基于扰动模型前馈与扩张状态观测合补偿的直线电机推力波动抑制策略

doi:10.19595/j.cnki.1000-6753.tces.250792

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (4621 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract An AC permanent-magnet synchronous linear motor (PMLSM) offers high response speed and control accuracy and is widely used in high-precision manufacturing applications. However, due to its unique physical structure, PMLSM is inevitably affected by thrust fluctuations, including detent and friction forces during movement, which deteriorate the motor’s control performance. To address thrust fluctuation problems in high-precision PMLSM, a composite compensation strategy is designed that combines disturbance model feedforward (DMF) and a linear extended state observer (LESO).
Firstly, based on the physical structure and magnetic field distribution of the PMLSM, the force of the motor mover during motion, along with its position and frequency characteristics of thrust fluctuation, are analyzed. It is found that a high-frequency component of thrust fluctuation occurs at high speed and high dynamic response, leading to an increase in servo error. Therefore, a thrust-fluctuation composite compensation strategy is proposed. Secondly, a neural network is used to model the detent force in the position domain, a piecewise linear friction model is used to model the friction force in the velocity domain, and the residual disturbance after modeling is further estimated and compensated by LESO. In addition, to enhance the tracking performance of the instructions, a two-degree-of-freedom control structure combining differential feedforward and PI control is adopted. Considering the real-time requirement of the servo system, the computational amount of the proposed thrust fluctuation composite compensation strategy is also analyzed.
Finally, the effectiveness of the proposed strategy is evaluated through position and velocity-servo experiments on a PMLSM prototype platform. Trapezoidal-wave-position servo experiments verify the proposed strategy for thrust fluctuation suppression. Additionally, experiments conducted at different speeds confirm that the proposed strategy suppresses thrust fluctuations across the full frequency range. Furthermore, sinusoidal position experiments show that the proposed control strategy provides adequate thrust fluctuation compensation in both steady-state and dynamic conditions, improving the servo performance of the PMLSM system and meeting the real-time computing requirement. The suppression rate of thrust fluctuations reaches 87.39%, with a steady-state position control accuracy of 2.72 μm and a speed control accuracy of 4.46 mm/min at 4 m/min. In addition, the strategy is robust to the mass change in the motor mover.

Key words： Permanent magnet linear synchronous motor thrust fluctuation neural network modeling extended state observer

Received: 13 May 2025

PACS:

TM341

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Li Yesong
	Lu Yuqing

Cite this article:

Li Yesong,Lu Yuqing. Disturbance Model Feedforward and Extended State Observer Based Composite Compensation Strategy for Thrust Fluctuation Suppression in Linear Motor[J]. Transactions of China Electrotechnical Society, 2026, 41(8): 2590-2600.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.250792 OR https://dgjsxb.ces-transaction.com/EN/Y2026/V41/I8/2590

[1] 卢琴芬, 沈燚明, 叶云岳. 永磁直线电动机结构及研究发展综述[J]. 中国电机工程学报, 2019, 39(9): 2575-2588.
Lu Qinfen, Shen Yiming, Ye Yunyue.Development of permanent magnet linear synchronous motors structure and research[J]. Proceedings of the CSEE, 2019, 39(9): 2575-2588.
[2] 冀相, 许金, 黄垂兵, 等. 永磁直线同步电机推力脉动削弱方法综述[J]. 电机与控制应用, 2019, 46(1): 70-74.
Ji Xiang, Xu Jin, Huang Chuibing, et al.Review of methods for reducing thrust ripple of permanent magnet linear synchronous motor[J]. Electric Machines & Control Application, 2019, 46(1): 70-74.
[3] Boff B H B, Eckert P R, Amara Y. A comprehensive review on the end effects of linear permanent magnet machines[J]. IEEE Transactions on Industry Appli-cations, 2023, 59(2): 1728-1741.
[4] 司纪凯, 王海星, 许孝卓, 等. 永磁直线同步电机建模、特性分析及推力控制[M]. 徐州: 中国矿业大学出版社, 2014.
[5] Wang Xuezhen, Chen Feixue, Zhu Renfeng, et al.A review on disturbance analysis and suppression for permanent magnet linear synchronous motor[J]. Actuators, 2021, 10(4): 77.
[6] 韩雪岩, 刘景铭, 朱龙飞. 永磁直线电机端部力抑制措施[J]. 电机与控制学报, 2023, 27(8): 54-63.
Han Xueyan, Liu Jingming, Zhu Longfei.Measures of reducing detent force and design of linear motor[J]. Electric Machines and Control, 2023, 27(8): 54-63.
[7] 杨科科, 任宁宁, 李长乐, 等. 基于辅助铁心的永磁直线同步电机边端力最小化[J]. 电机与控制应用, 2022, 49(8): 47-52.
Yang Keke, Ren Ningning, Li Changle, et al.End force minimization of permanent magnet linear synchronous motor based on auxiliary iron core[J]. Electric Machines & Control Application, 2022, 49(8): 47-52.
[8] Xu Xiaozhuo, Du Han, Du Baoyu, et al.Topology optimization with hybrid algorithm in end teeth of PMLSM[C]//2021 13th International Symposium on Linear Drives for Industry Applications, Wuhan, China, 2021: 1-5.
[9] Ma Mingna, Li Liyi, He Zhu, et al.Influence of longitudinal end-effects on electromagnetic perfor-mance of a permanent magnet slotless linear launcher[J]. IEEE Transactions on Plasma Science, 2013, 41(5): 1161-1166.
[10] 兰志勇, 谢斌, 祝涤非, 等. 基于Ⅴ型三段磁极错位削弱永磁直线电机推力波动的方法[J]. 电工技术学报, 2021, 36(16): 3474-3482.
Lan Zhiyong, Xie Bin, Zhu Difei, et al.Method for weakening thrust fluctuation of permanent magnet linear motor based on Ⅴ-shaped three-stage mag-netic pole misalignment[J]. Transactions of China Electrotechnical Society, 2021, 36(16): 3474-3482.
[11] Lu Shaowu, Tang Xiaoqi, Song Bao, et al.Identi-fication and compensation of force ripple in PMSLM using a JITL technique[J]. Asian Journal of Control, 2015, 17(5): 1559-1568.
[12] Bascetta L, Rocco P, Magnani G.Force ripple compensation in linear motors based on closed-loop position-dependent identification[J]. ASME Transa-ctions on Mechatronics, 2010, 15(3): 349-359.
[13] 仵岳. 基于机理-数据混合模型的直线电机推力波动抑制方法[D]. 沈阳: 沈阳工业大学, 2024.
Wu Yue.Thrust fluctuation suppression method of linear motor based on mechanism-empirical hybrid model[D]. Shenyang: Shenyang University of Tech-nology, 2024.
[14] Song Fazhi, Liu Yang, Xu Jianxin, et al.Iterative learning identification and compensation of space-periodic disturbance in PMLSM systems with time delay[J]. IEEE Transactions on Industrial Electronics, 2018, 65(9): 7579-7589.
[15] Wang Mingyi, Li Liyi, Pan Donghua, et al.High-bandwidth and strong robust current regulation for PMLSM drives considering thrust ripple[J]. IEEE Transactions on Power Electronics, 2016, 31(9): 6646-6657.
[16] Liu Yudong, Wang Mingyi, Zeng G, et al.An improved method for force ripple compensation of PMLSM based on an incremental Kalman filter[C]//2021 13th International Symposium on Linear Drives for Industry Applications, Wuhan, China, 2021: 1-4.
[17] Yang Rui, Wang Mingyi, Li Liyi, et al.Integrated uncertainty/disturbance compensation with second-order sliding-mode observer for PMLSM-driven motion stage[J]. IEEE Transactions on Power Elec-tronics, 2019, 34(3): 2597-2607.
[18] 张国强, 赵新茹, 张恒, 等. 基于比例谐振内模扩张状态观测器的PMLSM推力波动抑制策略[J]. 电工技术学报, 2024, 39(8): 2449-2458.
Zhang Guoqiang, Zhao Xinru, Zhang Heng, et al.Proportional resonant internal model extended state observer based thrust ripple suppression strategy of PMLSM drives[J]. Transactions of China Electro-technical Society, 2024, 39(8): 2449-2458.
[19] 杨依林, 余海涛, 车志远. 基于MPC的永磁同步直线电机位置控制[J]. 微电机, 2021, 54(8): 57-61.
Yang Yilin, Yu Haitao, Che Zhiyuan.Position control of PMLSM based on model predictive control[J]. Micromotors, 2021, 54(8): 57-61.
[20] 李争, 安金峰, 肖宇, 等. 基于自适应观测器的永磁同步直线电机模型预测控制系统设计[J]. 电工技术学报, 2021, 36(6): 1190-1200.
Li Zheng, An Jinfeng, Xiao Yu, et al.Design of model predictive control system for permanent magnet synchronous linear motor based on adaptive observer[J]. Transactions of China Electrotechnical Society, 2021, 36(6): 1190-1200.
[21] 隋延飞, 李旭, 李星占, 等. 基于模糊自抗扰的精密直线电机运动控制[J]. 电机与控制应用, 2020, 47(6): 6-11.
Sui Yanfei, Li Xu, Li Xingzhan, et al.Precise linear motor motion control based on fuzzy ADRC[J]. Electric Machines & Control Application, 2020, 47(6): 6-11.
[22] Shao Ke, Zheng Jinchuan, Wang Hai, et al.Tracking control of a linear motor positioner based on barrier function adaptive sliding mode[J]. IEEE Transactions on Industrial Informatics, 2021, 17(11): 7479-7488.
[23] 赵鑫宇, 王丽梅. 永磁直线同步电机自适应分数阶终端滑模控制[J]. 电工技术学报, 2023, 38(20): 5434-5443.
Zhao Xinyu, Wang Limei.Adaptive fractional-order terminal sliding mode control for permanent magnet linear synchronous motor[J]. Transactions of China Electrotechnical Society, 2023, 38(20): 5434-5443.
[24] 方馨, 王丽梅, 张康. 基于扰动观测器的永磁直线电机高阶非奇异快速终端滑模控制[J]. 电工技术学报, 2023, 38(2): 409-421.
Fang Xin, Wang Limei, Zhang Kang.High order nonsingular fast terminal sliding mode control of permanent magnet linear motor based on disturbance observer[J]. Transactions of China Electrotechnical Society, 2023, 38(2): 409-421.
[25] Wang Pan, Xu Yunlang, Ding Runze, et al.Multi-kernel neural network sliding mode control for permanent magnet linear synchronous motors[J]. IEEE Access, 2021, 9: 57385-57392.
[26] 鲍明堃, 周扬忠. 基于复合神经网络重构对象的永磁同步直线电机变参数型位移速度并行控制[J]. 电工技术学报, 2024, 39(8): 2470-2484.
Bao Mingkun, Zhou Yangzhong.Parallel displacement velocity control of permanent magnet synchronous linear motor with variable parameters based on composite neural network reconstruction object[J]. Transactions of China Electrotechnical Society, 2024, 39(8): 2470-2484.
[27] 宋琳, 聂子玲, 孙军, 等. 基于参数辨识的永磁同步直线电机循环神经网络多维观测器[J]. 电工技术学报, 2024, 39(22): 7059-7072.
Song Lin, Nie Ziling, Sun Jun, et al.Multidimensional observer of permanent magnet synchronous linear motor recurrent neural network based on parameter identification[J]. Transactions of China Electro-technical Society, 2024, 39(22): 7059-7072.
[28] 韩京清. 自抗扰控制技术: 估计补偿不确定因素的控制技术[M]. 北京: 国防工业出版社, 2008.