低频电压下含纤维素颗粒变压器油绝缘特性及影响因素研究

doi:10.19595/j.cnki.1000-6753.tces.222061

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (1520 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Low-frequency transformer is the key equipment in low-frequency transmission system, the insulation characteristics under low-frequency voltage have important meaning for its design and operation. In this paper, so as to study the insulation characteristics of transformer oil containing cellulose particles under low-frequency voltage, transformer oil breakdown tests at different cellulose particle size (low, medium and high) levels under AC voltages of 20Hz, 30Hz, 40Hz and 50Hz were conducted.
In this paper, the test frequency was selected as 20Hz, 30Hz, 40Hz and 50Hz, and the content of cellulose particles in oil samples was selected as low, medium and high particle size levels. According to IEC60156 standard, the pressure was increased step by step at a constant rate of 2kV/s to the oil sample breakdown, and the oil sample in the oil cup was replaced every 6 times after breakdown. In order to ensure the consistency of the test, 30 times of breakdown tests were repeated respectively at each frequency and particle size level, and the effective value of breakdown voltage was recorded. Weibull distribution method was used to analyze the test results. The test results show that at the low particle size level, the breakdown voltage at 50Hz is taken as the reference, and the breakdown voltage at 20Hz, 30Hz and 40Hz is increased by 12.25%, 25.62% and 39.14%, respectively. At the high particle level, the breakdown voltage increases 21.45%, 83.69% and 97.30% at 20Hz, 30Hz and 40Hz, respectively.
At the same time, the accumulation process of cellulose particles at the electrode was observed by experiments, and the movement of cellulose particles in transformer oil at different frequencies was analyzed by multi-physical field simulation. In this paper, an observation test was carried out on the motion characteristics of cellulose particles for transformer oil with high particle size level. 18kV was selected as the test voltage and carried out at room temperature. The distribution state of cellulose particles between electrodes was observed with a camera. Finally, COMSOL finite element software "AC-DC module" and "Particle tracking module" are used to simulate the motion trajectory of particles in the slightly uneven field of transformer oil under four frequencies. The results showed that the agglomeration rate of particles towards the electrode at low frequency 20Hz was significantly lower than that at power frequency 50Hz, and more impurities would accumulate near the electrode at 50Hz, and the bridge of impurities was wider than that at 20Hz.
The results show that the AC voltage frequency has a significant effect on the bridge formation characteristics and breakdown voltage of cellulose particles in transformer oil. When the transformer is running, the breakdown voltage of transformer oil increases with the decrease of AC voltage frequency, and the higher the granularity level, the more significant the difference of breakdown voltage between frequencies. The frequency of AC voltage will affect the moving speed of impurity particles and the formation process of impurity Bridges in transformer oil. The research results of this paper provide basic data support for the design, operation and maintenance of low-frequency transformer.

Key words： Transformer oil alternating current voltage low-frequency transmission cellulose particles movement

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Liu Yunpeng
	Zhao Jiaying
	Liu Hechen
	Zhao Tao
	Yin Ziao

Cite this article:

Liu Yunpeng,Zhao Jiaying,Liu Hechen等. Effect of AC Voltage and Frequency on Insulation Characteristics of Transformer Oil Containing Cellulose Particles[J]. Transactions of China Electrotechnical Society, 0, (): 118-118.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.222061 OR https://dgjsxb.ces-transaction.com/EN/Y0/V/I/118

[1] 林进钿,倪晓军,裘鹏.柔性低频交流输电技术研究综述[J].浙江电力,2021,40(10):42-50.
LIN Jintian, NI Xiaojun and Qiu Peng. Review of Flexible Low-frequency AC Transmission Technology[J]. Zhejiang Electric Power, 201,40(10):42-50.
[2] 王邦彦,王秀丽,王碧阳,等.海上风电分频送出系统可靠性评估模型及方法[J].电网技术,2022,46(08):2899-2909.
WANG Bangyan, WANG Xiuli and WANG Biyang, et al. Reliability Evaluation Model and Method of frequency distribution System for Offshore Wind Power[J]. Power Grid Technology, 222,46(08):2899-2909.
[3] Hao C, Johnson M H and Aliprantis D C. Low-Frequency AC Transmission for Offshore Wind Power[J]. IEEE Transactions on Power Delivery, 2013, 28(4):2236-2244.
[4] 张永泽,唐炬,潘成,骆欣瑜,姚雨杭.油流速度对含气泡变压器油击穿特性的影响[J].电工技术学报,2022,37(02):479-487.
Zhang Yongze, Tang Ju, Pan Cheng,et al.Influence of Oil Flow Velocity on Breakdown Characteristics of Oil in Transformer Containing Bubble[J]. Transactions of China Electrotechnical Society,2022,37(02):479-487.
[5] 董明,杨凯歌,马馨逸,胡一卓,谢佳成,徐广昊.纳米改性变压器油中载流子输运特性分析[J].电工技术学报,2020,35(21):4597-4608.
Dong Ming, Yang Kaige, Ma Xinyi, et alAnalysis of Carrier Transport Characteristics in Nano-modified Transformer Oil[J]. Transactions of China Electrotechnical Society,20,35(21):4597-4608.
[6] 李博程,程涣超,孙倩,等.交直流电压分量对变压器油中典型模型击穿特性影响[J].电工技术学报,2011,26(02):34-38
Li Bo, CHENG Huanchao and Sun Qian, et al. AC/DC voltage component influence of typical model in transformer oil breakdown characteristic[J]. Journal of electrotechnics, 2011, 26(02):34-38.
[7] 王有元,李熙,李原龙,等.交直流复合电压下铜颗粒在油中的分布及对绝缘油击穿特性的影响[J].电工技术学报,2018,33(23):5581-5590.
Wang Youyuan, Li xi and LI yuanlong, et al. Distribution of Copper Particles in Oil and Its Effect on Breakdown Characteristics of Insulating Oil under AC-DC Composite Voltage[J]. Transactions of the China Electrotechnical Society, 2018,33(23):5581-5590.
[8] 郝建,但敏,廖瑞金,等.颗粒属性对矿物绝缘油直流击穿特性的影响差异及原因分析[J].电工技术学报,2019,34(24):5270-5281.
Hao Jian, Dan Min and Liao RuiJin, et al. Effect of Particle Properties on DC Breakdown Characteristics of Mineral Insulating Oil and Its cause Analysis[J]. Electrotechnical journal, 2019 (24) : 5270-5281.
[9] Lu W and Liu Q. Effect of cellulose particles on impuls breakdown in ester transformer liquids in uniform electric fields[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2015, 22(5): 2554-2564.
[10] 贺博,王鹏,吴锴,胡小博,杨冬.多物理场中染污绝缘油内杂质相动力学行为研究综述[J].电工技术学报,2022,37(01):266-282.
He Bo, Wang Peng, Wu Kai, et al.Review on kinetic behavior of impurity phase in contaminated insulating oil in multiple physical fields[J]. Transactions of China Electrotechnical Society,2022,37(01):266-282.
[11] 陈彬,韩超,刘阁.颗粒污染物对变压器油击穿电压的影响[J].高电压技术,2018,44(12):3903-3909.
Chen Bin, Han Chao and Liu Ge. Influence of Particle contaminants on breakdown voltage of transformer oil[J]. High Voltage Technology,2018,44(12):3903-3909.
[12] 贾江波,张乔根,师晓岩,等.交流电压下绝缘子附近导电微粒运动特性[J].电工技术学报,2008(05):7-11.
JIA Jiangbo, ZHANG Qiaogen and SHI Xiaoyan, et al. Under ac voltage insulator nearby conductive particle movement characteristics[J]. Journal of electrical engineering technology, 2008 (5) :7-11.
[13] Zhang J, Li J, Huang D, et al.Influence of nonmetallic particles on the breakdown strength of vegetable insulating oil[C]//IEEE Conference on Electrical Insulation and Dielectric Phenomena (CEIDP). IEEE, 2015: 609-612.
[14] Hao J, Dan M and Liao R, et al. Effect of moisture on particles accumulation and oil breakdown characteristics in mineral oil and natural ester under non-uniform DC electrical field[J]. IEEE Access, 2019, 7: 101785-101794.
[15] 杜岳凡,李成榕,吕玉珍,等.TiO_2纳米颗粒对矿物及植物纳米变压器油中电荷输运特性的影响[J].高电压技术,2013,39(08):1941-1946.
Du Yuefan, Li Chengrong and Lv Yuzhen, et al. Effect of TiO_2 Nanoparticles on Charge Transport Characteristics in Mineral and Plant Nanotransformer Oil[J]. High Voltage Technology,2013,39(08):1941-1946.
[16] 姚志松,姚磊.变压器油的选择、使用和处理[M].北京: 机械工业出版社,2007.
Yao Zhisong and Yao Lei. Selection, Use and Treatment of Transformer Oil[M]. Beijing: China Machine Press, 2007.
[17] Mahmud S, Golosnoy I O and Chen G, et al. Numerical simulations of bridging phenomena in contaminated transformer oil[C]//IEEE. IEEE, 2012:6-10
[18] Mahmud S, Golosnoy I O, Chen G, et al.Effect of Kraft Paper barriers on bridging in contaminated transformer oil[C]//2014 IEEE Conference on Electrical Insulation and Dielectric Phenomena (CEIDP). IEEE, 2014: 110-113.
[19] 梁晨,伍衡,李原龙,等.油中碳颗粒对交直流复合电压下绝缘油击穿特性的影响[J].绝缘材料,2018,51(04):21-27.
Liang Chen, Wu Heng and LI Yuanlong,et al. Carbon particles in oil, insulating oil breakdown characteristic of ac/dc composite voltages[J]. The influence of insulation materials, ploidy of 2018 (04) : 21-27
[20] 郝建,秦威,但敏,等.交流和直流电压下纤维和金属颗粒对天然酯击穿特性的影响差异研究[J].高电压技术,2020,46(01):195-204.
Hao Jian, Qin Wei and Dan Min,et al. Effects of fiber and metal particles on breakdown Characteristics of natural esters under AC and DC voltages[J]. High Voltage Technology, 2020,46(01):195-204.
[21] 赵涛,律方成,刘云鹏,等.纤维素颗粒物对变压器油冲击击穿特性影响的试验研究[J].电工技术学报,2018,33(07):1626-1633.
Zhao Tao,LV Fang cheng and LIU Yunpeng,et al. Experimental Study on Effect of Cellulose Particulate Matter on Impact and Breakdown Characteristics of Transformer Oil[J]. Journal of Electrical Technology,2018,33(07):1626-1633.
[22] Kurgan E.Comparison of different force calculation methods in DC dielectrophoresis[J]. Electrotech. Rev, 2012, 88: 11-14.
[23] 李原,张乔根,赵毅.直流电压下纤维小桥对油纸复合绝缘局部放电特性的影响[J].高电压技术,2018. 44(11): 3611-3618.
LI Yuan, ZHANG Qiaogen and ZHAO Yi. The influence of small fiber bridges on the partial discharge characteristics of oil-paper composite insulation under DC voltage[J]. High Voltage Engineering, 2018. 44(11): 3611-3618.
[24] 张晓星,张锦斌,唐炬,等.镍掺杂碳纳米管传感器检测变压器油中溶解气体的气敏性[J].中国电机工程学报,2011,31(4):119-124.
ZANG Xiaoxing, ZHANG Jinbin and Tang Ju,et al, LIU Wangting. Nickel-doped carbon nanotube sensor detects gas sensitivity of dissolved gas in transformer oil[J].Proceedings of the Chinese Society of Electrical Engineering,2011,31(4): 119-124.
[25] Jarman P.Mahmud and S. Chen.Experimental Studies of influence of DC and AC Electric Fields on Bridging in Contaminated Transformer Oil.[J]. IEEE Transactions on Dielectrics & Electrical Insulation A Publication of the IEEE Dielectrics & Electrical Insulation Society, 2015.22:152-160
[26] Zhao T, Liu Y and Lv F, et al. Cellulose particle dynamics simulation in transformer oil under non-uniform electric field[C] 2017 IEEE 19th International Conference on Dielectric Liquids (ICDL). IEEE, 2017:1-4.
[27] 蔡文莱,黄亚军,刘伟阳,等.柔性微粒介电泳分离过程的多尺度模拟[J].力学学报,2019,51(02):405-414.
CAI Wenlai, HUANG Yajun and Liu Weiyang, et al. Multi-scale simulation of separation process of flexible particles by electrophoresis[J]. Chinese Journal of Theoretical and Applied Mechanics, 2019,51(02):405-414.
[28] Morgan H and Green N G. Dielectrophoretic manipulation of rodshaped viral particles[J]. J Electrostat, 1997,42(3);279-293.
[29] 陈巧莹. 基于介电泳原理的微尺度颗粒行为分析及微传感器研究[D].成都:西南交通大学,2019.
CHEN Qiaoying.Behavior analysis and microsensor research of micro-scale particles based on the principle of dielectric electrophoresis[D]. Chengdu, Southwest Jiaotong University, 2019.
[30] 孙治谦,周衍涛,李宁,等.非均匀正弦交流电场液滴介电泳迁移规律研究[J].高校化学工程学报,2021,35(03):464-470.
SUN Zhiqian, ZHOU Yantao and Li Ning, et al. Study on electrophoretic migration of droplets in heterogeneous sinusoidal AC electric field[J]. Journal of Chemical Engineering of Chinese Universities, 2021,35(03):464-470.
[31] Mahmud S, Chen G and Golosnoy I O, et al. Experimental studies of influence of different electrodes on bridging in contaminated transformer oil[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2015, 22(5): 2433-2441.
[32] Li Y, Zhang Q and Li J, et al. Study on micro bridge impurities in oil-paper insulation at DC voltage: Their generation, growth and interaction with partial discharge[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(4): 2213-2222.
[33] Y. Li, Q. Zhang and Y. Ding, et al. Effect of cellulose impurities on partial discharges in oil-pressboard insulation under DC voltage[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2017, 24(4): 2271-2273.