基于比例谐振内模扩张状态观测器的PMLSM推力波动抑制策略

doi:10.19595/j.cnki.1000-6753.tces.L10072

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (5380 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Permanent magnet synchronous linear motor (PMLSM) has excellent control accuracy and response speed. It is widely applied in automatic control systems, automatic precision machine tools, and other occasions. However, due to its structure, PMLSM has thrust ripples, which can cause vibration and noise, greatly affecting the control accuracy of the motor drive at low speeds. The detent force is the main cause of thrust ripples, containing end and cogging forces. This paper proposes a thrust ripple suppression strategy based on the proportional resonant internal model extended state observer (PR-IMESO) to improve system performance and control accuracy.
Firstly, thrust ripples are modeled and analyzed, and cogging force and end force models are established. Then, the detent force model, a function of mover position with motor pole distance τ as the period, is obtained. Its frequency is twice the frequency of the primary winding phase current. Aiming at the large detent force in thrust ripples, the internal model expanded state observer is studied, considering the detent force model to compensate for the detent force and other unmodeled thrust ripples in real-time. In addition, a resonant term is introduced into the observer to enhance the compensation ability of the fixed frequency detent force. The observer is designed according to the motion equation of PMLSM considering various thrust disturbances, and parameters are adjusted by the observer bandwidth.
Finally, simulation and experiment are carried out. Set the motor running speed to 0.06 m/s and load tension to 10 N. According to the simulation results, the amplitude of velocity fluctuation with the PR-IMESO suppression strategy attenuates to 3.4% of the amplitude of velocity fluctuation, and the suppression rate is 96.6%. It is theoretically verified that the proposed strategy has a significant suppression effect on the detent force with a secondary fluctuation frequency. Further, the experiment is carried out with a 750 W PMLSM experimental platform. The PMLSM thrust ripple suppression strategies based on ESO, IMESO, and PR-IMESO are verified under the motor speed of 0.03 m/s, 0.0 6m/s, no-load, load 2 kg, 3 kg, and 4 kg. The velocity fluctuation significantly decreases with the proposed strategy. The suppression rate can reach up to 73.5%, and the average suppression rate is 68.7%. In addition, the dynamic performance of the PR-IMESO thrust ripple suppression strategy is demonstrated in the sudden loading of 4 kg. Great fluctuations of the mover velocity before and after the sudden loading exist without a suppression strategy. After adding the proposed strategy, the fluctuation of the mover velocity is significantly reduced during the whole motion process. In the process of sudden loading, the transition of the velocity error and Q-axis current is smooth and rapid. The average suppression rate of the mover velocity fluctuation is 68.7%.

Key words： Permanent magnet linear synchronous motor detent force proportional resonant internal model extended state observer thrust ripple suppression

Received: 13 January 2023

PACS:

TM341

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Zhang Gouqiang
	Zhao Xinru
	Zhang Heng
	Wang Gaolin
	Xu Dianguo

Cite this article:

Zhang Gouqiang,Zhao Xinru,Zhang Heng等. Proportional Resonant Internal Model Extended State Observer Based Thrust Ripple Suppression Strategy of PMLSM Drives[J]. Transactions of China Electrotechnical Society, 2024, 39(8): 2449-2458.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.L10072 OR https://dgjsxb.ces-transaction.com/EN/Y2024/V39/I8/2449

[1] Yang Rui, Wang Mingyi, Li Liyi, et al.Robust predictive current control of PMLSM with extended state modeling based Kalman filter: for time-varying disturbance rejection[J]. IEEE Transactions on Power Electronics, 2020, 35(2): 2208-2221.
[2] 李雄松, 崔鹤松, 胡纯福, 等. 平板型永磁直线同步电机推力特性的优化设计[J]. 电工技术学报, 2021, 36(5): 916-923.
Li Xiongsong, Cui Hesong, Hu Chunfu, et al.Optimal design of thrust characteristics of flat-type permanent magnet linear synchronous motor[J]. Transactions of China Electrotechnical Society, 2021, 36(5): 916-923.
[3] 王明杰, 贾宛英, 张志艳, 等. 永磁直线同步电机空载反电动势和推力的解析计算[J]. 电工技术学报, 2021, 36(5): 954-963.
Wang Mingjie, Jia Wanying, Zhang Zhiyan, et al.Analytical calculation of no-load eletromotive force and thrust in permanent magnet linear synchronous motors[J]. Transactions of China Electrotechnical Society, 2021, 36(5): 954-963.
[4] Chung S U, Kim J M.Double-sided iron-core PMLSM mover teeth arrangement design for reduction of detent force and speed ripple[J]. IEEE Transactions on Industrial Electronics, 2016, 63(5): 3000-3008.
[5] 方馨, 王丽梅, 张康. 基于扰动观测器的永磁直线电机高阶非奇异快速终端滑模控制[J]. 电工技术学报, 2023, 38(2): 409-421.
Fang Xin, Wang Limei, Zhang Kang.High order nonsingular fast terminal sliding mode control of permanent magnet linear motor based on disturbance observer[J]. Transactions of China Electrotechnical Society, 2023, 38(2): 409-421.
[6] Cui H, Teng Qingfang, Xu Ruiqi.Adaptive super- twisting speed control for PMLSM system using generalized proportional integral observer[C]//2021 13th International Symposium on Linear Drives for Industry Applications (LDIA), Wuhan, China, 2021: 1-6.
[7] Chen S Y, Chiang H H, Liu T S, et al.Precision motion control of permanent magnet linear syn- chronous motors using adaptive fuzzy fractional-order sliding-mode control[J]. IEEE/ASME Transactions on Mechatronics, 2019, 24(2): 741-752.
[8] 魏惠芳, 王丽梅. 永磁直线同步电机自适应模糊神经网络时变滑模控制[J]. 电工技术学报, 2022, 37(4): 861-869.
Wei Huifang, Wang Limei.Adaptive fuzzy neural network time-varying sliding mode control for permanent magnet linear synchronous motor[J]. Transactions of China Electrotechnical Society, 2022, 37(4): 861-869.
[9] Chen Lifang, Lan Zhiyong, Xie Bin, et al.Develop- ment of the method of suppressing thrust fluctuation in permanent magnet linear synchronous motor[C]// 2021 13th International Symposium on Linear Drives for Industry Applications (LDIA), Wuhan, China, 2021: 1-6.
[10] Zhang Chao, Zhang Liwei, Huang Xianjin, et al.Research on the method of suppressing the end detent force of permanent magnet linear synchronous motor based on stepped double auxiliary pole[J]. IEEE Access, 2020, 8: 112539-112552.
[11] 彭兵, 刘铁法, 张囡, 等. 凹型端齿削弱永磁直线电机端部力波动方法[J]. 电工技术学报, 2015, 30(7): 119-124.
Peng Bing, Liu Tiefa, Zhang Nan, et al.A method for reducing the end effect force fluctuation by the concave profile end-tooth in permanent magnet linear motors[J]. Transactions of China Electrotechnical Society, 2015, 30(7): 119-124.
[12] 许孝卓, 孙震, 汪旭东, 等. Halbach交替极永磁同步直线电机特性分析[J]. 电工技术学报, 2019, 34(9): 1825-1833.
Xu Xiaozhuo, Sun Zhen, Wang Xudong, et al.Characteristic of a novel permanent magnet linear synchronous motor with Halbach array consequent- pole[J]. Transactions of China Electrotechnical Society, 2019, 34(9): 1825-1833.
[13] 董家臣, 高钦和, 陈志翔, 等. 考虑电流环动态响应的永磁直线同步电机新型线性自抗扰控制[J]. 中国电机工程学报, 2019, 39(8): 2436-2448, 26.
Dong Jiachen, Gao Qinhe, Chen Zhixiang, et al.New LADRC design for permanent magnet linear syn- chronous motor considering dynamic response of current loop[J]. Proceedings of the CSEE, 2019, 39(8): 2436-2448, 26.
[14] Zhao Jiwen, Wang Lijun, Dong Fei, et al.Robust high bandwidth current regulation for permanent magnet synchronous linear motor drivers by using two- degree-of-freedom controller and thrust ripple observer[J]. IEEE Transactions on Industrial Elec- tronics, 2020, 67(3): 1804-1812.
[15] 赵鑫宇, 王丽梅. 永磁直线同步电机自适应分数阶终端滑模控制[J]. 电工技术学报, 2023, 38(20): 5434-5443.
Zhao Xinyu, Wang Limei.Adaptive fractional-order terminal sliding mode control for permanent magnet linear synchronous motor[J]. Transactions of China Electrotechnical Society, 2023, 38(20): 5434-5443.
[16] 武志涛, 李帅, 程万胜. 基于扩展滑模扰动观测器的永磁直线同步电机定结构滑模位置跟踪控制[J]. 电工技术学报, 2022, 37(10): 2503-2512.
Wu Zhitao, Li Shuai, Cheng Wansheng.Fixed structure sliding mode position tracking control for permanent magnet linear synchronous motor based on extended sliding mode disturbance observer[J]. Transactions of China Electrotechnical Society, 2022, 37(10): 2503-2512.
[17] Yang Rui, Li Liyi, Wang Mingyi, et al.Force ripple compensation and robust predictive current control of PMLSM using augmented generalized proportional- integral observer[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2021, 9(1): 302-315.
[18] 王丽梅, 孙璐, 初升. 基于经验模态分解算法的永磁直线同步电机迭代学习控制[J]. 电工技术学报, 2017, 32(6): 164-171.
Wang Limei, Sun Lu, Chu Sheng.Iterative learning control of permanent magnet linear synchronous motor based on empirical mode decomposition algorithm[J]. Transactions of China Electrotechnical Society, 2017, 32(6): 164-171.
[19] Yan Yunda, Sun Zhiyuan, Li Shihua.Disturbance rejection control method based on composite dis- turbance observer for permanent magnet synchronous motor[C]//IECON 2015-41st Annual Conference of the IEEE Industrial Electronics Society, Yokohama, Japan, 2016: 3137-3142.
[20] Zhu Z Q, Ruangsinchaiwanich S, Chen Y, et al.Evaluation of superposition technique for calculating cogging torque in permanent-magnet brushless machines[J]. IEEE Transactions on Magnetics, 2006, 42(5): 1597-1603.
[21] Huang Xu zhen, Yu Han chuan, Zhou Bo, et al. Detent-force minimization of double-sided permanent magnet linear synchronous motor by shifting one of the primary components[J]. IEEE Transactions on Industrial Electronics, 2020, 67(1): 180-191.