一种提高级联H桥逆变器功率不平衡运行能力的控制策略

doi:10.19595/j.cnki.1000-6753.tces.220762

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (8241 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The maximum modulation index of the cascaded H-bridge photovoltaic grid-connected inverter controlled by the conventional sinusoidal modulation wave injection strategy (MWIS) is 1, so the working range is small. When the power imbalance is severe, the MWIS will have the problem of over-modulation, leading to the distortion of the grid-connected current. As a result, the output current cannot meet the grid-connected standard, thereby reducing the harvesting ability of photovoltaic energy. In the MWIS, the fine-tuning signal of the modulation signal of each H-bridge module is a part of the modulation wave signal. This paper proposes a modified modulation wave injection strategy (MMWIS). The sinusoidal modulation wave fine-tuning signal in the MWIS can be replaced with a part of the difference between the square wave signal in the same phase as the inductor current and the common modulation wave signal, thereby improving the active power transmission range of the system.
The implementation procedures of the MMWIS are as follows. First, the PI controller in the total voltage outer loop calculates the amplitude signal of the grid-connected current. The current inner loop calculates the common modulation signal of each H-bridge unit, and the voltage produced by this modulation signal represents the multi-level voltage on the AC side of the cascaded H-bridge inverter. Second, the remainder of the common modulation wave signal subtracted from the square wave signal (in the same phase as the ac current) is multiplied by the injection coefficient output by the voltage balancing PI controller of each H-bridge unit. The modification signal of each H-bridge unit can be obtained to replace the sine wave modification signal in the MWIS. Third, the low-power cells may be over-modulated around the zero-crossing point due to the large opposite injected modification signals. During the over-modulation period of the low-power modules, the fine-tuning amounts of all modules must be multiplied by the same coefficient to solve the over-modulation problem. At the same time, this common coefficient ensures that the sum of the AC voltages produced by the modulation wave of each H-bridge unit is equal to that produced by the common modulation signal.
The simulation and experimental results are as follows. First, the MMWIS can achieve a smooth transition between various working conditions, and the inductor current distortion is small. Second, when the power imbalance is large, compared with conventional methods such as the sinusoidal modulation wave injection strategy and third harmonic compensation strategy, the MMWIS can still maintain high grid-connected current quality. Third, the DC voltage fluctuation of the high-power module is small under the control of MMWIS. Because the peak value of the modulation wave reaches 1 only when the modulation ratio is equal to 1.27 in this method, the instantaneous power fluctuation of the high-power H-bridge unit is small.
The conclusions are as follows. The MMWIS can further improve the ability of high-power modules to transmit active power. The AC side fundamental voltage and current of the high-power module are in the same phase when the peak value of the modulation wave reaches 1.27, thereby transmitting the maximum active power. In addition, the MMWIS can overcome the problem of grid-connected current distortion caused by over-modulation in some areas due to the superposition of too many reverse adjustment quantities for low-power modules.

Key words： Cascaded H-bridge current distortion power imbalance modified strategy

Received: 07 May 2022

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Li Jinyu
	Chen Jie
	Gong Chunying
	He Qing

Cite this article:

Li Jinyu,Chen Jie,Gong Chunying等. A Control Strategy to Improve Working Ability of Cascaded H-Bridge Inverter Under Power Imbalance[J]. Transactions of China Electrotechnical Society, 2023, 38(10): 2731-2743.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.220762 OR https://dgjsxb.ces-transaction.com/EN/Y2023/V38/I10/2731

[1] 叶满园, 任威, 李宋, 等. 基于控制载波自由度的级联H桥逆变器改进型PWM技术[J]. 电工技术学报, 2021, 36(14): 3010-3021.
Ye Manyuan, Ren Wei, Li Song, et al.Improved PWM technology of cascaded H-bridge inverter based on control of carrier degree of freedom[J]. Transa- ctions of China Electrotechnical Society, 2021, 36(14): 3010-3021.
[2] Babaei E, Laali S, Alilu S.Cascaded multilevel inver- ter with series connection of novel H-bridge basic units[J]. IEEE Transactions on Industrial Electronics, 2014, 61(12): 6664-6671.
[3] 王琛琛, 李永东. 多电平变换器拓扑关系及新型拓扑[J]. 电工技术学报, 2011, 26(1): 92-99.
Wang Chenchen, Li Yongdong.Multilevel converter topologies and two novel topologies[J]. Transactions of China Electrotechnical Society, 2011, 26(1): 92-99.
[4] Zhang Zhiyu, Zhao Hengyang, Fu Shihang, et al.Voltage and power balance control strategy for three- phase modular cascaded solid stated transfor- mer[C]//2016 IEEE Applied Power Electronics Con- ference and Exposition (APEC), Long Beach, CA, 2016: 1475-1480.
[5] 陈轶涵, 郭鸿浩, 陈家伟. 基于载波移相控制的模块化串并联逆变器非理想条件谐波特性分析[J]. 电工技术学报, 2020, 35(8): 1690-1704.
Chen Yihan, Guo Honghao, Chen Jiawei.Analysis of harmonic characteristics in non-ideal conditions of modular series/parallel inverter based on carrier phase shift control[J]. Transactions of China Electrotech- nical Society, 2020, 35(8): 1690-1704.
[6] Zhang Yang, Chen Xin, Sun Jian.Sequence impe- dance modeling and analysis of MMC in single-star configuration[J]. IEEE Transactions on Power Elec- tronics, 2020, 35(1): 334-346.
[7] 李响, 郭希铮, 游小杰, 等. 一种改进的级联H桥整流器直流电压平衡策略[J]. 电工技术学报, 2017, 32(4): 66-75.
Li Xiang, Guo Xizheng, You Xiaojie, et al.An advanced DC voltage balance strategy for cascaded H-bridge rectifier[J]. Transactions of China Electro- technical Society, 2017, 32(4): 66-75.
[8] Yu Yifan, Konstantinou G, Hredzak B, et al.Oper- ation of cascaded H-bridge multilevel converters for large-scale photovoltaic power plants under bridge failures[J]. IEEE Transactions on Industrial Elec- tronics, 2015, 62(11): 7228-7236.
[9] Chavarria J, Biel D, Guinjoan F, et al.Energy-balance control of PV cascaded multilevel grid-connected inverter under level-shifted and phase-shifted PWMs[J]. IEEE Transactions on Industrial Electro- nics, 2013, 60(1): 98-111.
[10] Wang Liang, Zhang Donglai, Wang Yi, et al.Power and voltage balance control of a novel three-phase solid-state transformer using multilevel cascaded H-bridge inverters for microgrid applications[J]. IEEE Transactions on Power Electronics, 2016, 31(4): 3289-3301.
[11] Blahnik V, Kosan T, Peroutka Z, et al.Control of a single-phase cascaded H-bridge active rectifier under unbalanced load[J]. IEEE Transactions on Power Electronics, 2018, 33(6): 5519-5527.
[12] 王书征, 赵剑锋, 姚晓君, 等. 级联型光伏并网逆变器在光照不均匀条件下的功率平衡控制[J]. 电工技术学报, 2013, 28(12): 251-261.
Wang Shuzheng, Zhao Jianfeng, Yao Xiaojun, et al.Power balanced controlling of cascaded inverter for grid-connected photovoltaic systems under unequal irradiance conditions[J]. Transactions of China Elec- trotechnical Society, 2013, 28(12): 251-261.
[13] She Xu, Huang A Q, Zhao Tiefu, et al.Coupling effect reduction of a voltage-balancing controller in single-phase cascaded multilevel converters[J]. IEEE Transactions on Power Electronics, 2012, 27(8): 3530-3543.
[14] 王昕, 王琛琛, 顾长彬. 级联H桥整流器稳定运行区域和直流侧电压平衡策略的调节能力分析[J]. 电工技术学报, 2019, 34(14): 2970-2979.
Wang Xin, Wang Chenchen, Gu Changbin.Analysis about steady-state operating region and regulation capacity of voltage balance strategy for cascaded H-bridge rectifier[J]. Transactions of China Electro- technical Society, 2019, 34(14): 2970-2979.
[15] Eskandari A, Javadian V, Iman-Eini H, et al.Stable operation of grid connected cascaded H-bridge inverter under unbalanced in solation conditions[C]// Proceeding of the Third International Conference on Electrical Power Energy Conversion System, Istanbul, Turkey, 2014: 1-6.
[16] Iman-Eini H, Bacha S, Frey D.Improved control algorithm for grid-connected cascaded H-bridge photovoltaic inverters under asymmetric operating conditions[J]. IET Power Electronics, 2018, 11(3): 407-415.
[17] Liu Liming, Li Hui, Xue Yaosuo, et al.Reactive power compensation and optimization strategy for grid-interactive cascaded photovoltaic systems[J]. IEEE Transactions on Power Electronics, 2014, 30(1): 188-202.
[18] Liu Liming, Li Hui, Xue Yaosuo, et al.Decoupled active and reactive power control for large-scale grid- connected photovoltaic systems using cascaded modular multilevel converters[J]. IEEE Transactions on Power Electronics, 2015, 30(1): 176-187.
[19] Xiao Bailu, Hang Lijun, Mei Jun, et al.Modular cascaded H-bridge multilevel PV inverter with istri- buted MPPT for grid-connected applications[J]. IEEE Transactions on Industry Applications, 2015, 51(2): 1722-1731.
[20] Ko Y, Andresen M, Buticchi G, et al.Power routing for cascaded H-bridge converters[J]. IEEE Transa- ctions on Power Electronics, 2017, 32(12): 9435-9446.
[21] Zhao Tao, Zhang Xing, Mao Wang, et al.An opti- mized third harmonic compensation strategy for single-phase cascaded H-bridge photovoltaic inver- ter[J]. IEEE Transactions on Industrial Electronics, 2018, 65(11): 8635-8645.
[22] Zhao Tao, Zhang Xing, Mao Wang, et al.A modified hybrid modulation strategy for suppressing DC voltage fluctuation of cascaded H-bridge photovoltaic inverter[J]. IEEE Transactions on Industrial Electro- nics, 2018, 65(5): 3932-3941.
[23] Miranbeigi M, Iman-Eini H.Hybrid modulation technique for grid-connected cascaded photovoltaic systems[J]. IEEE Transactions on Industrial Elec- tronics, 2016, 63(12): 7843-7853.
[24] Moosavi M, Farivar G, Iman-Eini H, et al.A voltage balancing strategy with extended operating region for cascaded H-bridge converters[J]. IEEE Transactions on Power Electronics, 2014, 29(9): 5044-5053.
[25] Wang Mingda, Zhang Xing, Zhao Tao, et al.Harmonic compensation strategy for single-phase cascaded H-bridge PV inverter under unbalanced power conditions[J]. IEEE Transactions on Industrial Electronics, 2020, 67(12): 10474-10484.
[26] Zhao Tao, Zhang Xing, Mao Wang, et al.Harmonic compensation strategy for extending the operating range of cascaded H-bridge PV inverter[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2020, 8(2): 1341-1350.
[27] Zhao Tao, Chen Daolian.A power adaptive control strategy for further extending the operation range of single-phase cascaded H-bridge multilevel PV inver- ter[J]. IEEE Transactions on Industrial Electronics, 2022, 69(2): 1509-1520.