颗粒属性对矿物绝缘油直流击穿特性的影响差异及原因分析

doi:10.19595/j.cnki.1000-6753.tces.181606

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (101057 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The converter transformer is the most important equipment in the EHV/UHVDC transmission project. At present, impurity particles in insulation oil become a threat to the reliable operation of the converter transformer. In this paper, firstly, the effects of different concentrations and sizes of non-metallic fiber particles, copper particles, fiber and copper mixed particles on DC breakdown field strength of mineral were studied experimentally. Then the accumulation behavior of impurity particles in oil was simulated and analyzed using the particle dynamics model and the particle accumulation model. The particle accumulation and its effect on electric field distribution were analyzed. Finally, the differences and reasons of particle properties on DC breakdown of mineral oil were summarized. The results show that the particle properties determine the variation of DC breakdown voltage of insulation oil. The DC breakdown voltage of oil containing pure fiber or copper particles decreases linearly with the increase of particle concentration. The DC breakdown voltage of oil containing fiber and metal particles decreases exponentially with the increase of copper particle concentration. The deterioration degree of metal particles on oil insulation performance is greater than that of single particles, and the increase of fiber particle size further reduces the DC breakdown strength of oil. The results of experiment and simulation show that the bridge phenomenon of particle accumulation appears in the oil under the action of DC electric field. Particle accumulation greatly improves the conductivity of oil and leads to significant distortion of electric field distribution in oil. Compared with the DC breakdown voltage without preloading mode, the DC breakdown strength of oil decreases more than 30% due to the particle accumulation under the DC preloading mode.

Key words： Converter transformer insulation oil impurity particles DC breakdown strength

Received: 09 October 2018 Published: 30 December 2019

PACS:

TM835

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Hao Jian
	Dan Min
	Liao Ruijin
	Li Jian
	Yang Lijun

Cite this article:

Hao Jian,Dan Min,Liao Ruijin等. Influence of Particle Properties on DC Breakdown Characteristics of Mineral Oil and Its Difference Reason Analysis[J]. Transactions of China Electrotechnical Society, 2019, 34(24): 5270-5281.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.181606 OR https://dgjsxb.ces-transaction.com/EN/Y2019/V34/I24/5270

[1] 廖瑞金, 王季宇, 袁媛, 等. 换流变压器下新型纤维素绝缘纸特性综述[J]. 电工技术学报, 2016, 31(10): 1-15.
Liao Ruijin, Wang Jiyu, Yuan Yuan, et al.Review on the characteristic of new cellulose insulation paper used in the converter transformer[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 1-15.
[2] 宓传龙. 超高压换流变压器和平波电抗器绝缘结构简述[J]. 高压电器, 2003, 39(1): 7-15.
Bi Chuanlong.Summarization on the insulation structure of EHV converter transformer and smoothing reactor[J]. High Voltage Electrical Apparatus, 2003, 39(1): 7-15.
[3] 李金忠, 张乔根, 李原, 等. 直流电压下油纸绝缘杂质纤维小桥的形成过程[J]. 高电压技术, 2016, 42(12): 3901-3908.
Li Jinzhong, Zhang Qiaogen, Li Yuan, et al.Generation process of impurity bridges in oil-paper insulation under DC voltage[J]. High Voltage Engineering, 2016, 42(12): 3901-3908.
[4] Li Yuan, Zhang Qiaogen, Li Jinzhong, et al.Study on micro bridge impurities in oil-paper insulation at DC voltage: their generation, growth and interaction with partial discharge[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2016, 23(4): 2213-2222.
[5] Miyahara A Y H, Sampei H, Shirasaka Y, et al. Influence of micro particles in fluid on the impulse and AC breakdown strengths of low-viscosity silicone liquid immersed insulating systems[C]// International Conference on Electrical Engineering (ICEE), Okinawa, Japan, 2008: 1-4.
[6] CIGRE. Effect of particles on transformer dielectric strength[C]//WG 17/SC12, Canada, 2000: 1-30.
[7] 李智, 马强. 500kV变压器绝缘油的颗粒污染度监测[J]. 变压器, 1999, 36(9): 31.
Li Zhi, Ma Qiang.Monitoring the particle pollution degree of 500kV transformer's insulation oil[J]. Transformer, 1999, 36(9): 31.
[8] Shekhar Mahmud, George Chen.Experimental studies of influence of DC and AC electric fields on bridging in contaminated transformer oil[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2015, 22(1): 152-160.
[9] Shekhar Mahmud, George Chen.Bridging pheno- menon in contaminated transformer Oil[C]//2012 International Conference on Condition Monitoring and Diagnosis (CMD), Bali, 2012: 1-4.
[10] Shekhar Mahmud, George Chen.Experimental studies of influence of different Electrodes on bridging in contaminated transformer oil[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2015, 22(5): 2433-2441.
[11] 梁晨. 油中碳颗粒对绝缘油交直流复合电压下击穿特性的影响[J]. 高电压技术, 2017, 43(增刊): 121-126.
Liang Chen.Effect of carbon particles on breakdown strength of insulating oil under AC/DC composite voltage[J]. High Voltage Engineering, 2017, 43(S): 121-126.
[12] 赵涛, 律方成, 刘云鹏, 等. 纤维素颗粒物对变压器油冲击击穿特性影响的试验研究[J]. 电工技术学报, 2018, 33(7): 1626-1633.
Zhao Tao, Lü Fangcheng, Liu Yunpeng, et al.Experimental study of cellulose particles effect on impulse breakdown in transformer oil[J]. Transa- ctions of China Electrotechnical Society, 2018, 33(7): 1626-1633.
[13] 王淑娟, 时璟丽, 王景春, 等. 变压器油中大颗粒杂质对油局部放电的影响[J]. 高电压技术, 1994, 20(4): 26-29.
Wang Shujuan, Shi Jingli, Wang Jingchun, et al.The effect of macro-particle on the partial discharge pro- perty of transformer oil[J]. High Voltage Engineering, 1994, 20(4): 26-29.
[14] 王有元, 李熙, 李原龙, 等. 交直流复合电压下铜颗粒在油中的分布及对绝缘油击穿特性的影响[J]. 电工技术学报, 2018, 33(23): 5581-5590.
Wang Youyuan, Li Xi, Li Yuanlong, et al.Distri- bution of copper particle in insulating oil and its influence on breakdown strength of insulating oil under combined AC and DC voltage[J]. Transactions of China Electrotechnical Society, 2018, 33(23): 5581-5590.
[15] 付守海, 王淑娟, 王景春. 变压器油中导电颗粒运动轨迹的计算[J]. 现代电力, 1999, 16(2): 30-37.
Fu Shouhai, Wang Shujuan, Wang Jingchun.Calcu- lation of the motion trajectory of conductive particles in transformer oil[J]. Modern Electric Power, 1999, 16(2): 30-37.
[16] Wang Youyuan, Li Xi.Motion characteristic of copper particle in insulating oil under AC and DC voltages[C]//19th IEEE International Conference on Dielectric Liquids (ICDL), Manchester, United Kingdom, 2017: 1-4.
[17] 孙秋芹, 罗宸江, 王峰, 等. 直流GIL导体表面金属颗粒跳跃运动特性研究[J]. 电工技术学报, 2018, 33(22): 5206-5216.
Sun Qiuqin, Luo Chenjiang, Wang Feng, et al.Jumping characteristics of metal particle on the surface of DC gas insulated transmission line conductor[J]. Transactions of China Electrotechnical Society, 2018, 33(22): 5206-5216.
[18] Sarathi R, Archana M.Investigation of partial discharge activity by a conducting particle in transformer oil under harmonic AC voltages adopting UHF technique[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2012, 19(5): 1514-1520.
[19] 季洪鑫, 李成榕, 庞志开, 等. 电压波形对GIS自由金属颗粒放电特性的影响[J]. 电工技术学报, 2016, 31(13): 218-226.
Ji Hongxin, Li Chengrong, Pang Zhikai, et al.Influence of voltage waveforms on partial discharge characteristics of GIS mobilized metal particles[J]. Transactions of China Electrotechnical Society, 2016, 31(13): 218-226.
[20] Samuel Kotz, Campbell B Read, N Balakrishnan, et al. Encyclopedia of statistical sciences[M]. NewYork: John Wiley & Sons, Inc., 2015.
[21] Naciri N.Finite element analysis for power system component: dust accumulation in transformer oil[D]. Southampton: University of Southampton, 2011.
[22] 但敏, 郝建, 廖瑞金, 等. 直流电压下矿物油和天然酯中纤维颗粒运动及成桥特性的差异[J]. 电网技术, 2018, 42(2): 665-672.
Dan Min, Hao Jian, Liao Ruijin, et al.Different motion and bridging characteristics of fiber particles inmineral oil and natural ester under DC voltage[J]. Power System Technology, 2018, 42(2): 665-672.