频变电应力下高频电力变压器绝缘沿面放电形态及发展过程

Abstract
Figure/Table
References
Related Citation (11)

Download: PDF (2952 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Surface discharge is one of the main causes of insulation failures.In order to investigate the patterns of surface discharge and its evolution process in high frequency power transformers,an experimental platform with high frequency voltage source was built.First,the surface discharge inception voltage,the flashover voltage,and the insulation life were tested under sinusoidal voltage of different frequencies from 10 kHz to 40 kHz.Then,with the constant sinusoidal voltage value,surface discharge tests were conducted to observe the entire evolution process of the surface discharge including its initiation,development,and the ultimate flashover,along with the characteristic parameters and phase resolved spectra at different discharging stages. At last,the evolution process was analyzed based on the secondary electron emission avalanche model and the trap theory.Experimental results and analyses indicate that:the surface flashover voltage and the insulation life will be decreased with the increase of the voltage frequency;the surface discharge of polyimide film approximately develops in a straight line under high frequency;the discharge amplitude,discharge number,phase resolved spectrum,and corresponding statistical parameters show specific variation trend at different evolutionary stages,which can utilized as the evaluation index of the development degree for surface discharge; the charge distribution and the trap parameters on the insulation surface are the key issues to reveal the inherent mechanism of surface flashover,since they have important effects on surface discharge characteristics.

Key words： High frequency power transformer high frequency sinusoidal voltage frequency-dependent electric stress surface discharge discharge pattern

Received: 12 July 2015 Published: 02 November 2016

PACS:

TM215

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Liu Tao
	Han Shuai
	Li Qingmin
	Lu Xu
	Huang Xuwei

Cite this article:

Liu Tao,Han Shuai,Li Qingmin等. Patterns and Development of the Surface Discharge of High Frequency Power Transformer Insulation Under Frequency-Dependent Electric Stress[J]. Transactions of China Electrotechnical Society, 2016, 31(19): 199-207.

URL:

https://dgjsxb.ces-transaction.com/EN/ OR https://dgjsxb.ces-transaction.com/EN/Y2016/V31/I19/199

[1] 毛承雄,范澍,王丹,等.电力电子变压器的理论及其应用(I)[J].高电压技术,2003,29(10):4-6.
Mao Chengxiong,Fan Shu,Wang Dan,et al.Theory of power electric transformer and its applications (I)[J].High Voltage Engineering,2003,29(10):4-6.
[2] 兰征,涂春鸣,肖凡,等.电力电子变压器对交直流混合微网功率控制的研究[J].电工技术学报,2015,30(23):50-57.
Lan Zheng,Tu Chunming,Xiao Fan,et al.The power control of power electronic transformers in hybrid AC-DC microgrid[J].Transactions of China Electrotechnical Society,2015,30(23):50-57.
[3] Qin H,Kimball J W.Solid-state transformer architecture using AC-AC dual-active-bridge converter[J].IEEE Transactions on Industrial Electronics,2013,60(9):3720-3730.
[4] Lothar H.An actively cooled high power,high frequency transformer with high insulation capability[C]//IEEE Applied Power Electronics Conference and Exposition,Dallas,TX,2002:352-357.
[5] 韩帅,李庆民,刘伟杰,等.温-频耦合效应对高频固态变压器绝缘局部放电特性的影响[J].电工技术学报,2015,30(2):204-210.
Han Shuai,Li Qingmin,Liu Weijie,et al.Impacts of coupled temperature-frequency effects on partial discharge characteristics of high frequency solid state transformer insulation[J].Transactions of China Electrotechnical Society,2015,30(2):204-210.
[6] 罗杨,吴广宁,刘继午,等.局部放电作用对变频电机匝间纳米复合绝缘的损伤机理研究[J].电工技术学报,2014,29(6):303-310.
Luo Yang,Wu Guangning,Liu Jiwu,et al.Study on PD damage mechanism of nano-composite used as turn insulation in inverter-fed traction motors[J].Transactions of China Electrotechnical Society,2014,29(6):303-310.
[7] 周利军,刘继午,刘洋,等.方波脉冲电压下温度对聚酰亚胺薄膜电气绝缘特性的影响[J].高电压技术,2015,41(2):396-402.
Zhou Lijun,Liu Jiwu,Liu Yang,et al.Effect of temperature on the electrical properties of polyimide films under square impulse voltage[J].High Voltage Engineering,2015,41(2):396-402.
[8] 孟晓波,梅红伟,陈昌龙,等.绝缘介质表面流注发展特性的机理研究[J].中国电机工程学报,2013,33(22):155-165.
Meng Xiaobo,Mei Hongwei,Chen Changlong,et al.Research on characteristics of streamer propagation along insulation surfaces[J].Proceedings of the CSEE,2013,33(22):155-165.
[9] Yi Xiao,Wang Zhongdong.The influence of solid surface on the propagation of creepage discharge in insulating liquids[J].IEEE Transactions on Dielectrics and Electrical Insulation,2015,22(1):303-312.
[10]王伟,薛阳,程养春,等.变压器油纸绝缘沿面放电程度的诊断[J].高电压技术,2011,37(7):1713-1718.
Wang Wei,Xue Yang,Cheng Yangchun,et al.Diagnosis of severity degree for power transformer oil-pressboard insulation surface discharge[J].High Voltage Engineering,2011,37(7):1713-1718.
[11]Zainuddin H,Mitchinson P M,Lewin P L.Investigation on the surface discharge phenomenon at the oil-pressboard interface[C]//IEEE International Conference on Dielectric Liquids (ICDL),Trondheim,2011:1-4.
[12]Mitchinson P M,Lewin P L,Strawbridge B D,et al.Tracking and surface discharge at the oil-pressboard interface[J].IEEE Electrical Insulation Magazine,2010,26(2):35-41.
[13]罗杨,吴广宁,刘继午,等.表面放电对聚酰亚胺薄膜材料的电气损伤特性研究[J].中国电机工程学报,2013,33(25):187-195.
Luo Yang,Wu Guangning,Liu Jiwu,et al.Electrical damage characteristics of polyimide film caused by surface discharge[J].Proceedings of the CSEE,2013,33(25):187-195.
[14]Chen Yu,Cheng Yonghong,Wu Kai,et al.Flashover characteristic of epoxy composites filled with different micro-inorganic oxide particles under nanosecond pulse in vacuum[J].IEEE Transactions on Plasma Science,2009,37(1):195-203.
[15]Tang Junping,Qiu Aici,Li Yang,et al.Process of surface flashover in vacuum under nanosecond pulse[J].IEEE Transactions on Plasma Science,2010,38(1):53-58.
[16]刘熊,林海丹,梁义明,等.空气中微秒脉冲沿面放电对环氧树脂表面特性影响研究[J].电工技术学报,2015,30(13):158-165.
Liu Xiong,Lin Haidan,Liang Yiming,et al.Effect of atmospheric-pressure microsecond pulsed discharges on epoxy resin surface[J].Transactions of China Electrotechnical Society,2015,30(13):158-165.
[17]Dervos C,Bourkas P D,Kayafas E A,et al.Enhanced partial discharges due to temperature increase in the combined system of a solid-liquid dielectric[J].IEEE Transactions on Electrical Insulation,1990,25(3):469-474.
[18]Yang Jiaxiang,Chi Xiaochun,Ding Lijian,et al.Creeping discharge performance of oil-paper insulation with streaming electrification[J].IEEE Transactions on Dielectrics and Electrical Insulation,1997,4(6):780-784.
[19]Mitchinson P M,Lewin P L,Chen G,et al.A new approach to the study of surface discharge on the oil-pressboard interface[C]//IEEE International Conference on Dielectric Liquids (ICDL),Chasseneuil,2008:1-4.
[20]Zainuddin H,Lewin P L,Mitchinson P M.Partial discharge characteristics of surface tracking on oil-impregnated pressboard under AC voltages[C]//IEEE International Conference on Solid Dielectrics (ICSD),Bologna,2013:1016-1019.
[21]周远翔,聂琼,邢晓亮,等.频率对高密度聚乙烯电树老化特性的影响[J].高电压技术,2008,34(2):220-224.
Zhou Yuanxiang,Nie Qiong,Xing Xiaoliang,et al.Effect of frequency on electrical treeing characteristics of high-density polyethylene[J].High Voltage Engineering,2008,34(2):220-224.
[22]孙志,王暄,韩柏,等.聚酰亚胺薄膜表面电荷的开尔文力显微镜研究[J].中国电机工程学报,2014,34(12):1957-1964.
Sun Zhi,Wang Xuan,Han Bai,et al.Research on surface charges of polyimide films by the Kelvin force microscope[J].Proceedings of the CSEE,2014,34(12):1957-1964.
[23]Gutfleisch F,Niemeyer L.Measurement and simulation of PD in epoxy voids[J].IEEE Transactions on Dielectrics and Electrical Insulation,1995,2(5):729-743.
[24]Niemeyer L.A generalized approach to partial discharge modeling[J].IEEE Transactions on Dielectrics and Electrical Insulation,1995,2(4):510-528.