|
|
|
| Linear Power Balance Strategy for Asymmetric Cascaded H-Bridge Nine-Level Inverter |
| Ye Manyuan1, Yu Shengming2, Liu Wenfang2, Chen Yinbo1, Shao Yunpeng1 |
1. School of Electrical and Automation Engineering East China Jiaotong University Nanchang 330013 China;
2. State Grid Anhui Electric Power Co. Ltd Huaining County Power Supply Company Anqing 246121 China |
|
|
|
Abstract Compared to traditional two-level inverters, cascaded H-bridge (CHB) multi-level inverters based on pulse width modulation (PWM) strategy are widely used in medium and high voltage power applications, such as DC transmission and photovoltaic grid connection, due to their excellent harmonic performance, high efficiency, and low dv/dt.
According to different voltage values on the DC side of the inverter, CHB multi-level inverters can be divided into symmetrical and asymmetric cascaded H-bridge multi-level inverters. Asymmetric cascaded inverters output higher voltage levels under the same number of power switches and DC voltage sources, which have high research value. However, the traditional Type II asymmetric CHB inverter has the problem of current reversal under partial amplitude modulation. Therefore, the paper adds a low-voltage unit to the traditional type II asymmetric CHB inverter topology, adjusting the DC side voltage ratio to 2:1:1, and effectively avoiding current reversal by selecting switch states at different levels.
For the asymmetric cascaded nine-level inverter topology, the traditional hybrid PWM (H-PWM) strategy has the advantage of optimizing the harmonic performance of the output voltage. However, under this modulation strategy, only low-voltage unit H3 operates in the high-frequency state, and high-voltage unit H1 and low-voltage unit H2 both operate in the low-frequency state. The imbalanced output power and uneven distribution of switching losses exist among the cascaded units of the inverter, which seriously affects the lifespan of the inverter topology. Accordingly, the paper proposes an improved hybrid PWM (IH-PWM) modulation strategy based on the H-PWM modulation strategy. The proposed strategy improves the output voltage waveform but does not address the issue of the imbalanced output power between cascaded units.
This paper further optimizes the IH-PWM strategy and proposes a hybrid modulation strategy based on power units redistribution (PRH-PWM). For the high-voltage unit H1, the PRH-PWM strategy controls the conduction angle of the switch to control the amplitude of the fundamental wave of the unit output voltage. Thus, the average output power of the unit is always half of the average output power of the inverter under the full amplitude modulation. At the same time, it increases the modulation range for high-voltage unit H1 to participate in inverter operation. For low-voltage units H2 and H3, the PRH-PWM strategy combines the advantages of phase- disposition and phase-shift PWM modulation strategies. By recombining the power units, the inverter achieves output power balance and uniform distribution of switching losses between low-voltage units while outputting high-quality voltage waveforms.
Simulation and experimental platforms are established for asymmetric cascaded H-bridge nine-level inverters. The results indicate that the high-voltage unit H1 participates in the operation of the inverter under full amplitude modulation, which improves the utilization rate of the cascaded units and extends the service life of the inverter. Under the full amplitude modulation, the cascaded units' average output power ratio of the nine-level inverter remains at PH1: PH2 : PH3 =2: 1 : 1. The PRH-PWM modulation strategy achieves a linear balance of output power between the cascaded units of the nine-level inverter. The THD value of the nine-level inverter's output phase voltage waveform is low under the high amplitude modulation, and the quality of the inverter voltage waveform is better under the PRH-PWM modulation strategy.
|
|
Received: 18 May 2023
|
|
|
|
|
|
[1] 王立乔, 韩胥静, 李占一, 等. 一种新型飞跨电容型Zeta多电平逆变器[J]. 电工技术学报, 2022, 37(1): 254-265.
Wang Liqiao, Han Xujing, Li Zhanyi, et al.A novel flying-capacitor zeta multi-level inverter[J]. Transa-ctions of China Electrotechnical Society, 2022, 37(1): 254-265.
[2] 杨行, 王明渝, 孙雨婷, 等. 两级式级联H桥光伏并网逆变器功率平衡控制策略[J]. 电力系统及其自动化学报, 2021, 33(4): 76-83.
Yang Hang, Wang Mingyu, Sun Yuting, et al.Power balance control strategy for two-stage cascaded H-bridge photovoltaic grid-connected inverter[J]. Proceedings of the CSU-EPSA, 2021, 33(4): 76-83.
[3] 王要强, 李娜, 赵朝阳, 等. 一种新型多电平逆变器及其模块化分析[J]. 电工技术学报, 2022, 37(18): 4676-4687.
Wang Yaoqiang, Li Na, Zhao Zhaoyang, et al.A new type of multilevel inverter and its modular analysis[J]. Transactions of China Electrotechnical Society, 2022, 37(18): 4676-4687.
[4] Zeng Xiangjun, Gong Deling, Wei Milan, et al.Research on novel hybrid multilevel inverter with cascaded H-bridges at alternating current side for high-voltage direct current transmission[J]. IET Power Electronics, 2018, 11(12): 1914-1925.
[5] 徐畅, 宫金武, 张国琴, 等. 中点钳位型三电平逆变器并联系统的零序环流抑制策略[J]. 电工技术学报, 2023, 38(增刊1): 124-135.
Xu Chang, Gong Jinwu, Zhang Guoqin, et al.Zero sequence circulating current suppression strategy for a neutral point clamped three-level inverter parallel system[J]. Journal of Electrical Engineering, 2023, 38(S1): 124-135.
[6] Abolhassani M.Modular multipulse rectifier trans-formers in symmetrical cascaded H-bridge medium voltage drives[J]. IEEE Transactions on Power Electronics, 2012, 27(2): 698-705.
[7] Guo Xiaoqiang, Wei Baoze, Zhu Tieying, et al.Leakage current suppression of three-phase flying capacitor PV inverter with new carrier modulation and logic function[J]. IEEE Transactions on Power Electronics, 2018, 33(3): 2127-2135.
[8] 齐悦, 杨耕, 窦曰轩. 基于多电平变换逆变电路的拓扑分析[J]. 电机与控制学报, 2002, 6(1): 74-79.
Qi Yue, Yang Geng, Dou Yuexuan.The topology analysis of the multilevel inverter[J]. Electric Machines and Control, 2002, 6(1): 74-79.
[9] 余彬, 宋文胜, 冯加旭, 等. 基于虚拟电压矢量的五相电压源逆变器空间矢量调制算法[J]. 中国电机工程学报, 2020, 40(1): 212-221, 388.
Yu Bin, Song Wensheng, Feng Jiaxu, et al.Virtual voltage vectors based space vector PWM method for five phase voltage source inverters[J]. Proceedings of the CSEE, 2020, 40(1): 212-221, 388.
[10] 陈仲, 许亚明, 刘亚云, 等. 不对称两单元H桥级联逆变器的混合载波PWM方法[J]. 中国电机工程学报, 2016, 36(20): 5584-5593, 5735.
Chen Zhong, Xu Yaming, Liu Yayun, et al.A PWM method based on the hybrid carriers for an asymmetric inverter with two cascaded H-bridge cells[J]. Proceedings of the CSEE, 2016, 36(20): 5584-5593, 5735.
[11] Ye Manyuan, Kang Lixuan, Xiao Yunhuang, et al.Modified hybrid modulation strategy with power balance control for H-bridge hybrid cascaded seven-level inverter[J]. IET Power Electronics, 2018, 11(6): 1046-1054.
[12] 叶满园, 邢瑞新, 喻正炎, 等. 基于区间信号提取的Ⅱ型不对称级联逆变器新型PWM调制策略[J].高电压技术, 2023, DOI: 10.19595/j.cnki.1000-6753. tces.e10022.
Ye Manyuan, Xing Ruixin, Yu Zhengyan, et al.A novel PWM modulation strategy for type Ⅱ asym-metric cascaded inverter based on interval signal extraction[J]. High Voltage Technology, 2023, DOI: 10.19595/j.cnki.1000-6753. tces.e10022.
[13] Ronanki D, Williamson S S.Voltage ripple minimi-zation in modular multilevel converters using modified rotative PWM scheme[C]//2018 AEIT International Annual Conference, Bari, Italy, 2018: 1-6.
[14] Sarkar I, Fernandes B G.Modified hybrid multi-carrier PWM technique for cascaded H-bridge multilevel inverter[C]//IECON 2014-40th Annual Conference of the IEEE Industrial Electronics Society, Dallas, TX, USA, 2015: 4318-4324.
[15] Nirmal Mukundan C M, Jayaprakash P. A new binary hybrid cascaded H-bridge multi level converter for power quality applications[C]//2016 IEEE 7th Power India International Conference (PIICON), Bikaner, India, 2017: 1-6. |
|
|
|
2024, Vol. 39 
