基于电流预测的永磁同步电机驱动系统逆变器开关管和电流传感器故障诊断

doi:10.19595/j.cnki.1000-6753.tces.251363

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (4991 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract In permanent magnet synchronous motor (PMSM) drive systems, inverter-switch faults and current-sensor faults are the most common electrical failures. These two fault types often exhibit similar current distortion characteristics, making them difficult to distinguish. This diagnostic challenge is particularly pronounced in cost-sensitive or fault-tolerant applications where only two phase-current sensors are available, as traditional methods typically rely on complete three-phase current information or require additional hardware. Existing methods that operate with a reduced sensor set often struggle to distinguish between the two fault types or fail to identify the fault's specific nature. Therefore, this paper proposes a novel fault diagnosis strategy based on current prediction using only two-phase current measurements.
Firstly, a robust current prediction model for normal operation is established by integrating a speed-adaptive extended state observer (SA-ESO) into a deadbeat predictive current control (DPCC) architecture, providing an accurate baseline for both motor control and fault detection. Secondly, a three-step diagnostic procedure is executed. Faults are initially detected by monitoring the time-integrated residual of the dq-axis currents, computed as the difference between the predicted and measured values from the normal model. To isolate the faulty component, two distinct sets of predictive models are developed. One for inverter-switch open-circuit faults based on motor physics under fault conditions, and another for current-sensor faults, which leverage the SA-ESO to reconstruct system states using only a single healthy current. The faulty component is identified by selecting the healthy-phase current that deviates least from the measured value. Finally, once the component is identified, the specific fault type (e.g., upper/lower switch fault, sensor open-circuit, gain/offset error) is determined by analyzing the characteristics of the faulty phase current signal. Techniques such as Recursive Least Squares (RLS) are used to estimate the parameters of gain and offset faults.
Experimental results on a PMSM test rig show the proposed method detects fault occurrence within 1~3 switching periods. Simpler faults, such as sensor open-circuits, are identified within 5 switching periods, whereas inverter open-circuit faults take up to 10 switching periods. Diagnosing sensor gain and offset errors requires approximately 1.5 ms to allow the RLS estimation algorithm to converge. To verify the robustness of the proposed model, the system was subjected to sudden changes in load torque and rapid speed variations, as well as significant parameter mismatches (+20% deviation in inductance, resistance, and flux linkage). The results show that the fault detection and isolation logic remains reliable and avoids false alarms. A comparison with other state-of-the-art methods shows that the proposed strategy enables high-speed diagnosis and distinguishes inverter open-circuit faults from multiple types of current sensor faults, while requiring only two current sensors.
The following conclusions can be drawn. (1) The proposed three-step diagnostic framework, which combines a normal operation model for detection with multiple dedicated fault models for isolation, proves to be an effective architecture for addressing the ambiguity between inverter and sensor faults in two-sensor systems. (2) The integration of the speed-adaptive extended state observer (SA-ESO) significantly enhances the robustness of the current prediction against system parameter variations and external disturbances, which is critical for preventing misdiagnosis during transient operating conditions. (3) The proposed model without additional hardware is practical for industrial applications, imposes a moderate computational load, and does not depend on large datasets for training.

Key words： Permanent magnet synchronous motor (PMSM) drive system predictive current control inverter switch current sensor fault diagnosis extended state observer single-phase current reconstruction

Received: 03 August 2025

PACS:

TM614

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Wu Haolong
	Wang Manyi
	Jiang Yilin
	Li Ming

Cite this article:

Wu Haolong,Wang Manyi,Jiang Yilin等. A Diagnosis Method for Inverter Switch and Current Sensor Faults in PMSM Drive System Based on Current Prediction[J]. Transactions of China Electrotechnical Society, 2026, 41(14): 4762-4775.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.251363 OR https://dgjsxb.ces-transaction.com/EN/Y2026/V41/I14/4762

[1] 石秦赓, 朱俊杰, 韩一, 等. 基于自适应滑模观测器的永磁同步电机负载转矩辨识[J]. 电工技术学报, 2025, 40(12): 3868-3882.
Shi Qingeng, Zhu Junjie, Han Yi, et al.Load torque identification of permanent magnet synchronous motor based on adaptive sliding mode observer[J]. Transactions of China Electrotechnical Society, 2025, 40(12): 3868-3882.
[2] Zhang Shiqi, Wang Rongjie, Si Yupeng, et al.An improved convolutional neural network for three-phase inverter fault diagnosis[J]. IEEE Transactions on Instrumentation and Measurement, 2022, 71: 3510915.
[3] 陈超波, 代佳伟, 孙天誉, 等. 面向残差评价的中点钳位型逆变器开路故障诊断方法[J]. 电工技术学报, 2024, 39(21): 6877-6895.
Chen Chaobo, Dai Jiawei, Sun Tianyu, et al.NPC type inverter open circuit fault diagnosis method based on residual performance evaluation[J]. Transac-tions of China Electrotechnical Society, 2024, 39(21): 6877-6895.
[4] 孙德博, 胡艳芳, 牛峰, 等. 开关磁阻电机调速系统故障诊断和容错控制方法研究现状及展望[J]. 电工技术学报, 2022, 37(9): 2211-2229.
Sun Debo, Hu Yanfang, Niu Feng, et al.Status and prospect of fault diagnosis and tolerant control methods for switched reluctance motor drive system[J]. Transactions of China Electrotechnical Society, 2022, 37(9): 2211-2229.
[5] Farhadi M, Fard M T, Abapour M, et al.DC-AC converter-fed induction motor drive with fault-tolerant capability under open-and short-circuit switch failures[J]. IEEE Transactions on Power Electronics, 2018, 33(2): 1609-1621.
[6] Chen Mingyun, He Yigang.Open-circuit fault diagnosis method in NPC rectifiers using fault-assumed strategy[J]. IEEE Transactions on Power Electronics, 2022, 37(11): 13668-13683.
[7] 李兵, 崔介兵, 何怡刚, 等. 基于能量谱熵及小波神经网络的有源中性点钳位三电平逆变器故障诊断[J]. 电工技术学报, 2020, 35(10): 2216-2225.
Li Bing, Cui Jiebing, He Yigang, et al.Fault diagnosis of active neutral point clamped three-level inverter based on energy spectrum entropy and wavelet neural network[J]. Transactions of China Electrotechnical Society, 2020, 35(10): 2216-2225.
[8] 陈超波, 王霞霞, 高嵩, 等. 基于区间滑模观测器的逆变器开路故障诊断方法[J]. 中国电机工程学报, 2020, 40(14): 4569-4579, 4736.
Chen Chaobo, Wang Xiaxia, Gao Song, et al.A diagnosis method for open-circuit faults in inverters based on interval sliding mode observer[J]. Proceedings of the CSEE, 2020, 40(14): 4569-4579, 4736.
[9] Wu Chunya, Guo Chuangqiang, Xie Zongwu, et al.A signal-based fault detection and tolerance control method of current sensor for PMSM drive[J]. IEEE Transactions on Industrial Electronics, 2018, 65(12): 9646-9657.
[10] Ma Guangtong, Zhang Han, Sun Zhenyao, et al.Current sensor fault localization and identification of PMSM drives using difference operator[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2023, 11(1): 1097-1110.
[11] Wu Sijia, Ma Guangtong, Yao Chunxing, et al.Current sensor fault detection and identification for PMSM drives using multichannel global maximum pooling CNN[J]. IEEE Transactions on Power Electronics, 2024, 39(8): 10311-10325.
[12] Ben Youssef A, El Khil S K, Slama-Belkhodja I. State observer-based sensor fault detection and isolation, and fault tolerant control of a single-phase PWM rectifier for electric railway traction[J]. IEEE Transactions on Power Electronics, 2013, 28(12): 5842-5853.
[13] Foo G H B, Zhang Xinan, Vilathgamuwa D M. A sensor fault detection and isolation method in interior permanent-magnet synchronous motor drives based on an extended Kalman filter[J]. IEEE Transactions on Industrial Electronics, 2013, 60(8): 3485-3495.
[14] Xia Jinhui, Guo Yuanbo, Dai Bijun, et al.Sensor fault diagnosis and system reconfiguration approach for an electric traction PWM rectifier based on sliding mode observer[J]. IEEE Transactions on Industry Appli-cations, 2017, 53(5): 4768-4778.
[15] Jlassi I, Cardoso A J M. A single method for multiple IGBT, current, and speed sensor faults diagnosis in regenerative PMSM drives[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2020, 8(3): 2583-2599.
[16] Jlassi I, Estima J O, El Khil S K, et al. A robust observer-based method for IGBTs and current sensors fault diagnosis in voltage-source inverters of PMSM drives[J]. IEEE Transactions on Industry Applications, 2017, 53(3): 2894-2905.
[17] Khojet El Khil S, Jlassi I, Marques Cardoso A J, et al. Diagnosis of open-switch and current sensor faults in PMSM drives through stator current analysis[J]. IEEE Transactions on Industry Applications, 2019, 55(6): 5925-5937.
[18] Lu Falong, Guo Qiang, Dou Zhifeng, et al.A novel simultaneous diagnosis method for IGBT open-circuit faults and current sensor faults of three-phase SPWM inverter[J]. IEEE Transactions on Power Electronics, 2025, 40(8): 11369-11379.
[19] 许水清, 黄文展, 何怡刚, 等. 基于自适应滑模观测器的中点钳位型三电平并网逆变器开路故障诊断[J]. 电工技术学报, 2023, 38(4): 1010-1022.
Xu Shuiqing, Huang Wenzhan, He Yigang, et al.Open-circuit fault diagnosis method of neutral point clamped three-level grid-connected inverter based on adaptive sliding mode observer[J]. Transactions of China Electrotechnical Society, 2023, 38(4): 1010-1022.
[20] Xu Shuiqing, Yu Hongyan, Wang Hai, et al.Simultaneous diagnosis of open-switch and current sensor faults of inverters in IM drives through reduced-order interval observer[J]. IEEE Transactions on Industrial Electronics, 2025, 72(6): 6485-6496.
[21] Li Zhan, Wheeler P, Watson A, et al.A fast diagnosis method for both IGBT faults and current sensor faults in grid-tied three-phase inverters with two current sensors[J]. IEEE Transactions on Power Electronics, 2020, 35(5): 5267-5278.
[22] 王宇, 张成糕, 郝雯娟. 永磁电机及其驱动系统容错技术综述[J]. 中国电机工程学报, 2022, 42(1): 351-371.
Wang Yu, Zhang Chenggao, Hao Wenjuan.Overview of fault-tolerant technologies of permanent magnet brushless machine and its control system[J]. Pro-ceedings of the CSEE, 2022, 42(1): 351-371.
[23] Zhang Yun, Mao Yao, Wang Xueqing, et al.Current prediction-based fast diagnosis of electrical faults in PMSM drives[J]. IEEE Transactions on Trans-portation Electrification, 2022, 8(4): 4622-4632.
[24] Yu Yong, Zhao Yongzheng, Wang Bo, et al.Current sensor fault diagnosis and tolerant control for VSI-based induction motor drives[J]. IEEE Transac-tions on Power Electronics, 2018, 33(5): 4238-4248.
[25] Wang Gaolin, Hao Xiaofei, Zhao Nannan, et al.Current sensor fault-tolerant control strategy for encoderless PMSM drives based on single sliding mode observer[J]. IEEE Transactions on Trans-portation Electrification, 2020, 6(2): 679-689.
[26] 周正, 李健, 卢阳, 等. 大功率感应牵引电机的高动态响应无差拍控制技术研究[J]. 电工技术学报, 2025, 40(16): 5283-5293.
Zhou Zheng, Li Jian, Lu Yang, et al.Research on deadbeat control technology with high dynamic performance for high-power induction motors[J]. Transactions of China Electrotechnical Society, 2025, 40(16): 5283-5293.
[27] 张懿, 徐斌, 魏海峰, 等. 新型模型参考自适应的PMSM无差拍电流预测控制[J]. 电机与控制学报, 2023, 27(9): 157-167.
Zhang Yi, Xu Bin, Wei Haifeng, et al.New model reference adaptive deadbeat predictive current control of PMSM[J]. Electric Machines and Control, 2023, 27(9): 157-167.
[28] 朱玉璞, 杨淑英, 王奇帅. 基于延迟校正扩张状态观测器的内置式永磁同步电机电流控制策略[J]. 电工技术学报, 2024, 39(6): 1698-1712.
Zhu Yupu, Yang Shuying, Wang Qishuai.Current control strategy of interior permanent magnet synchronous motor based on delay corrected extended state observers[J]. Transactions of China Electro-technical Society, 2024, 39(6): 1698-1712.
[29] Zuo Ying, Lai Chunyan, Galkina A, et al.Adaptive current observer design for single current sensor control in PMSM drives[J]. IEEE Transactions on Transportation Electrification, 2024, 10(3): 6928-6939.
[30] Eull M, Mohamadian M, Luedtke D, et al.A current observer to reduce the sensor count in three-phase PM synchronous machine drives[J]. IEEE Transactions on Industry Applications, 2019, 55(5): 4780-4789.