, Zhu Z Q.Initial rotor position estimation using zero-sequence carrier voltage for permanent- magnet synchronous machines[J]. IEEE Transactions on Industrial Electronics, 2017, 64(1): 149-158. [31] Garcia P F, Briz M, Degner W, et al.Accuracy, bandwidth, and stability limits of carrier-signal- injection-based sensorless control methods[J]. IEEE Transactions on Industry Application, 2017, 43(4): 990-1000. [32] Xu P L, Zhu Z Q.Novel square-wave signal injection method using zero-sequence voltage for sensorless control of PMSM drives[J]. IEEE Transactions on Industrial Electronics, 2016, 63(12): 7444-7454. [33] Almarhoon A H, Zhu Z Q, Xu P L.Improved rotor position estimation accuracy by rotating carriers signal injection utilizing zero-sequence carrier voltage for dual three-phase PMSM[J]. IEEE Transactions on Industrial Electronics, 2017, 64(6): 4454-4462. [34] Masaki R, Kaneko S, Hombu M, et al.Development of a position sensorless control system on an electric vehicle driven by a permanent magnet synchronous motor[C]//Process Power Conversion Conference, Osaka, Japan, 2002: 571-576. [35] Yang S, Yang S M, Hu J H.Design consideration on the square-wave voltage injection for sensorless drive of interior permanent-magnet machines[J]. IEEE Transactions on Industrial Electronics, 2017, 64(1): 159-168. [36] Ni R, Xu D, Blaabjerg F, et al.Square-wave voltage injection algorithm for PMSM position sensorless control with high robustness to voltage errors[J]. IEEE Transactions on Power Electronics, 2017, 32(7): 5425-5437. [37] 张航, 刘卫国, 彭纪昌, 等. 基于方波电压信号注入的表贴式永磁同步电机饱和凸极性响应分析及转子位置估计[J]. 电工技术学报, 2017, 32(16): 106-114. Zhang Hang, Liu Weiguo, Peng Jichang, et al.Saturation saliency response analysis and rotor position estimation based on square-wave voltage signal injection for surface-mounted permanent magnet synchronous motor[J]. Transactions of China Electrotechnical Society, 2017, 32(16): 106-114. [38] 张国强, 王高林, 徐殿国. 基于无滤波器方波信号注入的永磁同步电机初始位置检测方法[J]. 电工技术学报, 2017, 32(13): 162-168. Zhang Guoqiang, Wang Gaolin, Xu Dianguo.Filterless square-wave injection based initial position detection for permanent magnet synchronous machines[J]. Transactions of China Electrotechnical Society, 2017, 32(13): 162-168. [39] Xu P L, Zhu Z Q.Novel square-wave signal injection method using zero-sequence voltage for sensorless control of PMSM drives[J]. IEEE Transactions on Industrial Electronics, 2016, 63(12): 7444-7454. [40] 许培林, 邓智泉, 王宇, 等. 12/10极永磁磁通切换电机转子初始位置检测[J]. 中国电机工程学报, 2013, 33(9): 104-114. Xu Peilin, Deng Zhiquan, Wang Yu, et al.Initial rotor position detection of 12/10 flux-switching permanent magnet motors[J]. Proceedings of the CSEE, 2013, 33(9): 104-114. [41] 许培林, 邓智泉, 王宇, 等. 基于脉振高频正弦信号注入的12/10极永磁磁通切换电机无位置传感器技术[J]. 电工技术学报, 2013, 28(增刊1): 307-313. Xu Peilin, Deng Zhiquan, Wang Yu, et al.Sensorless drive of 12/10 flux-switching permanent magnet motor with high-frequency pulsating sinusoidal signal injection[J]. Transactions of China Electro- technical Society, 2013, 28(S1): 307-313. [42] 张国强. 内置式永磁同步电机无位置传感器控制研究[D]. 哈尔滨: 哈尔滨工业大学, 2017. [43] Gong L M, Zhu Z Q.Robust initial rotor position estimation of permanent-magnet brushless AC machines with carrier-signal-injection-based sensor- less control[J]. IEEE Transactions on Industry Applications, 2013, 49(6): 2602-2609. [44] Holtz J.Acquisition of position error and magnet polarity for sensorless control of PM synchronous machines[J]. IEEE Transactions on Industry Appli- cations, 2008, 44(4): 1172-1180. [45] 刘景林, 鲁家栋. 基于相电流正负序分量相角差的高精度内置式永磁同步电机转子初始位置检测方法[J]. 电工技术学报, 2016, 31(23): 63-69. Liu Jinglin, Lu Jiadong.High-precision estimation method of initial rotor position for IPMSM based on phase difference of positive and negative sequence current component[J]. Transactions of China Electro- technical Society, 2016, 31(23): 63-69. [46] Kim H, Huh K K, Lorenz R D, et al.A novel method for initial rotor position estimation for IPM synchronous machine drives[J]. IEEE Transactions on Industry Applications, 2004, 40(5): 1369-1378. [47] 李洁, 周波, 刘兵, 等. 表贴式永磁同步电机无位置传感器起动新方法[J]. 中国电机工程学报, 2016, 36(9): 2513-2520. Li Jie, Zhou Bo, Liu Bing, et al.A novel starting strategy of sensorless control for surface mounted permanent magnet synchronous machines[J]. Pro- ceedings of the CSEE, 2016, 36(9): 2513-2520. [48] Gong L M, Zhu Z Q.Robust initial rotor position estimation of permanent-magnet brushless AC machines with carrier-signal-injection-based sensor- less control[J]. IEEE Transactions on Industry Applications, 2013, 49(6): 2602-2609. [49] 刘颖, 周波, 冯瑛, 等. 永磁同步电机低速无传感器控制及位置估计误差补偿[J]. 电工技术学报, 2012, 27(11): 38-45. Liu Ying, Zhou Bo, Feng Ying, et al.Sensorless control of SPMSM based on high frequency current signal injection in the direct axis at low and zero speed[J]. Transactions of China Electrotechnical Society, 2012, 27(11): 38-45. [50] 刘兵, 周波, 倪天恒. 基于广义二阶积分器的SPMSM无位置传感器控制逆变器非线性补偿策略[J]. 中国电机工程学报, 2018, DOI: 10.13334/j.0258- 8013.pcsee.170081. Liu Bing, Zhou Bo, Ni Tianheng.Inverter nonlin- earity compensation for SPMSM sensor-less control based on second-order generalized integrator[J]. Proceedings of the CSEE, 2018, DOI: 10.13334/ j.0258-8013.pcsee.170081. [51] Guerrero J M, Leetmaa M, Briz F, et al.Inverter nonlinearity effects in high-frequency signal- injection-based sensorless control methods[J]. IEEE Transactions on Industry Applications, 2005, 41(2): 618-626. [52] 刘家曦, 李立毅, 杜鹏程. 考虑磁场交叉耦合的内嵌式永磁同步电机初始位置检测技术[J]. 电工技术学报, 2013, 28(7): 32-38. Liu Jiaxi, Li Liyi, Du Pengcheng.Initial rotor position estimation considering magnetic crosss- coupling based on IPMSM[J]. Transactions of China Electrotechnical Society, 2013, 28(7): 32-38. [53] Reigosa D D, Garcia P, Briz F, et al.Modeling and adaptive decoupling of high-frequency resistance and temperature effects in carrier-based sensorless control of PM synchronous machines[J]. IEEE Transactions on Industry Applications, 2010, 46(1): 139-149. [54] Degner M W, Lorenz R D.Using multiple saliencies for the estimation of flux, position, and velocity in AC machines[J]. IEEE Transactions on Industry Applications, 1998, 1(5): 1097-1104. [55] 刘兵, 周波. 采用双重滤波补偿的永磁同步电机无位置传感器控制[J]. 中国电机工程学报, 2018, DOI: 10.13334/j.0258-8013.pcsee. Liu Bing, Zhou Bo.Sensor-less control for PMSMs with dual filter compensation[J]. Proceedings of the CSEE, 2018, DOI: 10.13334/j.0258-8013.pcsee. [56] 刘海东, 周波, 郭鸿浩, 等. 脉振高频信号注入法误差分析[J]. 电工技术学报, 2015, 30(6): 38-44. Liu Haidong, Zhou Bo, Guo Honghao, et al.Error analysis of high frequency pulsating signal injection method[J]. Transactions of China Electrotechnical 57 Society, 2015, 30(6): 38-44. [57] 王海兵, 赵荣祥, 汤胜清, 等. 永磁同步电机位置检测偏差对驱动系统性能的影响研究[J]. 电工技术学报, 2018, 33(4): 910-918. Wang Haibing, Zhao Rongxiang, Tang Shengqing, et al.Research on the influence of the position detection error to the PMSM drive system[J]. Transactions of China Electrotechnical Society, 2018, 33(4): 910-918. [58] 陈坤, 王辉, 吴轩, 等. 一种新型的内置式永磁同步电机无位置传感器低速控制策略[J]. 中国电机工程学报, 2017, 37(20): 6083-6091. Chen Kun, Wang Hui, Wu Xuan, et al.A novel position sensorless control for interior permanent magnet synchronous motor at low speed[J]. Pro- ceedings of the CSEE, 2017, 37(20): 6083-6091. [59] 田兵, 安群涛, 孙东阳, 等. 基于磁饱和效应的表贴式永磁同步电机初始位置检测方法[J]. 电工技术学报, 2016, 31(1): 155-164. Tian Bing, An Quntao, Sun Dongyang, et al.Initial position estimation for surface permanent magnet synchronous motors based on magnetic saturation effect[J]. Transactions of China Electrotechnical Society, 2016, 31(1): 155-164. [60] Wang G, Yang L, Yuan B, et al.Pseudo-random high-frequency square-wave voltage injection based sensorless control of IPMSM drives for audible noise reduction[J]. IEEE Transactions on Industrial Elec- tronics, 2016, 63(12): 7423-7433. [61] Wang G, Yang L, Zhang G, et al.Comparative investigation of pseudorandom high-frequency signal injection schemes for sensorless IPMSM drives[J]. IEEE Transactions on Power Electronics, 2017, 32(3): 2123-2132.
2018, Vol. 33 
