直流GIS/GIL内微纳粉尘弥散浓度分布特性及对气隙击穿强度的影响

doi:10.19595/j.cnki.1000-6753.tces.240191

Abstract
Figure/Table
References (0)
Related Citation (4)

Download: PDF (1651 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract

In the process of gas insulated switchger/gas insulated metal-enclosed transmission line (GIS/GIL) manufacturing, transportation, and servicing, the unavoidable generation and accumulation of metal dust at the micrometer level and below occur due to reasons such as switch contact collisions and mechanical vibrations. This minute-scale dust is challenging to detect, and its dispersion characteristics are not yet clear, potentially being the fundamental cause of air gap breakdown issues.
The paper begins by investigating the light scattering characteristics of metal dust with particle sizes of 1 000 mesh, 2 000 mesh, 10 000 mesh, 500 nm, and 50 nm. Based on this analysis, a micron-nano dust dispersion concentration detection system suitable for GIS/GIL is designed and built. The obtained dispersion concentration-voltage relationship functions for five particle sizes enable quantitative detection of micron-nano dust within coaxial cylindrical electrodes. This contributes theoretical guidance and technical insights for achieving detection of micron-nano dust dispersion concentration within GIS/GIL.
Experimental results reveal a trend in the dispersion concentration of dust, showing an initial increase followed by a decrease with the rise in voltage level, indicating clear extremum and polarity effects. The dispersion motion of micron-nano dust between coaxial cylindrical electrodes is summarized into three processes: firstly, dust is lifted by forces towards the high-voltage electrode; upon contact with the high-voltage electrode, dust undergoes dispersion back-and-forth motion and some dust adheres to the high-voltage electrode due to various physical forces; after 10 minutes, dust dispersion motion stabilizes, resulting in slightly higher dust concentration compared to before pressurization. The probability of air gap breakdown increases significantly when the dust concentration in the light detection zone reaches about 80% of the peak concentration. The study also explores the impact of particle size, initial mass, material, initial position of dust, and electric field polarity on dust dispersion motion. Smaller particle size and larger initial mass lead to lower voltage levels at which peaks occur, resulting in higher peak concentration values and increased danger, the breakdown voltage can be reduced by up to 36.7% compared to the dust-free condition. Copper dust, with lower physicochemical activity, exhibits less dispersion motion at the same voltage level compared to aluminum dust, and its impact on the breakdown voltage of coaxial cylindrical electrodes is smaller. When the insulator and dust are at a certain distance, dust is likely to undergo dispersion motion and simultaneous adhesion along the insulator under the influence of the electric field, with less obvious extremum effects in dust dispersion motion.
The study also analyzes the influence of researching the dispersion motion of micron-nano dust on the air gap insulation strength of coaxial cylindrical electrodes. Breakdown experiments are conducted with aluminum and copper dust of five different particle sizes, varying initial conditions such as particle size, initial mass, and material. When the dust concentration within the light detection area reaches 80% or less of the peak concentration, the probability of air gap breakdown significantly increases. Moreover, the decrease in breakdown voltage can reach a maximum of 36.7% when there is no dust. This provides a theoretical foundation and practical basis for further assessing the level of danger and achieving the detection of micron-nano dust dispersion concentration within GIS/GIL.

Key words： GIS/GIL micron-nano dust light scattering method dispersive concentration air gap breakdown

Received: 29 January 2024

PACS:

TM852

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Wang Yuan
	Yang Ruicheng
	Su Baoliang
	Li Xuan
	Xue Naifan
	Li Qingmin

Cite this article:

Wang Yuan,Yang Ruicheng,Su Baoliang等. Characterization of Diffuse Concentration Distribution of Micron-Nano Dust in DC GIS/GIL and the Effect on Air Gap Breakdown Strength[J]. Transactions of China Electrotechnical Society, 0, (): 2492912-2492912.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.240191 OR https://dgjsxb.ces-transaction.com/EN/Y0/V/I/2492912

[1] 薛乃凡, 李庆民, 刘智鹏, 等. 微纳粉尘运动行为与微弱放电探测技术研究进展[J]. 电工技术学报, 2022, 37(13): 3380-3392.
Xue Naifan, Li Qingmin, Liu Zhipeng, et al.Research advances of the detection technology for kinetic behavior and weak discharge of the micro-nano dust[J]. Transactions of China Electrotechnical Society, 2022, 37(13): 3380-3392.
[2] 程涵, 魏威, Bilal lqbal Ayubi, 等. 直流GIL中线形金属微粒电动力学行为研究[J]. 电工技术学报, 2021, 36(24): 5283-5293.
Cheng Han, Wei Wei, Ayubi Bilal Lqbal, et al.Study on the electrodynamic behavior of linear metal particles in DC gas insulated transmission line[J]. Transactions of China Electrotechnical Society, 2021, 36(24): 5283-5293.
[3] 关为民, 卞超, 谭婷月, 等. 苏通GIL综合管廊SF₆气体泄漏分布特性数值模拟研究[J]. 高压电器, 2020, 56(11): 102-110.
Guan Weimin, Bian Chao, Tan Tingyue, et al.Numerical simulation study on distribution characteristics of SF₆ gas leakage in SuzhouNantong GIL integrated gallery[J]. High Voltage Apparatus, 2020, 56(11): 102-110.
[4] 杜伯学, 董佳楠, 梁虎成. 特高压GIL非均匀热气流特性与三支柱绝缘子绝缘裕度分析[J]. 电工技术学报, 2023, 38(6): 1678-1686.
Du Boxue, Dong Jianan, Liang Hucheng.Non-uniform gas convection in UHV-GIL and insulation margin analysis for tri-post insulator[J]. Transactions of China Electrotechnical Society, 2023, 38(6): 1678-1686.
[5] 胡智莹, 耿秋钰, 魏来, 等. 直流GIS/GIL中驱赶电极与微粒陷阱的协同抑制作用及优化设计方法[J]. 电工技术学报, 2023, 38(12): 3338-3349.
Hu Zhiying, Geng Qiuyu, Wei Lai, et al.Synergistic inhibitory effect and optimal design method of driving electrode and particle trap in DC GIS/GIL[J]. Transactions of China Electrotechnical Society, 2023, 38(12): 3338-3349.
[6] 刘逸凡, 邹明, 王焱, 等. 面向海上风电仿真的永磁同步发电机电磁暂态等效建模方法[J]. 电工技术学报, 2024, 39(8): 2400-2411.
Liu Yifan, Zhou Ming, Wang Yan, et al.Equivalent modeling method for electromagnetic transient of permanent magnet synchronous generator for offshore wind power simulation[J]. Transactions of China Electrotechnical Society, 2024, 39(8): 2400-2411.
[7] 张连根, 路士杰, 李成榕, 等. 气体绝缘组合电器中微米量级金属粉尘运动和放电特征[J]. 电工技术学报, 2020, 35(2): 444-452.
Zhang Liangen, Lu Shijie, Li Chengrong, et al.Movement and discharge characteristics of micron-scale metal dust in gas insulated switchgear[J]. Transactions of China Electrotechnical Society, 2020, 35(2): 444-452.
[8] Madhu Sahu K B, Amarnath J. Effect of various parameters on the movement of metallic particles in a single phase gas insulated bus duct with image charges and dielectric coated electrodes[J]. ARPN Journal of Engineering and Applied Sciences, 2010, 5(6): 52-60.
[9] 王健. 直流GIL金属微粒的荷电运动机制与治理方法研究[D]. 北京: 华北电力大学, 2017.
Wang Jian.Research on the moving mechanisms of charged metal particles in DC GIL and suppressing methods[D]. Beijing: North China Electric Power University, 2017.
[10] 梁瑞雪, 王健, 胡琦, 等. 直流GIL盆式绝缘子附近微米级金属粉尘的动力学行为与吸附机制研究[J]. 中国电机工程学报, 2020, 40(4): 1387-1396, 1429.
Liang Ruixue, Wang Jian, Hu Qi, et al.Study on kinetic behavior and adsorption mechanism of the micron metal dust near the basin-type insulator in DC GIL[J]. Proceedings of the CSEE, 2020, 40(4): 1387-1396, 1429.
[11] Song Yifan, Zhang Qi.Multiple explosions induced by the deposited dust layer in enclosed pipeline[J]. Journal of Hazardous Materials, 2019, 371: 423-432.
[12] Huang Yubo, Liu Xiaowei, Wang Zhaofeng, et al.On-line measurement of ultralow mass concentration particulate based on light scattering coupled with beta ray attenuation method[J]. Fuel, 2022, 329: 125461.
[13] Zhang Rongrui, Zhao Heng.Small-angle particle counting coupled photometry for real-time detection of respirable particle size segmentation mass concentration[J]. Sensors, 2021, 21(17): 5977.
[14] Han Jinke, Liu Xiaowei, Jiang Meng, et al.An improved on-line measurement method of particulate matter concentration using tri-wavelength laser light scattering[J]. Fuel, 2021, 302: 121197.
[15] 宋琳. 作业场所金属粉尘监测技术研究及在线监测系统的开发[D]. 杭州: 浙江工业大学, 2019.
Song Lin.Research on monitoring technology of metal dust in workplace and development of online monitoring system[D]. Hangzhou: Zhejiang University of Technology, 2019.
[16] 李庆民, 魏来, 薛乃凡, 等. 交直流GIS/GIL微纳粉尘可视化探测技术研究进展[J]. 高电压技术, 2023, 49(9): 3607-3624.
Li Qingmin, Wei Lai, Xue Naifan, et al.Research advances in visualization detection technology of micron-nano dust in AC and DC GIS/GIL[J]. High Voltage Engineering, 2023, 49(9): 3607-3624.
[17] 梁瑞雪. 直流GIL内微米级金属粉尘的吸附动力学行为及诱导放电现象研究[D]. 北京: 华北电力大学, 2021.
Liang Ruixue.Study on kinetic adsorption behavior and its induced discharge phenomena of μm-level metal dust within DC GIL[D]. Beijing: North China Electric Power University, 2021.
[18] 薛乃凡, 魏来, 李庆民, 等. 平板电极下微米级粉尘弥散浓度探测方法与时空演化特性分析[J]. 电工技术学报, 2024, 39(7): 2132-2142.
Xue Naifan, Wei Lai, Li Qingmin, et al.Detection method and spatial-temporal evolution characteristics analysis of micron dust dispersion concentration under flat electrodes[J]. Transactions of China Electrotechnical Society, 2024, 39(7): 2132-2142.
[19] 崔江, 刘小伟, 陈栋, 等. 颗粒粒径分布对全散射法测量颗粒质量浓度的影响[J]. 中国电机工程学报, 2016, 36(16): 4415-4421, 4528.
Cui Jiang, Liu Xiaowei, Chen Dong, et al.Effect of particle size distribution on concentration measurement with light extinction method[J]. Proceedings of the CSEE, 2016, 36(16): 4415-4421, 4528.
[20] 张子同. 新型光散射式颗粒物传感器系统的研究[D]. 无锡: 江南大学, 2021.
Zhang Zitong.The research of novel light scattering particle sensor system[D]. Wuxi: Jiangnan University, 2021.
[21] 吴丹, 张国城, 赵晓宁. 光散射法颗粒物监测仪粒径识别检测装置的搭建及方法研究[J]. 计量学报, 2021, 42(3): 388-394.
Wu Dan, Zhang Guocheng, Zhao Xiaoning.Research on construction and method of particle size recognition and detection device for light scattering particles monitor[J]. Acta Metrologica Sinica, 2021, 42(3): 388-394.
[22] 黄鸿飞, 李洪涛, 高佳平, 等. 多场耦合作用下GIS/GIL气固界面绝缘性能研究评述[J]. 高压电器, 2023, 59(9): 12-26.
Huang Hongfei, Li Hongtao, Gao Jiaping, et al.Review on insulation performance at gas-solid interface in GIS/GIL with multi-field coupling[J]. High Voltage Apparatus, 2023, 59(9): 12-26.