基于功率-温度自适应控制的多堆质子交换膜电解制氢系统效率优化

doi:10.19595/j.cnki.1000-6753.tces.230113

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (3610 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract With the growing focus of human society on low-carbon energy, the proportion of hydrogen energy in power systems is increasing and the hydrogen production system from water electrolysis is evolving towards a larger capacity and multiple stacks. Water electrolysis based on the proton exchange membrane (PEM) technology using renewable energy is a promising means of promoting the consumption of renewable energy and building a low-carbon power system. However, the randomness and volatility of renewable energy pose challenges to the efficient operation of a multi-stack PEM electrolytic hydrogen production system under fluctuating power scenarios. To enhance the efficiency of hydrogen production systems with multi-stack PEM electrolyzers, this research proposes an efficiency optimization strategy with power-temperature adaptive control. The research work is described as follows:
Firstly, an overall efficiency model of the hydrogen production system is established. The relationship between optimal system efficiency and the electrolytic power and temperature is analyzed. It reveals that the optimal electrolytic efficiency might not be achieved at the upper limits of electrolytic temperature. When the current density is low, the optimal electrolytic temperature is relatively low due to the significant reduction in Faraday efficiency caused by temperature rise. However, when the current density exceeds 1.5 A/cm², the optimal electrolysis temperature increases with the increase of current density. Therefore, to improve the electrolytic efficiency when the power of renewable energy fluctuates, it is necessary to properly adjust the electrolytic power and temperature of the electrolyzers.
Secondly, offline optimization and online control are employed to enhance electrolytic efficiency. The offline optimization involves a two-stage optimization model, where the first stage optimizes the startup and shutdown status, electrolysis power, and temperature settings of different electrolyzers to maximize hydrogen production efficiency. In the second stage, a specific power-temperature implementation scheme is determined for the electrolyzers, to achieve rapid temperature adjustment when there are multiple solutions in the first stage. In the online control section, the dynamic models of the power and temperature control of the electrolyzers are established, respectively. Based on the current total power of hydrogen production and the power-temperature setting scheme determined in the offline optimization stage, the PWM modulation signal and the valve opening signal are generated by the buck and the valve controllers, respectively.
Finally, to verify the effectiveness of the proposed efficiency enhancement strategy, a comparison is made between the proposed method and the existing average allocation strategy and chain allocation strategy. The analysis shows that the efficiency of hydrogen production is affected by both electrolytic power and temperature. Increasing the electrolysis temperature does not necessarily improve the hydrogen production efficiency, and its optimal value should be determined based on the electrolysis power. Compared with the average allocation strategy and the chain allocation strategy, the power-temperature adaptive control strategy proposed in this research can make full use of low renewable energy efficiently, while maintaining high efficiency over a large power range, making it suitable for hydrogen production with power fluctuations. In actual scenarios of hydrogen production from wind power, the proposed power-temperature adaptive control strategy can increase hydrogen production by 6.4% and 5.7%, respectively, compared with the average allocation strategy and chain allocation strategy.

Key words： Proton exchange membrane elecrolyzers power to hydrogen renewable energy power generation efficiency optimization adaptive control

Received: 01 February 2023

PACS:	TQ116.2
	TM73

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Han Pengfei
	Xu Xiaoyuan
	Wang Han
	Yan Zheng

Cite this article:

Han Pengfei,Xu Xiaoyuan,Wang Han等. Operational Efficiency Enhancement of Multi-Stack Proton Exchange Membrane Electrolyzer Systems with Power-Temperature Adaptive Control[J]. Transactions of China Electrotechnical Society, 2024, 39(7): 2236-2248.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.230113 OR https://dgjsxb.ces-transaction.com/EN/Y2024/V39/I7/2236

[1] 王雨晴, 王文诗, 徐心竹, 等. 面向低碳交通的含新能源汽车共享站电-氢微能源网区间-随机混合规划方法[J]. 电工技术学报, 2023, 38(23): 6373-6390.
Wang Yuqing, Wang Wenshi, Xu Xinzhu, et al.Hybrid interval/stochastic planning method for new energy vehicle sharing station-based electro-hydrogen micro-energy system for low-carbon transportation[J]. Transactions of China Electrotechnical Society, 2023, 38(23): 6373-6390.
[2] 吴孟雪, 房方. 计及风光不确定性的电-热-氢综合能源系统分布鲁棒优化[J]. 电工技术学报, 2023, 38(13): 3473-3485.
Wu Mengxue, Fang Fang.Distributionally robust optimization of electricity-heat-hydrogen integrated energy system with wind and solar uncertainties[J]. Transactions of China Electrotechnical Society, 2023, 38(13): 3473-3485.
[3] 刘玮, 万燕鸣, 熊亚林, 等. 碳中和目标下电解水制氢关键技术及价格平准化分析[J]. 电工技术学报, 2022, 37(11): 2888-2896.
Liu Wei, Wan Yanming, Xiong Yalin, et al.Key technology of water electrolysis and levelized cost of hydrogen analysis under carbon neutral vision[J]. Transactions of China Electrotechnical Society, 2022, 37(11): 2888-2896.
[4] Han Bo, Steen S M, Mo Jingke, et al.Electrochemical performance modeling of a proton exchange membrane electrolyzer cell for hydrogen energy[J]. International Journal of Hydrogen Energy, 2015, 40(22): 7006-7016.
[5] 李军舟, 赵晋斌, 曾志伟, 等. 具有动态调节特性的光伏制氢双阵列直接耦合系统优化策略[J]. 电网技术, 2022, 46(5): 1712-1721.
Li Junzhou, Zhao Jinbin, Zeng Zhiwei, et al.Optimization strategy of photovoltaic hydrogen production dual array direct coupling system with dynamic regulation characteristics[J]. Power System Technology, 2022, 46(5): 1712-1721.
[6] 熊宇峰, 司杨, 郑天文, 等. 基于主从博弈的工业园区综合能源系统氢储能优化配置[J]. 电工技术学报, 2021, 36(3): 507-516.
Xiong Yufeng, Si Yang, Zheng Tianwen, et al.Optimal configuration of hydrogen storage in industrial park integrated energy system based on stackelberg game[J]. Transactions of China Electro-technical Society, 2021, 36(3): 507-516.
[7] 鲁明芳, 李咸善, 李飞, 等. 季节性氢储能-混氢燃气轮机系统两阶段随机规划[J]. 中国电机工程学报, 2023, 43(18): 6978-6992.
Lu Mingfang, Li Xianshan, Li Fei, et al.Two-stage stochastic programming of seasonal hydrogen energy storage and mixed hydrogen-fueled gas turbine system[J]. Proceedings of the CSEE, 2023, 43(18): 6978-6992.
[8] Huang Chunjun, Zong Yi, You Shi, et al.Economic model predictive control for multi-energy system considering hydrogen-thermal-electric dynamics and waste heat recovery of MW-level alkaline electro-lyzer[J]. Energy Conversion and Management, 2022, 265: 115697.
[9] Nguyen T T, Kim H M.Cluster-based predictive PCC voltage control of large-scale offshore wind farm[J]. IEEE Access, 2020, 9: 4630-4641.
[10] Kumar S S, Nirmal Mukundan C M, Jayaprakash P. Modified LMS control for a grid interactive PV-fuel cell-electrolyzer hybrid system with power dispatch to the grid[J]. IEEE Transactions on Industry Applications, 2022, 58(6): 7907-7918.
[11] Abdelghany M B, Faisal Shehzad M, Liuzza D, et al.Modeling and optimal control of a hydrogen storage system for wind farm output power smoothing[C]//2020 59th IEEE Conference on Decision and Control (CDC), Jeju, Korea (South), 2020: 49-54.
[12] Huang Chunjun, Zong Yi, You Shi, et al.Cooperative control of wind-hydrogen-SMES hybrid systems for fault-ride-through improvement and power smoothing[J]. IEEE Transactions on Applied Superconductivity, 2021, 31(8): 1-7.
[13] Guerra O J, Eichman J, Kurtz J, et al.Cost competitiveness of electrolytic hydrogen[J]. Joule, 2019, 3(10): 2425-2443.
[14] Tjarks G, Gibelhaus A, Lanzerath F, et al.Energetically-optimal PEM electrolyzer pressure in power-to-gas plants[J]. Applied Energy, 2018, 218: 192-198.
[15] Correa G, Marocco P, Muñoz P, et al.Pressurized PEM water electrolysis: dynamic modelling focusing on the cathode side[J]. International Journal of Hydrogen Energy, 2022, 47(7): 4315-4327.
[16] Scheepers F, Stähler M, Stähler A, et al.Improving the efficiency of PEM electrolyzers through membrane-specific pressure optimization[J]. Energies, 2020, 13(3): 612.
[17] Scheepers F, Stähler M, Stähler A, et al.Temperature optimization for improving polymer electrolyte membrane-water electrolysis system efficiency[J]. Applied Energy, 2021, 283: 116270.
[18] 邓智宏, 江岳文. 考虑制氢效率特性的风氢系统容量优化[J]. 可再生能源, 2020, 38(2): 259-266.
Deng Zhihong, Jiang Yuewen.Optimal sizing of a wind-hydrogen system under consideration of the efficiency characteristics of electrolysers[J]. Renewable Energy Resources, 2020, 38(2): 259-266.
[19] Keller R, Rauls E, Hehemann M, et al.An adaptive model-based feedforward temperature control of a 100 kW PEM electrolyzer[J]. Control Engineering Practice, 2022, 120: 104992.
[20] 沈小军, 聂聪颖, 吕洪. 计及电热特性的离网型风电制氢碱性电解槽阵列优化控制策略[J]. 电工技术学报, 2021, 36(3): 463-472.
Shen Xiaojun, Nie Congying, Lü Hong.Coordination control strategy of wind power-hydrogen alkaline electrolyzer bank considering electrothermal charac-teristics[J]. Transactions of China Electrotechnical Society, 2021, 36(3): 463-472.
[21] 唐司航. 基于风电功率最值预测的电解槽阵列轮换控制策略研究[D]. 石家庄: 河北科技大学, 2022.
Tang Sihang.Research on control strategy of alkaline electrolyzer array with rotation mode based on best value forecast for wind power[D]. Shijiazhuang: Hebei University of Science and Technology, 2022.
[22] 卢昕宇, 杜帮华, 赵波, 等. 基于链式分配策略的风氢耦合系统设计与控制[J]. 太阳能学报, 2022, 43(6): 405-413.
Lu Xinyu, Du Banghua, Zhao Bo, et al.Design and control of wind-hydrogen coupled system based on chain distribution strategy[J]. Acta Energiae Solaris Sinica, 2022, 43(6): 405-413.
[23] Luxa A, Jöres N, Yáñez C, et al.Multilinear modeling and simulation of a multi-stack PEM electrolyzer with degradation for control concept comparison[C]//Proceedings of the 12th International Conference on Simulation and Modeling Methodologies, Technologies and Applications, Lisbon, Portugal, 2022: 52-62.
[24] Bareiß K, de la Rua C, Möckl M, et al. Life cycle assessment of hydrogen from proton exchange membrane water electrolysis in future energy systems[J]. Applied Energy, 2019, 237: 862-872.
[25] Sakas G, Ibáñez-Rioja A, Ruuskanen V, et al.Dynamic energy and mass balance model for an industrial alkaline water electrolyzer plant process[J]. International Journal of Hydrogen Energy, 2022, 47(7): 4328-4345.
[26] Tiktak W J.Heat management of PEM electrolysis[D]. Delft: Delft University of Technology, 2019.
[27] Zheng Yi, You Shi, Bindner H W, et al.Optimal day-ahead dispatch of an alkaline electrolyser system concerning thermal-electric properties and state-transitional dynamics[J]. Applied Energy, 2022, 307: 118091.
[28] 游双矫. 中石油为雄安新区供氢方式优化的研究[D]. 北京: 中国石油大学(北京), 2020.
Yon Shuangjiao.Research on optimization of hydrogen supplies for Xiongan New Area by CNPC[D]. Beijing: China University of Petroleum, 2020.
[29] 徐卫君, 张伟, 胡宇涛, 等. 先进绝热压缩空气储能多能流优化调度模型[J]. 电工技术学报, 2022, 37(23): 5944-5955.
Xu Weijun, Zhang Wei, Hu Yutao, et al.Multi energy flow optimal scheduling model of advanced adiabatic compressed air energy storage[J]. Transactions of China Electrotechnical Society, 2022, 37(23): 5944-5955.
[30] Skorek-Osikowska A, Bartela Ł, Katla D, et al.Thermodynamic assessment of the novel concept of the energy storage system using compressed carbon dioxide, methanation and hydrogen generator[J]. Fuel, 2021, 304: 120764.
[31] 张理, 韩民晓, 范溢文. 多相堆叠交错并联制氢变换器控制策略与特性分析[J]. 电工技术学报, 2023, 38(2): 485-495.
Zhang Li, Han Minxiao, Fan Yiwen.Control strategy and characteristic analysis of multi-phase stacked interleaved buck converter for hydrogen production[J]. Transactions of China Electrotechnical Society, 2023, 38(2): 485-495.
[32] 任洲洋, 王皓, 李文沅, 等. 基于氢能设备多状态模型的电氢区域综合能源系统可靠性评估[J]. 电工技术学报, 2023, 38(24): 6744-6759.
Ren Zhouyang, Wang Hao, Li Wenyuan, et al.Reliability evaluation of electricity-hydrogen regional integrated energy systems based on the multi-state models of hydrogen energy equipment[J]. Transactions of China Electrotechnical Society, 2023, 38(24): 6744-6759.
[33] Ayachit A, Kazimierczuk M K.Averaged small-signal model of PWM DC-DC converters in CCM including switching power loss[J]. IEEE Transactions on Circuits and Systems II: Express Briefs, 2019, 66(2): 262-266.
[34] Talebian I, Alavi P, Marzang V, et al.Analysis, design, and investigation of a soft-switched buck converter with high efficiency[J]. IEEE Transactions on Power Electronics, 2022, 37(6): 6899-6912.
[35] Yigit T, Selamet O F.Mathematical modeling and dynamic Simulink simulation of high-pressure PEM electrolyzer system[J]. International Journal of Hydrogen Energy, 2016, 41(32): 13901-13914.
[36] Rizwan M, Alstad V, Jäschke J.Design considerations for industrial water electrolyzer plants[J]. International Journal of Hydrogen Energy, 2021, 46(75): 37120-37136.
[37] 宋天昊, 李柯江, 韩肖清, 等. 储能系统参与多应用场景的协同运行策略[J]. 电力系统自动化, 2021, 45(19): 43-51.
Song Tianhao, Li Kejiang, Han Xiaoqing, et al.Coordinated operation strategy of energy storage system participating in multiple application scenarios[J]. Automation of Electric Power Systems, 2021, 45(19): 43-51.