EAST快控电源中空心电抗器的电磁屏蔽计算

doi:10.19595/j.cnki.1000-6753.tces.L70363

Abstract
Figure/Table
References
Related Citation (13)

Download: PDF (1663 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract In experimental advanced superconducting Tokamak (EAST) power system, the magnetic field can cause interference of the magnetic field to the surrounding electronic equipment in operation of air core reactor. In this paper, the theoretical analysis of shielding magnetic field of metal mesh is presented. The expressions of shielding factor of single layer metal mesh and double layer metal mesh are obtained by analytical calculation. Based on the physical model, a number of 3D models are established. The metal mesh of different materials (DT4A, GO, 1008steel) is selected as a shield. Using three-dimensional finite element method and Matlab simulation and flux density distribution around the shield cabinet were obtained. Then, analysis of the shielding coefficient and the three influencing factors, three factors are number of mesh, excitation frequency and distance. The results show that the shielding effect of DT4A is best when the single metal mesh is shielded, and the shielding effect of DT4A/GO is best when the double metal mesh is shielded. Overall, the double layers are more effective than single layer shields. To further study the safety operation of the air core reactor is of great significance.

Key words： EAST fast control power supply air core reactor metal mesh shielding factor

Received: 19 August 2016 Published: 14 November 2017

PACS:

TM471

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Bao Xiaohua
	Hu Yunpeng
	Zhang Cheng
	Gao Ge

Cite this article:

Bao Xiaohua,Hu Yunpeng,Zhang Cheng等. Electromagnetic Shielding Calculation of Air Core Reactor in EAST Fast Control Power Supply[J]. Transactions of China Electrotechnical Society, 2017, 32(增刊2): 64-70.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.L70363 OR https://dgjsxb.ces-transaction.com/EN/Y2017/V32/I增刊2/64

[1] Huang Haihong, Wang Haixin, Gao Ge, et al. Application of phase-shift PWM in EAST fast control power supply[J]. IEEE Transactions on Applied Superconductivity, 2010, 20(3): 1671-1675.
[2] Sergeant P, Adriano U, Dupre L, et al. Active and passive magnetic shielding for stray field reduction of an induction heater with axial flux[J]. IEEE Transactions on Magnetics, 2004, 40(2): 675-678.
[3] Sergeant P, Dupre L, Melkebeek J. Active and passive magnetic shielding for stray field reduction of an induction heater with axial flux[J]. IEE Procee- dings of Electric Power Applications, 2005, 152(5): 1359-1364.
[4] 白保东, 王禹, 陈志雪, 等. 基于电磁屏蔽法变频电机轴承电流抑制研究[J]. 电工技术学报, 2010, 25(10): 33-39. Bai Baodong, Wang Yu, Chen Zhixue, et al. Inhibition of bearing currents in frequency variable motor based on electromagnetic shielding[J]. Transactions of China Electrotechnical Society, 2010, 25(10): 33-39.
[5] 焦重庆, 李顺杰. 导电板覆盖的开孔矩形腔体电磁屏蔽效能的比较研究[J]. 电工技术学报, 2016, 31(1): 112-118. Jiao Chongqing, Li Shunjie. Shielding effectiveness comparison of a rectangular box with an aperture covered by conductive sheet[J]. Transactions of China Electrotechnical Society, 2016, 31(1): 112-118.
[6] 杨添棋,苏东林,戴飞. 非平面态屏蔽金属网建模的等效算法研究[J]. 电子测量技术, 2008, 31(12): 31-35. Yang Tianqi, Su Donglin, Dai Fei. Research of equivalent algorithm of non-plane-shaped shielding metall ic mesh modeling[J]. Electronic Measurement Technology, 2008, 31(12): 31-35.
[7] Kim Sang-Beom, Soh Joon-Young, Shin Koo-Yong, et al. Magnetic shielding performance of thin metal sheets near power cables[J]. IEEE Transactions on Magnetics, 2010, 46(2): 682-685.
[8] Tashiro K, Sasada I. A low-cost magnetic shield consisting of nonoriented silicon steel[J]. IEEE Transactions on Magnetics, 2005, 41(10): 4081-4083.
[9] Daisuke Miyagi, Satoru Iwata, Norio Takahashi, et al. 3D FEM analysis of effect of current distribution on AC loss in shield layers of multi-layered HTS power cable[J]. IEEE Transactions on Applied Super- conductivity, 2007, 17(2): 1696-1699.
[10] Massarini A, Reggiani U, Sandrolini L. Optimization of magnetic multilayered shields[J]. IEEE International Symposium on Electromagnetic Compatibility, 2001, 1: 161-166.
[11] Zhou Xiangxian, Lu Tiebing, Cui Xiang, et al. Analysis of the shielding effect of wire mesh to ion flow field from HVDC transmission lines[J]. IEEE Transactions on Magnetics, 2014, 50(2): 4081-4083.
[12] 李永刚, 李悦宁, 程志光, 等. 电力变压器中不同磁屏蔽的建模、仿真和基准化实验验证[J]. 电工电能新技术, 2015, 34(2): 61-66. Li Yonggang, Li Yuening, Cheng Zhiguang, et al. Modeling,simulation and benchmarking validation of magnetic shields in large power transformers[J]. Advanced Technology of Electrical Engineering and Energy, 2015, 34(2): 61-66.
[13] 赵志刚, 赵新丽, 程志光, 等. HVDC中电力变压器直流偏磁屏蔽效应研究[J]. 电工技术学报, 2014, 29(7): 45-52. Zhao Zhigang, Zhao Xinli, Cheng Zhiguang, et al. Research on the shielding effects of power transformer under DC-biased condition in HVDC[J]. Transactions of China Electrotechnical Society, 2014, 29(7): 45-52.
[14] 汪泉弟, 张艳, 李永明, 等. 干式空心电抗器周围工频磁场分布[J]. 电工技术学报, 2009, 24(1): 8-13. Wang Quandi, Zhang Yan, Li Yongming, et al. The power frequency magnetic field distribution around dry-type air-core reactor[J]. Transactions of China Electrotechnical Society, 2009, 24(1): 8-13.
[15] 欧阳樟, 刘全峰, 梁艺超, 等. 干式空心电抗器工频磁场屏蔽方法的研究[J]. 电力电容器与无功补偿, 2013, 34(6): 66-79. Ouyang Zhang, Liu Quanfeng, Liang Yichao, et al. Study on power frequency magnetic field shielding method of dry air-core reactor[J]. Power Capacitor and Reactive Power Compensation, 2013, 34(6): 66-79.
[16] 李永明,徐禄文,俞集辉,等. 35kV干式空心电抗器下工频磁场抑制[J]. 高电压技术, 2010, 36(12): 2960-2965. Li Yongming, Xu Luwen, Yu Jihui, et al. Intensity control of power frequency magnetic field under 35kV dry-type air-core reactor[J]. High Voltage Engineering, 2010, 36(12): 2960-2965.