|
|
|
| Equivalent Nonlinear Circuit Model with Interface Charge and Polarity Effect for Oil-Paper Composite Insulation |
| Huang Meng, Li Yiran, Wu Yanyu, Chen Liangjiong, Qi Bo |
| State Key Laboratory of Alternate Electrical Power System with Renewable Energy Sources North China Electric Power University Beijing 102206 China |
|
|
|
Abstract In the operation of a converter transformer, the interface of its oil-paper composite insulation is prone to charge accumulation under DC voltage. A simple non-linear equivalent circuit model is proposed based on the extended Debye model in this paper, which can calculate the electric field distribution and interface charge amount of oil-paper insulation more easily and accurately.
Firstly, the capacitance and resistance parameters of the transformer oil and the oil-immersed paperboard are separately measured, and the electric field strength in the oil is measured based on the Kerr effect method at applied voltages from 5 to 25 kV respectively. The electric field distribution in the oil-paper composite insulation is calculated for different applied voltages as well as different voltage polarities, and the measured results are compared with the calculated results from the RC model. Secondly, the conductivity of the transformer oil and oil-immersed paperboard are measured under different electric field strength to establish a non-linear conductivity model for the oil-paper composite insulation. Then the polarisation currents of the transformer oil and oil-immersed paperboard are separately measured and fitted to extract the branch parameters of extended Debye model. Finally, the interface potential barriers are derived from the measured polarisation currents, and the polarity determined interface potential barrier is then added to the model to limit the current through the interface, thus establishing a non-linear equivalent circuit model for the transformer oil and oil-impregnated paperboard where the resistances are the electric field strength dependent.
The electric field distribution in the oil-paper composite insulation calculated by the established non-linear equivalent model is compared with those by the RC model, extended Debye model and actual measured results. The time to steady state calculated by the equivalent model is reduced to about 500 s, which is shorter than that calculated by the RC and Debye models, and is closer to the measured results. As regards the steady state electric field in oil at different applied voltages, it can be seen that the error between those by the equivalent model and measurment is less than 5% for both positive and negative polarities. The error between the electric field in oil calculated by the equivalent model and the measured results is greatest at DC voltage of 25 kV, but the maximum error is 4.8%. These indicate that the accuracy of this model is greatly improved compared to the RC and series extended Debye model. Comparing the results of the three models with the measured values for positive and negative polarities, the equivalent model is much closer to the measured values than the RC and extended Debye model, and just the equivalent model reflects a polarity effect. The absolute value of the measured negative interface charge amount at 25 kV is merely 1.07% higher than the proposed equivalent model calculation, and the measured positive interface charge amount is 0.95% higher than the proposed equivalent model calculation.
The following conclusions can be drawn from the above: (1) Compared with the RC and extended Debye model, the dynamics of electric field distribution of the oil-paper insulation calculated by the proposed model reach the steady state faster and is closer to the measured situation. (2) The proposed model takes into account the polarity determined interface barrier to limit the current through the interface, so its calculation can reflect the polarity effect and the error between the calculated and measured electric field is less than 5%. (3) The model has incorporated the influence of nonlinear conductivity, relaxation polarisation and interfacial potential barrier limiting current, so it has a good applicability to the calculation of the interfacial charge of oil-paper insulation under different conditions more easily and accurately.
|
|
Received: 27 March 2023
|
|
|
|
|
|
[1] 张书琦, 赵晓林, 齐波, 等. 直流和极性反转电压下石蜡基与环烷基变压器油纸界面电荷积聚特性及动态过程[J]. 电工技术学报, 2022, 37(3): 767-774, 792.
Zhang Shuqi, Zhao Xiaolin, Qi Bo, et al.Interface charge accumulation characteristics and dynamic process of paraffine-base and naphthene-base transformer oils under DC and polarity reversal voltage[J]. Transactions of China Electrotechnical Society, 2022, 37(3): 767-774, 792.
[2] Huang Meng, Zhou Yuanxiang, Chen Weijiang, et al.Influence of voltage reversal on space charge behavior in oil-paper insulation[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2014, 21(1): 331-339.
[3] 郝建, 黄博, George Chen, 等. 空间电荷在多层结构油纸绝缘混合体系的积聚规律及其对电场分布的影响[J]. 高电压技术, 2017, 43(6): 1973-1979.
Hao Jian, Huang Bo, Chen G, et al.Space charge accumulation behavior of multilayer structure oil-paper insulation and its effect on electric field distribution[J]. High Voltage Engineering, 2017, 43(6): 1973-1979.
[4] 高春嘉. 直流电场下油纸绝缘界面电荷产生机制及影响因素的研究[D]. 北京: 华北电力大学, 2020.
Gao Chunjia.Research on generation mechanism of interface charge and the impacting factors in oil-pressboard insulation structure under DC voltage[D]. Beijing: North china Electric Power University, 2020.
[5] Huang Bo, Hao Miao, Hao Jian, et al.Space charge characteristics in oil and oil-impregnated pressboard and electric field distortion after polarity reversal[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(2): 881-891.
[6] Zahn M, Takada T.High voltage electric field and space-charge distributions in highly purified water[J]. Journal of Applied Physics, 1983, 54(9): 4762-4775.
[7] Hao Miao, Zhou Yuan, Chen G, et al.Space charge behavior in oil gap and impregnated pressboard combined system under HVDC stresses[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(2): 848-858.
[8] Gafvert U, Hjortstam O, Serdyuk Y, et al.Modeling and measurements of electric fields in composite oil/cellulose insulation[C]//2006 IEEE Conference on Electrical Insulation and Dielectric Phenomena, Kansas City, MO, USA, 2006: 154-157.
[9] 吴锴, 朱庆东, 王浩森, 等. 温度梯度下双层油纸绝缘系统的空间电荷分布特性[J]. 高电压技术, 2012, 38(9): 2366-2372.
Wu Kai, Zhu Qingdong, Wang Haosen, et al.Space charge distribution characteristic in double-layer oil impregnated papers under temperature gradient[J]. High Voltage Engineering, 2012, 38(9): 2366-2372.
[10] 吴洁, 郝建, 高春嘉, 等. 直流电压下界面电荷积聚对“液-固”油纸绝缘电场分布影响的仿真分析及试验验证[J]. 高电压技术, 2022, 48(5): 1737-1750.
Wu Jie, Hao Jian, Gao Chunjia, et al.Simulation and verification of interface charge accumulation influence on electric field distribution of “liquid-solid” oil-paper insulation under DC voltage[J]. High Voltage Engineering, 2022, 48(5): 1737-1750.
[11] 李国倡, 王家兴, 魏艳慧, 等. 高压直流电缆附件XLPE/SIR材料特性及界面电荷积聚对电场分布的影响[J]. 电工技术学报, 2021, 36(14): 3081-3089.
Li Guochang, Wang Jiaxing, Wei Yanhui, et al.Effect of material properties of XLPE/SIR and interface charge accumulation on electric field distribution of HVDC cable accessory[J]. Transactions of China Electrotechnical Society, 2021, 36(14): 3081-3089.
[12] 黎枝鑫, 王东阳, 温荣婷, 等. 基于时变指前因子和频域介电谱平移系数的油浸纸热老化评估方法[J]. 电工技术学报, 2022, 37(17): 4487-4496, 4516.
Li Zhixin, Wang Dongyang, Wen Rongting, et al.Thermal aging assessment method of oil impregnated paper based on time-varying pre-exponential factor and translation coefficient of frequency domain spectroscopy[J]. Transactions of China Electrotechnical Society, 2022, 37(17): 4487-4496, 4516.
[13] 黄峻峰, 秋向飞, 刘志华, 等. 交直流复合电压下纳米Al2O3改性绝缘纸板介电与电荷特性研究[J]. 高压电器, 2022, 58(12): 138-146.
Huang Junfeng, Qiu Xiangfei, Liu Zhihua, et al.Study on dielectric and charge properties of nano-Al2O3 modified paperboard under AC-DC composite voltage[J]. High Voltage Apparatus, 2022, 58(12): 138-146.
[14] 徐晴川, 王圣康, 林福昌, 等. 基于时频域介电响应的绝缘油弛豫过程分析[J]. 电工技术学报, 2022, 37(9): 2355-2365.
Xu Qingchuan, Wang Shengkang, Lin Fuchang, et al.Analysis of relaxation process of insulating oil based on dielectric response in time and frequency domain[J]. Transactions of China Electrotechnical Society, 2022, 37(9): 2355-2365.
[15] 邹阳, 林锦煌, 何津, 等. 基于频谱解构法的油纸绝缘扩展德拜模型参数辨识[J]. 电工技术学报, 2023, 38(3): 622-632.
Zou Yang, Lin Jinhuang, He Jin, et al.Parameter identification of oil paper insulation extended Debye model based on spectrum deconstruction method[J]. Transactions of China Electrotechnical Society, 2023, 38(3): 622-632.
[16] 胡一卓, 董明, 谢佳成, 等. 油纸绝缘宽频介电响应谱分析及等效模型研究[J]. 中国电机工程学报, 2019, 39(23): 7065-7073, 7119.
Hu Yizhuo, Dong Ming, Xie Jiacheng, et al.Spectrum analyzing and modeling of wide-band frequency dielectric response of oil-paper insulation[J]. Proceedings of the CSEE, 2019, 39(23): 7065-7073, 7119.
[17] Wei Yanhui, Mu Haibao, Deng Junbo, et al.Effect of space charge on breakdown characteristics of aged oil-paper insulation under DC voltage[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(5): 3143-3150.
[18] 连启祥, 杜志叶, 杨知非, 等. 油纸绝缘内部合成电场数值模拟方法[J]. 电工技术学报, 2017, 32(20): 53-61.
Lian Qixiang, Du Zhiye, Yang Zhifei, et al.Numerical simulation method of electric field in oil-paper insulation[J]. Transactions of China Electrotechnical Society, 2017, 32(20): 53-61.
[19] 黄猛, 葛扬, 单秉亮, 等. TiO2纳米粒子几何形貌对冲击电压下变压器油中流注发展速度的影响[J]. 高电压技术, 2020, 46(11): 3986-3993.
Huang Meng, Ge Yang, Shan Bingliang, et al.Influence of TiO2 nanoparticle’s geometry on propagation velocity of streamers in transformer oil under impulse voltage[J]. High Voltage Engineering, 2020, 46(11): 3986-3993.
[20] 朱庆东, 吴锴, 朱文兵, 等. 温度梯度下油纸绝缘空间电荷特性的数值仿真[J]. 高电压技术, 2016, 42(3): 923-930.
Zhu Qingdong, Wu Kai, Zhu Wenbing, et al.Numerical simulation of space charge property in oil-paper insulation space under temperature gradient[J]. High Voltage Engineering, 2016, 42(3): 923-930.
[21] Gabler T, Backhaus K, Großmann S, et al.Dielectric modeling of oil-paper insulation systems at high DC voltage stress using a charge-carrier-based approach[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2019, 26(5): 1549-1557.
[22] Qi Bo, Gao Chunjia, Zhao Xiaolin, et al.Interface charge polarity effect based analysis model for electric field in oil-pressboard insulation under DC voltage[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(5): 2704-2711.
[23] 关毅. 动态参数下换流变压器油纸绝缘电场分布与放电特性[D]. 哈尔滨: 哈尔滨理工大学, 2022.
Guan Yi.Electric field distribution and discharge characteristics of oil-pressboard insulation of converter transformer with dynamic parameters[D]. Harbin: Harbin University of Science and Technology, 2022.
[24] 应宇鹏, 黄猛, 吕玉珍, 等. TiO2纳米粒子浓度对油纸复合绝缘击穿特性和界面电荷的影响[J]. 中国电机工程学报, 2019, 39(增刊1): 249-257.
Ying Yupeng, Huang Meng, Lü Yuzhen, et al.Influence of TiO2 nanoparticles concentration on breakdown characteristic and interface charge of oil-paper insulation[J]. Proceedings of the CSEE, 2019, 39(S1): 249-257.
[25] 应宇鹏. 纳米粒子对油纸复合绝缘直流击穿强度的影响[D]. 北京: 华北电力大学, 2020.
Ying Yupeng.Influence of nanoparticles on DC breakdown strength of oil-paper composite insulation[D]. Beijing: North China Electric Power University, 2020. |
|
|
|
2024, Vol. 39 
