基于发电机定子接地燃弧电阻变化特征的主动降压熄弧机理与抑制方法

doi:10.19595/j.cnki.1000-6753.tces.231141

Abstract
Figure/Table
References
Related Citation (2)

Download: PDF (1950 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The stator grounding arc fault is a technical bottleneck that restricts the safe and reliable operation of large generators. The continuous burning arc is prone to burn or melt the stator winding insulation and iron core. residual currents, active and harmonic currents of grounding faults is not eliminated completely by the existing methods. And it is difficult to limit the residual currents of grounding faults to the allowable value of safe grounding currents and cannot meet the requirements of existing regulations. By analyzing the variation characteristics of stator grounding arc suppression fault voltage and arc resistance, the flexible grounding method for stator grounding arcing fault voltage reduction and arc suppression is proposed.
Firstly, the analytical relationship between the stator grounding arc resistance and the arc voltage was established. Then, during the voltage reduction at the stator grounding fault point, the stator arc resistance increase. The voltage at the grounding fault point is suppressed below the arc reignition voltage. So, the suppression method can achieve returning the breakdown gap of the stator winding to the normal insulation state. When the method of generator stator is the flexible grounding, the grounding fault point is output with the power frequency and third harmonic reverse electromotive. The voltage of the fault point is reduced to below the gradient of the arcing electric field. And the stator grounding arc is extinguished. By injection signals to sense the stator grounding fault status, the vector angle change trend of stator winding damping rate is real-time monitored. And the grounding arc fault is monitored during the voltage reduction and arc suppression process. In the proposed method, the fault point voltage is not required reducing to zero. The risk of breakdown in the slot of the stator winding is effectively avoided during the voltage rise of the non-fault phase.
The proposed method was experimentally validated by simulating the arcing conditions of stator grounding faults in the PSCAD/EMTDC simulation environment. The experimental results showed that the flexible grounding voltage source was put into operation. The input potential amplitude was changed, and the fault point voltage was regulated. The fault point voltage value was lower than the arc breakdown voltage, and the stator grounding arc extinguished within 100 ms. The stator grounding arc is unable to reignite. After the flexible grounding voltage source is put into use for voltage reduction and arc suppression, the damping vector angle is less than 12°. And the change value is negative. The state of stator grounding arc burning out is effectively distinguished during the voltage reduction and arc suppression process.
The following conclusions can be drawn from the analysis: (1) The field strength of the stator grounding fault through the gap is inversely proportional to the arc resistance. By reducing the voltage at the stator ground fault point, the electric field strength of the arc is reduced, and the arc resistance is increasing. So, the current at the fault point is reduced. (2) By utilizing a controllable voltage source in parallel with the stator neutral point, the voltage at the fault point is reduced to achieve reliable suppression of grounding fault arcs. (3) The voltage asymmetry of the stator system is reduced during the voltage reduction and arc suppression process in the method. the degree of voltage rise of the non-fault phase winding and the risk of breakdown can be reduce. The maximum displacement voltage shall not exceed the rated voltage of the system and shall be consistent with the stator voltage offset caused by natural ground faults.

Key words： Generator stator arcing ground fault voltage actively reduced of arc extinguishing arc resistance fault detection

Received: 17 July 2023

PACS:

TM771

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Li Li
	Yu Kun
	Zeng Xiangjun
	Wang Zhan
	He Shigeng

Cite this article:

Li Li,Yu Kun,Zeng Xiangjun等. Mechanism and Suppression Method of Active Arc Extinguishing Based on the Variation Characteristics of Arc Resistance of Stator[J]. Transactions of China Electrotechnical Society, 2024, 39(17): 5379-5393.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.231141 OR https://dgjsxb.ces-transaction.com/EN/Y2024/V39/I17/5379

[1] 王维俭. 电气主设备继电保护原理与应用[M]. 2版. 北京: 中国电力出版社, 2002.
[2] 王维俭, 王祥珩, 王赞基. 大型发电机变压器内部故障分析与继电保护[M]. 北京: 中国电力出版社, 2006.
[3] 龚衡, 桂林, 周光厚, 等. 发电机定子单相接地故障下定子铁心的电弧烧损过程[J]. 电力自动化设备, 2022, 42(12): 197-203.
Gong Heng, Gui Lin, Zhou Guanghou, et al.Arc burning process of stator core under stator single-phase grounding fault of generator[J]. Electric Power Automation Equipment, 2022, 42(12): 197-203.
[4] Wu A Y.MV generator ground fault arcing power damage assessment[J]. IEEE Transactions on Industry Applications, 2018, 54(1): 912-915.
[5] 高彩霞, 苗壮, 陈昊, 等. 基于线圈子单元的永磁同步电机健康与定子绕组短路故障数学模型[J]. 电工技术学报, 2023, 38(4): 957-969.
Gao Caixia, Miao Zhuang, Chen Hao, et al.A mathematical model based on coil sub-element for permanent magnet synchronous motor with health and stator winding short-circuit fault[J]. Transactions of China Electrotechnical Society, 2023, 38(4): 957-969.
[6] 崔磊, 刘亚青, 朱钊, 等. 大容量水轮发电机中性点接地装置设计关键技术[J]. 人民长江, 2022, 53(2): 100-104, 110.
Cui Lei, Liu Yaqing, Zhu Zhao, et al.Key technology for design of neutral point grounding equipment of large-capacity hydro-generator[J]. Yangtze River, 2022, 53(2): 100-104, 110.
[7] 薛永端, 任伟, 唐毅, 等. 基于热稳定原理的中性点小电阻接地系统间歇接地故障保护[J]. 电力系统自动化, 2021, 45(18): 122-130.
Xue Yongduan, Ren Wei, Tang Yi, et al.Intermittent grounding fault protection based on principle of thermal stability for low resistance neutral grounded system[J]. Automation of Electric Power Systems, 2021, 45(18): 122-130.
[8] 钟守平, 王洪林, 陈佳胜, 等. 大型燃气轮发电机组保护关键技术研究[J]. 电气技术, 2021, 22(12): 67-72.
Zhong Shouping, Wang Honglin, Chen Jiasheng, et al.Research on key technology of protection for large capacity gas-turbine generator set[J]. Electrical Engineering, 2021, 22(12): 67-72.
[9] Xiong Bin, Zhou Long, Ding Shuye.Study on dynamic characteristics of single-phase grounding fault of 1000 MW hydro generator under different grounding modes[J]. Machines, 2022, 10(7): 554.
[10] 要焕年, 曹梅月. 电力系统谐振接地[M]. 2版. 北京: 中国电力出版社, 2009.
[11] 张琦雪, 曾祥君, 徐金, 等. 大型发电机中性点组合型接地方式的分析与探讨[J]. 电力自动化设备, 2018, 38(11): 217-222.
Zhang Qixue, Zeng Xiangjun, Xu Jin, et al.Analysis and discussion on combination-type grounding scheme for large-sized generator[J]. Electric Power Automation Equipment, 2018, 38(11): 217-222.
[12] 张琦雪, 王祥珩, 陈佳胜, 等. 组合型接地方式对注入式定子接地保护的影响[J]. 中国电力, 2018, 51(11): 96-103.
Zhang Qixue, Wang Xiangheng, Chen Jiasheng, et al.Influence of the combination-type grounding scheme on voltage-injected stator ground fault protection[J]. Electric Power, 2018, 51(11): 96-103.
[13] 贾文超, 曹嵩. 大型水电机组组合型接地方式参数优化设计[J]. 电力自动化设备, 2022, 42(4): 79-85.
Jia Wenchao, Cao Song.Parameter optimization design of combination-type grounding mode for large-sized hydropower units[J]. Electric Power Automation Equipment, 2022, 42(4): 79-85.
[14] 吴梦可, 喻锟, 李理, 等. 一种发电机定子绕组单相接地故障消弧方法: CN111579986B[P].2022-05-10.
[15] 喻锟, 李理, 曾祥君, 等. 一种发电机定子与厂用电系统接地故障处理方法: CN113937737A[P].2022-01-14.
[16] 徐雯, 王义凯, 尹项根, 等. 基于零序电压有源调控的发电机定子接地故障消弧方法及保护对策[J]. 电力自动化设备, 2022, 42(4): 197-202.
Xu Wen, Wang Yikai, Yin Xianggen, et al.Arc suppression method and protection countermeasures of generator stator grounding fault based on active control of zero-sequence voltage[J]. Electric Power Automation Equipment, 2022, 42(4): 197-202.
[17] 卓超, 曾祥君, 彭红海, 等. 配电网接地故障相主动降压消弧成套装置及其现场试验[J]. 电力自动化设备, 2021, 41(1): 48-58.
Zhuo Chao, Zeng Xiangjun, Peng Honghai, et al.Arc suppression device with active reduction of grounding fault phase voltage and field test for distribution networks[J]. Electric Power Automation Equipment, 2021, 41(1): 48-58.
[18] 王义凯, 尹项根, 谭力铭, 等. 发电机定子接地故障双频有源消弧策略及故障类型辨识[J]. 电工技术学报, 2022, 37(19): 4835-4847.
Wang Yikai, Yin Xianggen, Tan Liming, et al.Generator stator ground fault active arc suppression and fault type identification method based on dual-frequency voltage regulation[J]. Transactions of China Electrotechnical Society, 2022, 37(19): 4835-4847.
[19] 尹项根, 王义凯, 谭力铭, 等. 基于双频有源调控的大型机组定子接地故障电弧抑制及自适应保护[J]. 电力系统保护与控制, 2023, 51(6): 1-9.
Yin Xianggen, Wang Yikai, Tan Liming, et al.Dual-frequency active regulation-based arc suppression and adaptive protection for a stator ground fault in large generators[J]. Power System Protection and Control, 2023, 51(6): 1-9.
[20] 杨明波, 龙毅, 樊三军, 等. 基于组合Mayr和Cassie电弧模型的弧光接地故障仿真及分析[J]. 电测与仪表, 2019, 56(10): 8-13.
Yang Mingbo, Long Yi, Fan Sanjun, et al.Simulation and analysis of arc grounding fault based on combined Mayr and Cassie arc models[J]. Electrical Measurement & Instrumentation, 2019, 56(10): 8-13.
[21] 林莘, 王娜, 徐建源. 动态电弧模型下特快速瞬态过电压特性的计算与分析[J]. 中国电机工程学报, 2012, 32(16): 157-164.
Lin Xin, Wang Na, Xu Jianyuan.Calculation and analysis of very fast transient over-voltage characteristic on the condition of dynamic arcing model[J]. Proceedings of the CSEE, 2012, 32(16): 157-164.
[22] 乔健, 尹项根, 王义凯, 等. 以槽电势为分析单元的大型发电机定子接地故障定位方法[J]. 电力自动化设备, 2022, 42(11): 204-210, 217.
Qiao Jian, Yin Xianggen, Wang Yikai, et al.Slot potential based stator grounding fault location method for large generator[J]. Electric Power Automation Equipment, 2022, 42(11): 204-210, 217.
[23] 王义凯, 尹项根, 谭力铭, 等. 基于三次谐波电势分布特征的发电机定子绕组接地故障定位方法[J]. 电工技术学报, 2023, 38(13): 3552-3562.
Wang Yikai, Yin Xianggen, Tan Liming, et al.Generator stator winding ground fault location algorithm based on third harmonic potential distribution characteristic[J]. Transactions of China Electrotechnical Society, 2023, 38(13): 3552-3562.
[24] 谭力铭, 尹项根, 王义凯, 等. 自适应工况的大型水轮发电机定子接地故障定位方法[J]. 电工技术学报, 2022, 37(17): 4411-4422.
Tan Liming, Yin Xianggen, Wang Yikai, et al.An adaptive load-based location method of stator ground fault for large hydro-generators[J]. Transactions of China Electrotechnical Society, 2022, 37(17): 4411-4422.
[25] Safari-Shad N, Franklin R, Negahdari A, et al.Adaptive 100% injection-based generator stator ground fault protection with real-time fault location capability[J]. IEEE Transactions on Power Delivery, 2018, 33(5): 2364-2372.
[26] 曾鹏, 张靖, 高宗宝, 等. 水轮发电机定子绕组绝缘诊断及寿命评估研究[J]. 电工技术, 2023(5): 221-224.
Zeng Peng, Zhang Jing, Gao Zongbao, et al.Research on insulation diagnosis and life evaluation of hydro generator stator winding[J]. Electric Engineering, 2023(5): 221-224.