|
|
|
| Design and Efficiency Optimization of a High Step-Up Converter for DC Microgird |
| Luo Peng1, Pan Jinchao2, Hong Junzhe1, Liu Mingxin1 |
1. School of Electronic and Information Engineering Guangdong Ocean University Zhanjiang 524088 China;
2. School of Automation Guangdong University of Technology Guangzhou 510006 China |
|
|
|
Abstract Since the excessive use of fossil energy has caused global warming and an energy crisis, clean energy development has gained much more attention. In order to reduce the impact of clean energy based distributed generation grid-connect, improving the conversion efficiency and reliable performance, DC microgrid plays an important role. However, the low output voltage of clean energy should be boosted to a suitable voltage level of the DC microgrid grid-connected. Therefore, a high step-up DC-DC converter using switched coupled inductor and passive clamp circuit is proposed. The switched coupled inductor technique is connected to the input and the output parts, and the voltage gain can be further improved by adjusting the turns ratio of the coupled inductor. In addition, by applying a passive clamp circuit, the energy stored in the leakage inductor is recycled, and the voltage spike on the power switch can be suppressed. Hence, the voltage stress on the switch is reduced, and the efficiency can be improved.
The operating principles and steady-state performance in continuous conduction mode (CCM) and discontinuous conduction mode (DCM) are analyzed in detail. The operating mode is analyzed through the key waveforms and equivalent circuits. Considering the coupling coefficient has no significant effect on the voltage gain, the ideal voltage gain is (2+n)/(1-D) where n=ns/np. Under n=2 and D=0.6, the voltage gain can reach 10. Hence, the proposed converter can achieve high voltage gain. Meanwhile, the voltage stress and current stress of components are studied, including semiconductor devices and passive devices. Moreover, the parameters of the magnetizing inductor and capacitors are designed.
The power loss is divided into four parts: power switch, diode, capacitor, and inductor losses. The theoretical efficiency and non-ideal voltage gain are obtained. Compared with the ideal and non-ideal voltage gains at the appropriate duty cycle, the effect of parasitic parameters of components is negligible. The proposed converter has higher voltage gain and efficiency, lower voltage stress of the power switch, and fewer components than the high step-up converter.
A 40 V-input, 400 V-output, 250 W experimental prototype is built by choosing the proper value and type of components. Considering the inductor loss, the material of core and turns ratio are selected to achieve the highest efficiency. The measured voltage and current of components are consistent with the theoretical analysis. Also, the measured maximum and full-load efficiencies are 97.59 % and 97.10 %, respectively. Total power loss is 5.49 W at 250 W. The proposed converter has the following advantages.
(1) The high voltage gain is obtained by switched coupled inductor, suitable for the DC microgrid grid-connected.
(2) Through the experiment results, the low voltage stress of the power switch validates that the passive clamp circuit inhibits the voltage spike effectively.
(3) The beneficial parameters are chosen to improve the efficiency, verifying the power loss analyses through the experiment.
(4) Fewer components are required, which improves reliability.
|
|
Received: 29 November 2022
|
|
|
|
|
|
[1] 姚子睿, 曾君, 刘俊峰. 基于耦合电感的高增益低电压应力Boost变换器[J]. 中国电机工程学报, 2019, 39(12): 3659-3667.
Yao Zirui, Zeng Jun, Liu Junfeng.High step-up low- voltage stress Boost converter based on coupled inductor[J]. Proceedings of the CSEE, 2019, 39(12): 3659-3667.
[2] Liang T J, Luo Peng, Chen Kaihui.A high step-up DC-DC converter with three-winding coupled indu- ctor for sustainable energy systems[J]. IEEE Transa- ctions on Industrial Electronics, 2022, 69(10): 10249-10258.
[3] 孙孝峰, 张绘欣, 张涵, 等. 一种用于电-氢多能互补型微电网的双有源桥集成Boost拓扑及其控制[J]. 电工技术学报, 2021, 36(10): 2092-2104.
Sun Xiaofeng, Zhang Huixin, Zhang Han, et al.Topo- logy and control strategy of dual active bridge integrated Boost circuit for electro-hydrogen multi- energy complementary microgrid[J]. Transactions of China Electrotechnical Society, 2021, 36(10): 2092-2104.
[4] 张沈习, 王丹阳, 程浩忠, 等. 双碳目标下低碳综合能源系统规划关键技术及挑战[J]. 电力系统自动化, 2022, 46(8): 189-207.
Zhang Shenxi, Wang Danyang, Cheng Haozhong, et al.Key technologies and challenges of low-carbon integrated energy system planning for carbon emission peak and carbon neutrality[J]. Automation of Electric Power Systems, 2022, 46(8): 189-207.
[5] 侯金鸣, 孙蔚, 肖晋宇, 等. 电力系统关键技术进步与低碳转型的协同优化[J]. 电力系统自动化, 2022, 46(13): 1-9.
Hou Jinming, Sun Wei, Xiao Jinyu, et al.Collabo- rative optimization of key technology progress and low-carbon transition of power systems[J]. Auto- mation of Electric Power Systems, 2022, 46(13): 1-9.
[6] Majeed Y E, Ahmad I, Habibi D.A multiple-input cascaded DC-DC converter for very small wind tur- bines[J]. IEEE Transactions on Industrial Electronics, 2019, 66(6): 4414-4423.
[7] 佟子昂, 武建文, 马速良, 等. 一种基于主动电压扰动的直流微网负载均流控制策略[J]. 电工技术学报, 2019, 34(24): 5199-5208.
Tong Ziang, Wu Jianwen, Ma Suliang, et al.A load current-sharing control strategy for DC microgrid converters based on active voltage disturbance[J]. Transactions of China Electrotechnical Society, 2019, 34(24): 5199-5208.
[8] 吴卫民, 何远彬, 耿攀, 等. 直流微网研究中的关键技术[J]. 电工技术学报, 2012, 27(1): 98-106, 113.
Wu Weimin, He Yuanbin, Geng Pan, et al.Key tech- nologies for DC micro-grids[J]. Transactions of China Electrotechnical Society, 2012, 27(1): 98-106, 113.
[9] 郭慧, 汪飞, 顾永文, 等. 基于电压分层控制的直流微电网及其储能扩容单元功率协调控制策略[J]. 电工技术学报, 2022, 37(12): 3117-3131.
Guo Hui, Wang Fei, Gu Yongwen, et al.Coordinated Power control strategy for DC microgrid and storage expansion unit based on voltage hierarchical con- trol[J]. Transactions of China Electrotechnical Society, 2022, 37(12): 3117-3131.
[10] 王攀攀, 段森, 于东升, 等. 一种新型高增益零输入纹波DC-DC变换器[J]. 太阳能学报, 2020, 41(12): 18-25.
Wang Panpan, Duan Sen, Yu Dongsheng, et al.A novel high voltage gain zero input-current ripple DC-DC converter[J]. Acta Energiae Solaris Sinica, 2020, 41(12): 18-25.
[11] 郭英军, 孔德楷, 汤雨, 等. 考虑寄生参数的双管升压变换器高频工作特性分析[J]. 电工技术学报, 2022, 37(6): 1431-1441.
Guo Yingjun, Kong Dekai, Tang Yu, et al.Analysis of operating characteristics of dual-switch Boost converter considering parasitic parameters under high frequency conditions[J]. Transactions of China Elec- trotechnical Society, 2022, 37(6): 1431-1441.
[12] Ai Jian, Lin Mingyao, Yin Ming.A family of high step-up cascade DC-DC converters with clamped circuits[J]. IEEE Transactions on Power Electronics, 2020, 35(5): 4819-4834.
[13] 周磊, 张宇妍, 秦岭, 等. 低电应力无变压器单管高增益Boost变换器族[J]. 中国电机工程学报, 2020, 40(21): 7036-7047.
Zhou Lei, Zhang Yuyan, Qin Ling, et al.A family of transformer-less single-switch high gain Boost con- verters with low electric stress[J]. Proceedings of the CSEE, 2020, 40(21): 7036-7047.
[14] 唐钧涛, 戚志东, 裴进, 等. 基于电荷泵的燃料电池有源网络升压变换器[J]. 电工技术学报, 2022, 37(4): 905-917.
Tang Juntao, Qi Zhidong, Pei Jin, et al.An active network DC-DC Boost converter with a charge pump employed in fuel cells[J]. Transactions of China Electrotechnical Society, 2022, 37(4): 905-917.
[15] Liang T J,Chen S M,Yang L S, et al.Ultra-large gain step-up switched-capacitor DC-DC converter with coupled inductor for alternative sources of energy[J]. IEEE Transactions on Circuits and Systems I: Regular Papers, 2012, 59(4): 864-874.
[16] 罗全明, 高伟, 吕星宇, 等. 耦合电感型高增益Boost变换器拓扑分析[J]. 中国电机工程学报, 2017, 37(24): 7266-7275, 7441.
Luo Quanming, Gao Wei, Lü Xingyu, et al.Topology analysis of high step-up Boost converters with coupled inductors[J]. Proceedings of the CSEE, 2017, 37(24): 7266-7275, 7441.
[17] Hu Renjun, Zeng Jun, Liu Junfeng, et al.An ultrahigh step-up quadratic Boost converter based on coupled- inductor[J]. IEEE Transactions on Power Electronics, 2020, 35(12): 13200-13209.
[18] 丁杰, 高双, 赵世伟, 等. 基于耦合电感的对称式交错并联低输入电流纹波高增益DC-DC变换器[J]. 电工技术学报, 2021, 36(7): 1507-1515.
Ding Jie, Gao Shuang, Zhao Shiwei, et al.Symmetri- cal interleaved low input current ripple high step-up DC-DC converter based on coupled inductor[J]. Transactions of China Electrotechnical Society, 2021, 36(7): 1507-1515.
[19] Zheng Yifei, Smedley K M.Analysis and design of a single-switch high step-up coupled-inductor Boost converter[J]. IEEE Transactions on Power Electronics, 2020, 35(1): 535-545.
[20] 皇金锋, 谢锋, 罗全明. 一种改进型低电压应力耦合电感高增益Boost变换器[J]. 电机与控制学报, 2020, 24(10): 69-76.
Huang Jinfeng, Xie Feng, Luo Quanming.High step-up improved low voltage-stress Boost converter with coupled inductors[J]. Electric Machines and Control, 2020, 24(10): 69-76.
[21] Hsieh Y P, Chen J F, Liang T J P, et al. Novel high step-up DC-DC converter with coupled-inductor and switched-capacitor techniques for a sustainable energy system[J]. IEEE Transactions on Power Elec- tronics, 2011, 26(12): 3481-3490.
[22] 李洪珠, 刘飞扬, 刘艳, 等. 一种新型磁集成高增益耦合电感倍压Boost变换器[J]. 电工技术学报, 2020, 35(增刊2): 450-460.
Li Hongzhu, Liu Feiyang, Liu Yan, et al.A new magnetically integrated high gain coupled inductance voltage-doubled Boost converter[J]. Transactions of China Electrotechnical Society, 2020, 35(S2): 450-460.
[23] 高伟, 罗全明, 张阳, 等. 一种零输入电流纹波高增益DC-DC变换器[J]. 电工技术学报, 2018, 33(2): 284-292.
Gao Wei, Luo Quanming, Zhang Yang, et al.A high step-up DC-DC converter with zero input current ripple[J]. Transactions of China Electrotechnical Society, 2018, 33(2): 284-292.
[24] 林雪凤, 许建平, 周翔. 谐振软开关耦合电感高增益DC-DC变换器[J]. 电工技术学报, 2019, 34(4): 747-755.
Lin Xuefeng, Xu Jianping, Zhou Xiang.Soft-switched high step-up DC-DC converter with coupled inductor of resonance[J]. Transactions of China Electro- technical Society, 2019, 34(4): 747-755.
[25] Lee S W, Do H L.High step-up coupled-inductor cascade Boost DC-DC converter with lossless passive snubber[J]. IEEE Transactions on Industrial Elec- tronics, 2018, 65(10): 7753-7761.
[26] Mirzaee A, Moghani J S.Coupled inductor-based high voltage gain DC-DC converter for renewable energy applications[J]. IEEE Transactions on Power Electronics, 2020, 35(7): 7045-7057.
[27] 罗全明, 张阳, 闫欢, 等. 一种带耦合电感的有源钳位高增益Boost变换器[J]. 中国电机工程学报, 2014, 34(27): 4576-4583.
Luo Quanming, Zhang Yang, Yan Huan, et al.An active-clamp high step-up Boost converter with coupled-inductor[J]. Proceedings of the CSEE, 2014, 34(27): 4576-4583.
[28] Wang Yijie, Qiu Yuping, Bian Qing, et al.A single switch quadratic Boost high step up DC-DC con- verter[J]. IEEE Transactions on Industrial Electronics, 2019, 66(6): 4387-4397.
[29] 陈章勇, 许建平, 吴建雪, 等. 耦合电感零输入纹波高增益非隔离DC-DC变换器[J]. 中国电机工程学报, 2014, 34(33): 5836-5845.
Chen Zhangyong, Xu Jianping, Wu Jianxue, et al.High voltage gain zero-ripple non-isolated converters with a coupled-inductor[J]. Proceedings of the CSEE, 2014, 34(33): 5836-5845.
[30] Hassan W, Lu D D C, Xiao Weidong. Single-switch high step-up DC-DC converter with low and steady switch voltage stress[J]. IEEE Transactions on Industrial Electronics, 2019, 66(12): 9326-9338.
[31] Kumar G G, Sundaramoorthy K, Karthikeyan V, et al.Switched capacitor-inductor network based ultra-gain DC-DC converter using single switch[J]. IEEE Transa- ctions on Industrial Electronics, 2020, 67(12): 10274-10283.
[32] Bao Danyang, Kumar A, Pan Xuewei, et al.Switched inductor double switch high gain DC-DC converter for renewable applications[J]. IEEE Access, 2021, 9: 14259-14270.
[33] Chen S M, Lao Manlong, Hsieh Y H, et al.A novel switched-coupled-inductor DC-DC step-up converter and its derivatives[J]. IEEE Transactions on Industry Applications, 2015, 51(1): 309-314.
[34] Ding Xinping, Zhou Mingzhu, Cao Yichang, et al.A high step-up coupled-inductor-integrated DC-DC multilevel Boost converter with continuous input current[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2022, 10(6): 7346-7360. |
|
|
|
2023, Vol. 38 
