电流源型逆变器电机驱动系统的直流链电流控制

doi:10.19595/j.cnki.1000-6753.tces.221716

Abstract
Figure/Table
References
Related Citation (4)

Download: PDF (1350 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Motor drive system can be divided into voltage source inverter(VSI) topology and current source inverter(CSI) topology according to the type of DC side power supply.Compared with VSI, CSI uses inductance as energy storage element, which has high reliability. At the same time, CSI also has the advantages of high output current waveform quality, can realize four quadrant operation of motor load, inherent short circuit protection function and voltage boost function to expand the constant power operation range of motor. However, the DC-link current is not controlled in this way, and the DC-link current will be intermittent or continuously increased. Therefore, a PI controller is designed by using DC-DC converter circuit to control DC-link current. At the same time, the ripple of DC-link current is suppressed by optimizing the current vector sequence of CSI, the inductance and switching loss are reduced, and the current waveform quality of the motor at the output end is improved.
Firstly,in order to realize the control of DC-link current, a DC-DC converter circuit is adopted on the basis of the traditional current source inverter circuit. Through the analysis of different working modes of DC-DC converter, two working modes are selected to realize the control of DC-link current, and the field oriented control of CSI motor drive systemis designed.Secondly, the analysis of the DC-link current ripple of CSI system shows that in order to reduce the DC-link current ripple, the voltage difference between the two ends of the inductance should be reduced without increasing the inductance value and the switching frequency. Therefore, by analyzing the output voltage of DC-DC converter and the input voltage of CSI in a cycle in detail, we can know the voltage difference between the two ends of the inductance. Finally, according to the variation regularity of voltage between the DC-DC converter and CSI in one cycle, a method to optimize CSI current vector sequence is proposed.The feasibility of the method is illustrated through the specific analysis of the three segment SVPWM modulation method, and the feasibility of other more segment modulation methods is analyzed. The method proposed in this paper is tested. By observing the DC-link current in the startup stage and the speed change stage, it can be seen that the DC-link current can be controlled by the DC-DC converter circuit in this paper, and it has good dynamics. The current ripple suppression method does not change the dynamics of the DC side. The experiments of DC-link current ripple suppression at different speeds show that the ripple of DC-link current is reduced. At the same time, the harmonic analysis of the output current is carried out, and the total harmonic distortion of the output current is reduced by using the proposed DC-link current ripple suppression method, which proves the effectiveness of the proposed DC-link current ripple suppression method.
Therefore, the following conclusions can be drawn. This paper presents a DC-link current control method for CSI motor drive system. The method uses DC-DC converter circuit and PI controller to control the DC-link current. After analyzing the voltage variation rule between DC-DC converter and CSI in one cycle, the DC-link current ripple is reduced by optimizing the current vector sequence of CSI. The experimental platform was built and the experimental verification was carried out. The experimental results show that the proposed DC-link current control method can realize the control of DC-link current, reduce the ripple of DC-link current, thus reduce the inductance loss and switching loss, and improve the quality of the current waveform of the motor.

Key words： Current source inverter DC-link current current vector sequence DC-link current ripple

Received: 07 September 2022

PACS:

TM315

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	ZhaoWenxiang
	ZhouShuwen
	Song Shichang
	TaoTao

Cite this article:

ZhaoWenxiang,ZhouShuwen,Song Shichang等. DC-Link Current Control of Current Source Inverter Motor Drive System[J]. Transactions of China Electrotechnical Society, 0, (): 85-85.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.221716 OR https://dgjsxb.ces-transaction.com/EN/Y0/V/I/85

[1] Akbar F, Cha H, Do D T.CSI7: novel three-phase current-source inverter with improved reliability[J]. IEEE Transactions on Power Electronics, 2021, 36(8): 9170-9182.
[2] 黄林森, 赵文祥, 吉敬华, 等. 稳态性能改善的双三相永磁电机直接转矩控制[J]. 电工技术学报, 2022, 37(2): 355-367.
Huang Linsen, Zhao Wenxiang, Ji Jinghua, et al.Direct torque control for dual three-phase permanent-magnet machine with improved steady-state performance[J]. Transactions of China Electrotechnical Society, 2022, 37(2): 355-367.
[3] 贺虎成, 刘卫国, 李榕, 等. 电机驱动用新型谐振直流环节电压源逆变器[J]. 中国电机工程学报, 2008, 28(12): 60-65.
He Hucheng, Liu Weiguo, Li Rong, et al.A novel resonant DC link voltage source inverter for motor drives[J]. Proceedings of the CSEE, 2008, 28(12): 60-65.
[4] 韩应生, 孙海顺, 秦世耀, 等. 电压源型双馈风电并网系统小扰动低频稳定性分析[J]. 电工技术学报, 2023, 38(5): 1312-1324, 1374.
Han Yingsheng, Sun Haishun, Qin Shiyao, et al.Low-frequency stability analysis of voltage-sourced doubly-fed wind power grid-connected system under small disturbance[J]. Transactions of China Electrotechnical Society, 2023, 38(5): 1312-1324, 1374.
[5] Song Yantao, Wang Bingsen.Survey on reliability of power electronic systems[J]. IEEE Transactions on Power Electronics, 2013, 28(1): 591-604.
[6] Guo Xiaoqiang, Sui Sen, Wang Baocheng, et al.A current-based approach for short-circuit fault diagnosis in closed-loop current source inverter[J]. IEEE Transactions on Industrial Electronics, 2020, 67(9): 7941-7950.
[7] Guzman J I, Espinoza J R, Zargari N R, et al.Selective harmonic elimination in multi-modules three-phase current-source converters[C]//2006 IEEE International Symposium on Industrial Electronics, Montreal, QC, Canada, 2007: 1241-1246.
[8] Zhang Yichao, Jahns T M.Uncontrolled generator operation of PM synchronous machine drive with current-source inverter using normally on switches[J]. IEEE Transactions on Industry Applications, 2017, 53(1): 203-211.
[9] 陈超, 陈振, 赵静, 等. 基于五相电流源型逆变器的一种新型PMSM就近空间矢量容错组合策略[J]. 电工技术学报, 2020, 35(增刊2): 404-412.
Chen Chao, Chen Zhen, Zhao Jing, et al.A novel PMSM near space vector fault tolerant combination strategy based on five-phase current source inverter[J]. Transactions of China Electrotechnical Society, 2020, 35(S2): 404-412.
[10] 王晓琳, 郭慧, 顾聪. 一种基于电流源逆变驱动的超高速永磁同步电机改进型控制策略[J]. 中国电机工程学报, 2022, 42(7): 2733-2744.
Wang Xiaolin, Guo Hui, Gu Cong.An improved control strategy for the ultra-high-speed permanent magnet synchronous motor based on the current source inverter[J]. Proceedings of the CSEE, 2022, 42(7): 2733-2744.
[11] Migliazza G, Buticchi G, Carfagna E, et al.DC current control for a single-stage current source inverter in motor drive application[J]. IEEE Transactions on Power Electronics, 2021, 36(3): 3367-3376.
[12] Xu Yang, Wang Zheng, Liu Pengcheng, et al.A soft-switching current-source-inverter-fed motor drive with reduced common-mode voltage[J]. IEEE Transactions on Industrial Electronics, 2021, 68(4): 3012-3021.
[13] Lee H J, Jung S, Sul S K.A current controller design for current source inverter-fed AC machine drive system[J]. IEEE Transactions on Power Electronics, 2013, 28(3): 1366-1381.
[14] 陈亦文, 邱琰辉, 何勇吉, 等. 储能电感电流限定单周期控制单相电流型PWM逆变器研究[J]. 电工技术学报, 2015, 30(14): 311-319.
Chen Yiwen, Qiu Yanhui, He Yongji, et al.Research on single-phase current mode PWM inverter of one-cycle control strategy with limited storage inductance current[J]. Transactions of China Electrotechnical Society, 2015, 30(14): 311-319.
[15] Su Guijia, Tang Lixin.Current source inverter based traction drive for EV battery charging applications[C]//2011 IEEE Vehicle Power and Propulsion Conference, Chicago, IL, USA, 2011: 1-6.
[16] Zhang Ye, Li Yun wei. Investigation and suppression of harmonics interaction in high-power PWM current-source motor drives[J]. IEEE Transactions on Power Electronics, 2015, 30(2): 668-679.
[17] Li Yun wei, Pande M, Zargari N, et al. DC link current minimization for high power current source motor drives[C]//2008 IEEE Power Electronics Specialists Conference, Rhodes, Greece, 2008: 2505-2511.
[18] Guo Xiaoqiang, Xu D, Wu Bin.Common-mode voltage mitigation for back-to-back current-source converter with optimal space-vector modulation[J]. IEEE Transactions on Power Electronics, 2016, 31(1): 688-697.
[19] Guo Xiaoqiang, Xu D, Guerrero J M, et al.Space vector modulation for DC-link current ripple reduction in back-to-back current-source converters for microgrid applications[J]. IEEE Transactions on Industrial Electronics, 2015, 62(10): 6008-6013.
[20] 肖蕙蕙, 周琛力, 郭强, 等. 用于改善直流链电流纹波的电流源型整流器扇区优化调制策略[J]. 电工技术学报, 2021, 36(24): 5250-5260.
Xiao Huihui, Zhou Chenli, Guo Qiang, et al.Optimized sector modulation strategy of current source rectifier for DC-link current ripple reduction[J]. Transactions of China Electrotechnical Society, 2021, 36(24): 5250-5260.
[21] Cuzner R M, Venkataramanan G.Current source rectifiers in discontinuous conduction modes of operation[J]. IEEE Transactions on Industry Applications, 2015, 51(1): 470-478.