应用于自动导引小车无线充电系统的导航与供电一体化线圈研究

doi:10.19595/j.cnki.1000-6753.tces.230831

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (5486 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract As the advent of the fourth industrial revolution develops all automated and connected systems in industries, automated guided vehicles (AGVs) have become essential technologies for factory production and logistics systems. Since the AGV should be automatically parked and charged in the charging station, wireless power transfer (WPT) technologies are inevitably used instead of plug-in-type power cables or conductive charging. Compared with electric vehicles, the navigation system of AGV adds new challenges to the application of WPT technology. Recent studies have paid less attention to this problem. This paper proposes a navigation and power supply integrated DAD coil.
This paper introduces the structure of DAD coils and analyzes the principle of the DAD coil navigation and power supply from the coil magnetic field perspective. Most magnetic lines of the DAD coil form an annular closed magnetic field in the air gap magnetic field area. The leakage magnetic field is small, the coupling coefficient between primary and secondary is high, and the coil efficiency is high. From the navigation perspective, under different offset directions, the mutual inductance of the two coils on the secondary side changes differently. Therefore, the offset direction can be judged according to the relative value of mutual inductance, and the offset value can be judged by the difference of mutual inductance.
Then, the DAD coil with an LCC-S compensation topology is modeled and analyzed, and the loop current equation is written. With the traditional compensation parameters, it is found that the value of the coil output voltage is related to the secondary coupling inductance. There are two disadvantages: (1) The load voltage changes with the load, which is not conducive to DCDC voltage modulation and voltage stability; (2) The way of characterizing the offset direction and offset value by the voltage output difference is disturbed by the load. Therefore, the compensation parameters are improved, making the output voltage of the two secondary coils only dependent on the input voltage of the coupling mechanism, mutual inductance between the primary and secondary sides, and resonant inductance L_r. In general, during the operation of the WPT system, U_in and L_r remain unchanged, U₁ and U₂ can fully characterize the changes of M_p1 and M_p2. The two secondary coils can be used as a whole, which is conducive to further analysis and optimization.
Finally, the navigation and power supply performance of the DAD coil is verified by experiments. The mutual inductance and self-inductance parameters are measured, verifying the correctness of the navigation principle. A 400 W wireless charging system was built. The coil output voltage, load voltage, and efficiency were measured in the range from -50 mm to +50 mm offset. It is proved that the offset direction can be judged by the relative value of the secondary output voltage, and the offset value can be judged by the voltage difference. Aiming at the misjudgment problem when x=0 caused by the coil winding difference, using the voltage change value to characterize the offset can achieve a better navigation effect. In the range from -50 mm to +50 mm, the DAD coil achieves 400 W stable power transmission, and the efficiency is between 73.55% and 77.80%.

Key words： Automated guided vehicle (AGV) wireless power transfer (WPT) coil navigation

Received: 02 June 2023

PACS:

TM724

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Feng Hongyun
	Lin Fei
	Yang Zhongping
	Fang Xiaochun

Cite this article:

Feng Hongyun,Lin Fei,Yang Zhongping等. A Research on a Navigation and Power Supply Integrated Coil for Automatic Guided Vehicle Wireless Power Transfer System[J]. Transactions of China Electrotechnical Society, 2024, 39(14): 4294-4304.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.230831 OR https://dgjsxb.ces-transaction.com/EN/Y2024/V39/I14/4294

[1] https://www.sohu.com/a/654363731_218783.
[2] Mahesh A, Chokkalingam B, Mihet-Popa L.Inductive wireless power transfer charging for electric vehicles-a review[J]. IEEE Access, 2021, 9: 137667-137713.
[3] 赵争鸣, 张艺明, 陈凯楠. 磁耦合谐振式无线电能传输技术新进展[J]. 中国电机工程学报, 2013, 33(3): 1-13, 21.
Zhao Zhengming, Zhang Yiming, Chen Kainan.New progress of magnetically-coupled resonant wireless power transfer technology[J]. Proceedings of the CSEE, 2013, 33(3): 1-13, 21.
[4] 黄学良, 谭林林, 陈中, 等. 无线电能传输技术研究与应用综述[J]. 电工技术学报, 2013, 28(10): 1-11.
Huang Xueliang, Tan Linlin, Chen Zhong, et al.Review and research progress on wireless power transfer technology[J]. Transactions of China Elec-trotechnical Society, 2013, 28(10): 1-11.
[5] 范兴明, 莫小勇, 张鑫. 无线电能传输技术的研究现状与应用[J]. 中国电机工程学报, 2015, 35(10): 2584-2600.
Fan Xingming, Mo Xiaoyong, Zhang Xin.Research status and application of wireless power transmission technology[J]. Proceedings of the CSEE, 2015, 35(10): 2584-2600.
[6] 吴理豪, 张波. 电动汽车静态无线充电技术研究综述(上篇)[J]. 电工技术学报, 2020, 35(6): 1153-1165.
Wu Lihao, Zhang Bo.Overview of static wireless charging technology for electric vehicles: part Ⅰ[J]. Transactions of China Electrotechnical Society, 2020, 35(6): 1153-1165.
[7] 吴理豪, 张波. 电动汽车静态无线充电技术研究综述(下篇)[J]. 电工技术学报, 2020, 35(8): 1662-1678.
Wu Lihao, Zhang Bo.Overview of static wireless charging technology for electric vehicles: part Ⅱ[J]. Transactions of China Electrotechnical Society, 2020, 35(8): 1662-1678.
[8] 张献, 王杰, 杨庆新, 等. 电动汽车动态无线供电系统电能耦合机构与切换控制研究[J]. 电工技术学报, 2019, 34(15): 3093-3101.
Zhang Xian, Wang Jie, Yang Qingxin, et al.The power coupling mechanism and switching control for dynamic wireless power supply system of electric vehicle[J]. Transactions of China Electrotechnical Society, 2019, 34(15): 3093-3101.
[9] 崔淑梅, 宋贝贝, 王志远. 电动汽车动态无线供电磁耦合机构研究综述[J]. 电工技术学报, 2022, 37(3): 537-554.
Cui Shumei, Song Beibei, Wang Zhiyuan.Overview of magnetic coupler for electric vehicles dynamic wireless charging[J]. Transactions of China Elec-trotechnical Society, 2022, 37(3): 537-554.
[10] 宋凯, 朱春波, 李阳, 等. 用于电动汽车动态供电的多初级绕组并联无线电能传输技术[J]. 中国电机工程学报, 2015, 35(17): 4445-4453.
Song Kai, Zhu Chunbo, Li Yang, et al.Wireless power transfer technology for electric vehicle dynamic charging using multi-parallel primary coils[J]. Proceedings of the CSEE, 2015, 35(17): 4445-4453.
[11] Liu Qingyun, Hu S, Angeloudis P, et al.Dynamic wireless power transfer system for electric-powered connected and autonomous vehicle on urban road network[J]. IET Intelligent Transport Systems, 2021, 15(9): 1153-1166.
[12] 肖蕙蕙, 周青山, 熊山香, 等. 基于双层正交DD线圈抗偏移偏转的无线电能传输系统[J]. 电工技术学报, 2022, 37(16): 4004-4018.
Xiao Huihui, Zhou Qingshan, Xiong Shanxiang, et al.Wireless power transfer system based on double-layer quadrature double-D coupling structure with anti-misalignment and anti-deflection[J]. Transactions of China Electrotechnical Society, 2022, 37(16): 4004-4018.
[13] 谢诗云, 杨奕, 李恋, 等. 基于双极性耦合磁场调控的高抗偏移偏转无线电能传输系统[J]. 电工技术学报, 2023, 38(18): 4838-4852.
Xie Shiyun, Yang Yi, Li Lian, et al.Wireless power transfer system with high misalignment tolerance based on bipolar coupling magnetic-field control[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 4838-4852.
[14] 陈庆彬, 范峰, 汪金帅, 等. 无线电能传输磁耦合系统Litz线圈交流电阻精确评估方法[J]. 电工技术学报, 2022, 37(24): 6294-6305.
Chen Qingbin, Fan Feng, Wang Jinshuai, et al.Accurate evaluation method of litz coil AC resistance in wireless power transfer magnetically-coupled system[J]. Transactions of China Electrotechnical Society, 2022, 37(24): 6294-6305.
[15] 谭平安, 许文浩, 上官旭, 等. 无线电能传输系统中组合串绕六边形线圈的互感建模及参数优化[J]. 电工技术学报, 2023, 38(9): 2299-2309.
Tan Ping'an, Xu Wenhao, Shangguan Xu, et al. Mutual inductance modeling and parameter optimi-zation of wireless power transfer system with combined series-wound hexagonal coils[J]. Transa-ctions of China Electrotechnical Society, 2023, 38(9): 2299-2309.
[16] 陈志鑫, 张献, 沙琳, 等. 基于频率调节的电动汽车无线充电互操作性提升方法研究[J]. 电工技术学报, 2023, 38(5): 1237-1247.
Chen Zhixin, Zhang Xian, Sha Lin, et al.Research on improving interoperability of electric vehicle wireless power transfer based on frequency adjustment[J]. Transactions of China Electrotechnical Society, 2023, 38(5): 1237-1247.
[17] 赵进国, 赵晋斌, 张俊伟, 等. 无线电能传输系统中有源阻抗匹配网络断续电流模式最大效率跟踪研究[J]. 电工技术学报, 2022, 37(1): 24-35.
Zhao Jinguo, Zhao Jinbin, Zhang Junwei, et al.Maximum efficiency tracking study of active impe-dance matching network discontinous current mode in wireless power transfer system[J]. Transactions of China Electrotechnical Society, 2022, 37(1): 24-35.
[18] Liu Sheng, Feng Yue, Weng Wanying, et al.Contactless-sensor-based output feedback control with maximum efficiency tracking technique in indu-ctive power transfer systems[J]. IEEE Transactions on Power Electronics, 2023, 38(7): 9218-9229.
[19] Kanazawa H, Uwai H, Kiuchi S, et al.Receiver-position-based unbalanced-current control for a three-to single-phase wireless power transfer system for AGVs[J]. IEEE Transactions on Industrial Electronics, 2023, 70(4): 3245-3256.
[20] Wang Deyu, Fu Chaowei, Zhao Qinglin, et al.A PSO-based optimization design of W-type noncontact transformer for stable power transfer in DWPT system[J]. IEEE Transactions on Industry Appli-cations, 2022, 58(1): 1211-1221.
[21] Yang Bin, Lu Yuanfang, Peng Yuner, et al.Analysis and design of a T/S compensated IPT system for AGV maintaining stable output current versus air gap and load variations[J]. IEEE Transactions on Power Electronics, 2022, 37(5): 6217-6228.
[22] Su Shijian, Zeng Xianping, Song Shuang, et al.Positioning accuracy improvement of automated guided vehicles based on a novel magnetic tracking approach[J]. IEEE Intelligent Transportation Systems Magazine, 2020, 12(4): 138-148.
[23] Rozsa Z, Sziranyi T.Obstacle prediction for automated guided vehicles based on point clouds measured by a tilted LIDAR sensor[J]. IEEE Transactions on Intelligent Transportation Systems, 2018, 19(8): 2708-2720.
[24] Jiang Chaoqiang, Chau K T, Liu Chunhua, et al.Move-and-charge system for automatic guided vehicles[J]. IEEE Transactions on Magnetics, 2018, 54(11): 1-5.