|
|
|
| Electrode Polarization in Graphene Oxide/Epoxy Resins Nanocomposites |
| Zhang Hongliang1,2,3,4, Jin Hai1,3,4, Zhang Siyu2, Liu Peng2, Peng Zongren2 |
1. College of Electrical and Information Engineering Lanzhou University of Technology Lanzhou 730050 China;
2. State Key Laboratory of Electrical Insulation and Power Equipment Xi’an Jiaotong University Xi’an 710049 China;
3. Key Laboratory of Gansu Advanced Control for Industrial Processes Lanzhou 730050 China;
4. National Experimental Teaching Center of Electrical and Control Engineering Lanzhou University of Technology Lanzhou 730050 China |
|
|
|
|
Abstract In this paper, the samples of graphene oxide/epoxy resins nanocomposites (GO/EP) were prepared by the method of two-phase extraction. For comparison purposes, the samples of pure epoxy resins (EP) were also prepared. Microscopic observation of graphene oxide in epoxy matrix was carried out by different microscopes. The glass transition temperatures Tg and space charge distributions of GO/EP and EP were measured, and obvious heterocharge accumulations were observed in the GO/EP sample bulk once a DC electric field had just been applied. By comparing the broadband dielectric spectrum of GO/EP and EP samples, a dielectric relaxation phenomenon appeared only in the GO/EP samples at temperatures no more than Tg. The dielectric spectrum of GO/EP were fitted and analyzed by using the modified electrode polarization model, which results show that: The dielectric relaxations in the low frequency region were caused by the electrode polarization, which were mainly generated by the ion jump conductance; At temperatures no less than 80℃, the DC conductivity in epoxy matrix were significantly increased, and the conductivity type was ohmic conductance, which carriers were mainly originated from the electronic jump conductance.
|
|
Received: 14 December 2017
Published: 17 December 2018
|
|
|
|
|
|
[1] Bolon D.A. Epoxy chemistry for electrical insulation[J]. IEEE Electrical Insulation Magazine, 1995, 11(4): 10-18.
[2] 孙曼灵. 环氧树脂应用原理与技术[M]. 北京: 机械工业出版社, 2002.
[3] 俞翔霄, 俞赞琪, 陆惠英. 环氧树脂电绝缘材料[M]. 北京: 化学工业出版社, 2006.
[4] 赵玉顺, 张桦, 陈维江, 等. 雷电冲击电压下环氧树脂基频率选择超材料沿面放电特性[J]. 电工技术学报, 2017, 32(20): 10-19.
Zhao Yushun, Zhang Hua, Chen Weijiang, et al.Analysis of surface discharge characteristics of a frequency selective metamaterial based on epoxy resin under lightning pulse voltage[J]. Transactions of China Electrotechnical Society, 2017, 32(20): 10-19.
[5] 方雅琪, 王力农, 李姗姗, 等. 复合材料杆塔人工加速老化试验及其长期性能评估[J]. 电工技术学报, 2017, 32(19): 212-219.
Fang Yaqi, Wang Linong, Li Shanshan, et al.Artificial accelerated ageing test for composite material tower and its long-term performance evaluation[J]. Transactions of China Electrotechnical Society, 2017, 32(19): 212-219.
[6] 陈少卿, 彭宗仁, 王霞. 玻璃化温度对环氧树脂空间电荷分布的影响[J]. 电工技术学报, 2011, 26(8): 227-230.
Chen Shaoqing, Peng Zongren, Wang Xia.Effects of glass transition temperature on space charge in epoxy resin[J]. Transactions of China Electrotechnical Society, 2011, 26(8): 227-230.
[7] 王有元, 王施又, 陆国俊, 等. 纳米AlN改性对干式变压器环氧树脂绝缘性能的影响[J]. 电工技术学报, 2017, 32(7): 174-180.
Wang Youyuan, Wang Shiyou, Lu Guojun, et al.Influence of nano-AlN modification on the insulation properties of epoxy resin of dry-type transformers[J]. Transactions of China Electrotechnical Society, 2017, 32(7): 174-180.
[8] 龚瑾, 李喆, 刘新月. 氧化铝/环氧树脂复合材料空间电荷特性与高温高湿环境下交流电场老化[J]. 电工技术学报, 2016, 31(18): 191-198.
Gong Jin, Li Zhe, Liu Xinyue.Space charge and AC field aging in high hygrothermal environment of alumina/epoxy resin composites[J]. Transactions of China Electrotechnical Society, 2016, 31(18): 191-198.
[9] 王旗, 李喆, 尹毅, 等. 微/纳米氧化铝/环氧树脂复合材料抑制电树枝生长能力的研究[J]. 电工技术学报, 2015, 30(6): 255-260.
Wang Qi, Li Zhe, Yin Yi, et al.The effect of micro and nano alumina on the ability of impedance on the electrical tree of epoxy resin[J]. Transactions of China Electrotechnical Society, 2015, 30(6): 255-260.
[10] Huang Xingyi, Jiang Pingkai, Yin Yi.Nanoparticle surface modification induced space charge suppression in linear low density polyethylene[J]. Applied Physics Letters, 2009, 95(24): 242905.
[11] Ishimoto K, Kanegae E, Ohki Y, et al.Superiority of dielectric properties of LDPE/MgO nanocomposites over microcomposites[J]. IEEE Transactions on Dielectrics Electrical Insulation, 2009, 16(6): 1735-1742.
[12] 刘晨阳, 郑晓泉, 别成亮. 掺杂ZnO/环氧树脂基体的制备及其非线性电导改性研究[J] .电工技术学报, 2016, 31(12): 24-30.
Liu Chengyang, Zheng Xiaoquan, Bie Chengliang.Research of preparation and non-linear conductivity modification of doped ZnO/epoxide resin material[J]. Transactions of China Electrotechnical Society, 2016, 31(12): 24-30.
[13] 张明艳, 王晨, 吴淑龙, 等. 碳纳米管、蒙脱土共掺杂环氧树脂复合材料介电性能研究[J]. 电工技术学报, 2016, 31(10): 151-158.
Zhang Mingyan, Wang Chen, Wu Shulong, et al.Research on dielectric properties of epoxy resin composites doped with carbon nanotubes and montmorillonite[J]. Transactions of China Electrotechnical Society, 2016, 31(10): 151-158.
[14] 邓尧, 黄肖容, 邬晓龄. 氧化石墨烯复合材料的研究进展[J]. 材料导报, 2012, 26(8): 84-87.
Deng Yao, Huang Xiaorong, Wu Xiaoling.Review on graphene oxide composites[J]. Materials Review, 2012, 26(8): 84-87.
[15] Singh V, Joung D, Zhai Lei, et al.Graphene based materials: past, present and future[J]. Progress in Materials Science, 2011, 56(8): 1178-1271.
[16] Wang Zepu, Nelson J K, Hillborg H, et al.Nonlinear conductivity and dielectric response of graphene oxide filled silicone rubber nanocomposites[C]//2012 Annual Report Conference on Electrical Insulation and Dielectric Phenomena, Montreal, QC, Canada, 2012: 40-43.
[17] Wang Zepu, Nelson J K, Hillborg H, et al.Graphene oxide filled nanocomposite with novel electrical and dielectric properties[J]. Advanced Materials, 2012, 24(23): 3134-3137.
[18] Mancinelli P, Fabiani D, Saccani A, et al.Electrical AC and DC behavior of epoxy nanocomposites containing graphene oxide[J]. Journal of Applied Polymer Science, 2015, 132(18): 595-599.
[19] 李忠磊, 韩晨磊, 赵伟铭, 等. 基于等温表面电位衰减法的氧化石墨烯/低密度聚乙烯纳米复合材料陷阱分布特性[J]. 高电压技术, 2017, 43(11): 3583-3590.
Li Zhonglei, Han Chenlei, Zhao Weiming, et al.Characteristics of trap level distribution in graphene oxide/low density polyethylene nanocomposites based on the isothermal surface potential decay method[J]. High Voltage Engineering, 2017, 43(11): 3583-3590.
[20] Zhang Siyu, Zhang Hongliang, Feng Hua, et al.Relaxation processes and conduction mechanism of epoxy resin filled with graphene oxide[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2017, 24(1): 519-527.
[21] Kremer F, Schonhals A.Broadband dielectric spectroscopy[M]. Germany: Springer, 2003.
[22] Coelho R.Physics of dielectrics for the engineer[M]. Netherlands: Elsevier, 1979.
[23] Diaham S, Locatelli M L.Concentration and mobility of charge carriers in thin polymers at high temperature de-termined by electrode polarization modeling[J]. Journal of Applied Physics, 2012, 112(1): 013710.
[24] 陈季丹, 刘子玉. 电介质物理学[M]. 北京: 机械工业出版社, 1980.
[25] Tian Fuqiang, Ohki Y.Charge transport and electrode polarization in epoxy resin at high temperatures[J]. Journal of Physics D-Applied Physics, 2014, 47(4): 045311.
[26] 李方, 孟蝶. 氧化石墨烯: 膜科学的机遇与挑战[J]. 膜科学与技术, 2015, 35(6): 106-112.
Li Fang, Meng Die.Graphene oxide: the opportunity and challenge of membrane science[J]. Membrane Science and Technology, 2015, 35(6): 106-112.
[27] Takada T, Hayase Y, Tanaka Y, et al.Space charge trapping in electrical potential well caused by permanent and induced dipoles for LDPE/MgO nanocomposite[J]. IEEE Transactions on Dielectrics and Electrical Insulation, 2008, 15(1): 152-160. |
|
|
|
2018, Vol. 33 
