|
|
|
| Push-Pull Forward Three-Level Converter with Reduced Rectifier Voltage Stress |
| Yao Zhilei1, 2, Xiao Lan1, Huang Yong1, Ding Lianfeng1 |
| 1. Nanjing University of Aeronautics and Astronautics Nanjing 210016 China 2. Yancheng Institute of Technology Yancheng 224051 China |
|
|
|
|
Abstract This paper presents a push-pull forward (PPF) three-level (TL) converter, which is suitable for low and wide-range input voltage applications, such as renewable energy resources. Half of the switches sustain half of the input voltage, and the others sustain one and one-half input voltage. However, voltage stress of the rectifier diode is high with the conventional TL control strategy, especially in high output-voltage condition, considering voltage spike across the rectifier diode caused by leakage inductance. When 1/2 level of the secondary rectified voltage shows first and 1 level of that appears later, the voltage stress across the rectifier diode can be reduced by paralleling with external capacitor. The operating principle and selection of the external capacitor are analyzed. Finally, experimental results of a 500 W PPF TL converter verify the theoretical analysis.
|
|
Received: 13 August 2009
Published: 20 March 2014
|
|
|
|
|
|
[1] Blaabjerg F, Iov F, Teodorescu R, et al. Power electronics in renewable energy systems[C]. Proceedings of the IEEE International Conference and Exhibition on Power Electronics and Motion Control, 2006: 1-17.
[2] Sharma R, Gao H W. Low cost high efficiency DC-DC converter for fuel cell powered auxiliary power unit of a heavy vehicle[J]. IEEE Transactions on Power Electronics, 2006, 21(3): 587-591.
[3] 王赞, 肖岚, 严仰光. 基于燃料电池的推挽正激变换器的控制研究[J]. 中国电机工程学报, 2007, 27(33): 82-86.
Wang Zan, Xiao Lan, Yan Yangguang. Research on control of fuel cell based push-pull forward converter[J]. Proceedings of the CSEE, 2007, 27(33): 82-86.
[4] Lai J S, Nelson D J. Energy management power converters in hybrid electric and fuel cell vehicles[J]. Proceedings of the IEEE, 2007, 95(4): 766-777.
[5] Todorovic M H, Palma L, Enjeti P N. Design of a wide input range DC-DC converter with a robust power control scheme suitable for fuel cell power conversion[J]. IEEE Transactions on Industrial Electronics, 2008, 55(2): 1247-1255.
[6] Masters G M. Renewable and efficient electric power systems[M]. New Jersey: Wiley-IEEE Press, 2004.
[7] Pinheiro J R, Barbi I. Wide load range three-level ZVS-PWM DC-to-DC converter[C]. Proceedings of the IEEE Power Electronics Specialist Conference, 1993: 171-177.
[8] Zhou X, Yang B, Amoroso L, et al. A novel high-input-voltage, high-efficiency and fast transient voltage regulator module: push-pull forward converter[C]. Proceedings of the IEEE Applied Power Electronics Conference, 1999: 279-283.
[9] Yao Zhilei, Xiao Lan, Yan Yangguang. A family of zero-voltage-switching DC-DC transformers[C]. Proceedings of the IEEE Applied Power Electronics Conference, 2006: 513-516.
[10] 陈志英, 阮新波. 零电压开关PWM复合式全桥三电平变换器[J]. 中国电机工程学报, 2004, 24(5): 24-29.
[11] Redl R, Balogh L, Edwards D W. Optimal ZVS full-bridge DC/DC converter with PWM phase-shift control: analysis, design considerations, and experimental results[C]. Proceedings of the IEEE Applied Power Electronics Conference, 1994: 159-165.
[12] 刘福鑫, 阮新波. 零电压开关PWM组合式三电平变换器的箝位策略[J]. 中国电机工程学报, 2006, 26(17): 44-50.
Liu Fuxin, Ruan Xinbo. Voltage clamping scheme for zero-voltage switching PWM combined three-level converter[J]. Proceedings of the CSEE, 2006, 26(17): 44-50.
[13] Zeghbroeck B V. Principles of semiconductor devices [M]. Boulder: Colorado University, 2001.
[14] Erickson R W, Maksimovic D. Fundamentals of power electronics [M]. 2nd ed. New York: Kluwer Academic Publishers, 2001. |
|
|
|
2012, Vol. 27 
