一种基于多谐振开关槽与Buck-Boost电路的准并联变换器

doi:10.19595/j.cnki.1000-6753.tces.230918

Abstract
Figure/Table
References
Related Citation (7)

Download: PDF (28786 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract With the rapid development of 5G communication, big data, artificial intelligence, and other emerging information technologies, data centers are becoming the critical infrastructure with rapid increases in application scale and power demand. The intermediate bus converter (IBC) is a critical power stage in the power supply architecture. Resonant switched capacitor converters (RSCCs) have the advantages of high efficiency, small size, lightweight, and potential for integration, which are suitable for IBC. This paper investigates an IBC based on the resonant switched capacitor to achieve high efficiency, low cost, and voltage regulation.
Firstly, the conventional 2X step-down RSCC is investigated, and its working principle and voltage gain characteristics for zero-current turn-off operation are analyzed. However, it has shortcomings in the fixed voltage ratio and the susceptibility of the soft switching characteristics to resonant parameters. The simulation shows the resonant frequency drifts due to the tolerance of components, and the switches have hard turning-off problems, thus reducing the efficiency of the converter. The influence of component variation on the converter is analyzed by deducing the time-domain expression of the resonant current.
Therefore, a multi-resonant switched capacitor converter (MRSCC) with high immunity toward component variation is introduced. The converter realizes the lossless reverse of the residual current in the resonant inductor within the dead time using the band-stop characteristic of the notch resonant frequency. The Class II ceramic capacitor can be used as the resonant component, which reduces the production cost. In order to meet different voltage conversion requirements of IBC, the multi-resonant switched tank converter (MRSTC) has been developed, and the basis and procedure for parameter design are proposed.
Regarding the poor voltage regulation capability of convention RSCCs, an IBC based on quasi-parallel is investigated by combining MRSTC with a four-switch Buck-Boost (FSBB) converter. The working principle and voltage gain characteristics of the converter are analyzed. A three-mode rough regulation control strategy is proposed to increase the direct power ratio in FSBB. The small signal model and the transfer functions are deduced. The parameters of the closed-loop control system are designed to enhance the voltage regulation ability, thereby achieving output voltage stability.
The results show that the proposed MRSCC is highly immune to component variation. The designed IBC prototype realizes the closed-loop regulation of output voltage while maintaining high efficiency in the range of input voltage and power.

Key words： Intermediate bus converter resonant switched-capacitor converter multi-resonant switched tank converter quasi-parallel architecture

Received: 14 June 2023

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Dai Ruiran
	Ma Yundong
	Wang Peng
	Wang Pengfei

Cite this article:

Dai Ruiran,Ma Yundong,Wang Peng等. A Quasi Parallel Converter Based on Multi Resonant Switched Tank and Buck-Boost Circuit[J]. Transactions of China Electrotechnical Society, 2024, 39(18): 5768-5785.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.230918 OR https://dgjsxb.ces-transaction.com/EN/Y2024/V39/I18/5768

[1] 张玉莹, 曾博, 周吟雨, 等. 碳减排驱动下的数据中心与配电网交互式集成规划研究[J]. 电工技术学报, 2023, 38(23): 6433-6450.
Zhang Yuying, Zeng Bo, Zhou Yinyu, et al.Research on interactive integration planning of data centers and distribution network driven by carbon emission reduction[J]. Transactions of China Electrotechnical Society, 2023, 38(23): 6433-6450.
[2] Fei C, Ahmed M H, Lee F C, et al.Two-stage 48V- 12V/6V-1.8V voltage regulator module with dynamic bus voltage control for light-load efficiency improve- ment[J]. IEEE Transactions on Power Electronics, 2017, 32(7): 5628-5636.
[3] 任小永. 高效率高功率密度通信模块电源技术的研究[D]. 南京: 南京航空航天大学, 2008.
Ren Xiaoyong.Research on high efficiency high power density telecom power supply modules[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2008.
[4] 王汝田, 李辉, 刘闯, 等. 基于开关电容与双降压变换器的三相AC-AC变换器[J]. 电工技术学报, 2022, 37(20): 5241-5252.
Wang Rutian, Li Hui, Liu Chuang, et al.A three-phase AC-AC converter based on switched- capacitor and dual-Buck converter[J]. Transactions of China Electrotechnical Society, 2022, 37(20): 5241-5252.
[5] 陈思哲, 徐梦然, 范元亮, 等. 一种基于开关电容的九电平逆变器[J]. 电工技术学报, 2022, 37(4): 931-941.
Chen Sizhe, Xu Mengran, Fan Yuanliang, et al.A nine-level inverter based on switched-capacitor[J]. Transactions of China Electrotechnical Society, 2022, 37(4): 931-941.
[6] 王要强, 李娜, 赵朝阳, 等. 一种新型多电平逆变器及其模块化分析[J]. 电工技术学报, 2022, 37(18): 4676-4687.
Wang Yaoqiang, Li Na, Zhao Zhaoyang, et al.A new type of multilevel inverter and its modular analysis[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4676-4687.
[7] 李紫薇, 吴学智, 王静, 等. 谐振开关电容变换器磁集成电感设计[J]. 电工技术学报, 2022, 37(24): 6230-6238.
Li Ziwei, Wu Xuezhi, Wang Jing, et al.Design of magnetic integrated inductor for resonant switched capacitor converter[J]. Transactions of China Elec- trotechnical Society, 2022, 37(24): 6230-6238.
[8] Tang Jun, Guo Tian, Kim J S, et al.A current-mode four-phase synchronous Buck converter with dynamic dead-time control[J]. IEEE Access, 2021, 9: 81078-81088.
[9] Law K K, Cheng K W E, Yeung Y P B. Design and analysis of switched-capacitor-based step-up resonant converters[J]. IEEE Transactions on Circuits and Systems I: Regular Papers, 2005, 52(5): 943-948.
[10] Ye Zichao, Lei Yutian, Pilawa-Podgurski R C N. The cascaded resonant converter: a hybrid switched- capacitor topology with high power density and efficiency[J]. IEEE Transactions on Power Elec- tronics, 2020, 35(5): 4946-4958.
[11] Li Yongjun, John M, Ramadass Y, et al.AC-coupled stacked dual-active-bridge DC-DC converter for inte- grated lithium-ion battery power delivery[J]. IEEE Journal of Solid-State Circuits, 2019, 54(3): 733-744.
[12] Li Yanchao, Ni Ze, Liu Chengkun, et al.A 100kW switched-tank converter for electric vehicle appli- cation[C]//2019 IEEE Applied Power Electronics Conference and Exposition (APEC), Anaheim, CA, USA, 2019: 1690-1697.
[13] 管乐诗, 温兆亮, 许晓志, 等. 适用于宽增益范围的可重构单级DC-DC变换器及其磁元件设计[J]. 电工技术学报, 2023, 38(6): 1571-1583.
Guan Yueshi, Wen Zhaoliang, Xu Xiaozhi, et al.A modular reconfigurable single-stage DC-DC converter suitable for wide gain range and its magnetic design[J]. Transactions of China Electrotechnical Society, 2023, 38(6): 1571-1583.
[14] Stauth J T, Kesarwani K, Schaef C. A distributed photovoltaic energy optimization system based on a sub- module resonant switched-capacitor implementation[C]//2012 15th International Power Electronics and Motion Control Conference (EPE/PEMC), Novi Sad, Serbia, 2012: LS2d.2-1-LS2d.2-6.
[15] Cao Dong, Peng Fangzheng.A family of zero current switching switched-capacitor DC-DC converters[C]// 2010 Twenty-Fifth Annual IEEE Applied Power Electronics Conference and Exposition (APEC), Palm Springs, CA, USA, 2010: 1365-1372.
[16] Li Shouxiang, Liang Shengnan, Li Zhenning, et al.A bidirectional resonant two-switch boosting switched- capacitor converter with phase-shift modulation[C]// 2020 IEEE Applied Power Electronics Conference and Exposition (APEC), New Orleans, LA, USA, 2020: 56-60.
[17] 闫成章, 杨晓峰, 刘妍, 等. 基于移相控制的谐振开关电容变换器占空比优化策略[J]. 电工技术学报, 2021, 36(增刊2): 676-687.
Yan Chengzhang, Yang Xiaofeng, Liu Yan, et al.Duty cycle optimization of phase shift control based on resonant switched capacitor converter[J]. Transa- ctions of China Electrotechnical Society, 2021, 36(S2): 676-687.
[18] Liang Jiawei, Wang Haoyu.Light load efficiency Boost technique for switched tank converters based on hybrid ZVS-ZCS control[C]//2022 International Power Electronics Conference (IPEC-Himeji 2022- ECCE Asia), Himeji, Japan, 2022: 2231-2235.
[19] Li Shouxiang, Liang Shengnan, Li Zhenning, et al.A phase-shift-modulated resonant two-switch boosting switched-capacitor converter and its modulation map[J]. IEEE Transactions on Industrial Electronics, 2023, 70(8): 7783-7795.
[20] 谢文浩. 高功率密度全范围调压的谐振开关电容变换器研究[D]. 哈尔滨: 哈尔滨工业大学, 2021.
Xie Wenhao.Resonant switched-capacitor converters with high power density and full-range regulation[D]. Harbin: Harbin Institute of Technology, 2021.
[21] Li Shouxiang, Zhang Ningning, Zheng Shuhua, et al.A dickson resonant switched-capacitor converter with “indirect” resonant core and continuous conversion ratio[C]//2019 IEEE Applied Power Electronics Conference and Exposition (APEC), Anaheim, CA, USA, 2019: 2218-2222.
[22] 丘东元, 张波, 郑春芳, 等. 谐振开关电容变换器新型PWM控制策略[J]. 中国电机工程学报, 2006, 26(2): 116-120.
Qiu Dongyuan, Zhang Bo, Zheng Chunfang, et al.New PWM control method of resonant switched capacitor DC-DC converter[J]. Proceedings of the CSEE, 2006, 26(2): 116-120.
[23] Li Yanchao, Lü Xiaofeng, Cao Dong, et al.A 98.55% efficiency switched-tank converter for data center application[J]. IEEE Transactions on Industry Applications, 2018, 54(6): 6205-6222.
[24] 吴学智, 祁静静, 刘京斗, 等. 谐振开关电容DC/ DC变换器拓扑研究综述[J]. 中国电机工程学报, 2021, 41(2): 655-666.
Wu Xuezhi, Qi Jingjing, Liu Jingdou, et al.Review of topological research on resonant switched capacitor DC/DC converter[J]. Proceedings of the CSEE, 2021, 41(2): 655-666.
[25] Wei Mengxuan, Li Yanchao, Ni Ze, et al.Zero voltage switching switched-tank modular converter for data center application[C]//2019 IEEE 7th Workshop on Wide Bandgap Power Devices and Applications (WiPDA), Raleigh, NC, USA, 2019: 245-250.
[26] Li B C Y, Lü Xiaofeng, Cao Dong. Single-wing resonant multilevel converter featuring reduced number of resonant inductors[C]//2017 IEEE Energy Conversion Congress and Exposition (ECCE), Cincinnati, OH, USA, 2017: 1733-1738.
[27] Jiang Shuai, Saggini S, Nan Chenhao.Switched tank converters[J]. IEEE Transactions on Power Elec- tronics, 2019, 34(6): 5048-5062.
[28] Sovik G, Urkin T, Masandilov E E, et al.Optimal self-tuning control for data-centers’ 48V-12V ZCS- STC[C]//2020 IEEE Applied Power Electronics Conference and Exposition (APEC), New Orleans, LA, USA, 2020: 455-462.
[29] 任小永, 阮新波, 李明秋, 等. 双沿调制的四开关Buck-Boost变换器[J]. 中国电机工程学报, 2009, 29(12): 16-23.
Ren Xiaoyong, Ruan Xinbo, Li Mingqiu, et al.Dual edge modulated four-switch Buck-Boost converter[J]. Proceedings of the CSEE, 2009, 29(12): 16-23.
[30] 刘妍, 杨晓峰, 闫成章, 等. 考虑寄生电感的谐振开关电容变换器电压尖峰抑制[J]. 电工技术学报, 2021, 36(12): 2627-2639.
Liu Yan, Yang Xiaofeng, Yan Chengzhang, et al.Suppression of voltage spike in resonant switched capacitor converter considering parasitic indu- ctance[J]. Transactions of China Electrotechnical Society, 2021, 36(12): 2627-2639.