具有短路容错能力的五电平主动电磁轴承开关功率放大器

doi:10.19595/j.cnki.1000-6753.tces.250234

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (7100 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract The power amplifier constitutes the critical actuating element in active magnetic bearings (AMBs). While elevating input voltage enhances dynamic response characteristics, this approach introduces significant operational challenges. High-voltage operation induces excessive voltage stress on power switching devices, escalates switching losses, and generates substantial electromagnetic interference (EMI) during circuit operation. A fundamental constraint of conventional three-level configurations is their fixed input voltage maintenance, regardless of tracking error magnitude, which leads to aggravated circuit stress conditions. Furthermore, the power switching devices exhibit particular vulnerability under combined high-voltage, high-current, and high-frequency switching conditions, potentially compromising AMBs' operational safety. Switching device failures generally manifest as either open-circuit or short-circuit modes. Compared to open-circuit failures, short-circuit faults present more severe consequences. Effective fault-tolerant strategies must therefore integrate rapid detection mechanisms with responsive protection measures to mitigate overcurrent risks in load coils during short-circuit events.
Firstly, this paper introduces the operational principle of a five-level power amplifier topology, guided by the design philosophy of “high voltage for large errors, low voltage for small errors”. The analysis demonstrates that under high dynamic response requirements, the five-level switching power amplifier circuit operates at a high voltage level while maintaining dynamic response capabilities equivalent to those of three-level ones. Conversely, under low dynamic response requirements, the five-level switching power amplifier circuit switches to a low-voltage level, where its input voltage is reduced to half that of conventional amplifiers. This voltage reduction halves the voltage stress on power electronic devices. Accordingly, voltage breakdown risks are mitigated, and the switching loss and electromagnetic noise in the circuit are reduced. Furthermore, a control strategy is presented for five-level operation, defining three distinct operational modes: low-voltage, transitional, and high-voltage. Through analytical derivation, we establish the critical current frequency governing inter-mode transitions and map the operating modes of five-level switching amplifiers across different AMBs speed ranges.
This paper then presents a fault-tolerant strategy for switch device short-circuit conditions in respective bridge arms of a five-level switching power amplifier topology. Furthermore, a diagnostic method is proposed through real-time monitoring of current flow in bridge arm freewheeling diodes and verification against predefined logical relationships with switching states. The implemented fault-tolerant strategy allows for a seamless transition between normal and fault-tolerant operation modes through controller parameter adjustments, completing mode switching within a single switching cycle.
Finally, the experimental results verify that the five-level switching power amplifier successfully tracks reference currents at different frequencies and maintains preset operational states. Compared with three-level switching power amplifiers, the five-level configuration demonstrates superior operational performance. When short-circuit faults occur in switching devices, the five-level switching power amplifier rapidly transitions to fault-tolerant states while maintaining continuous operation.

Key words： Active magnetic bearings switching power amplifier short-circuit fault fault-tolerant control

Received: 17 February 2025

PACS:	TH133.3
	TH113.1

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Liu Ziyi
	Li Wengheng
	Zhu Changsheng

Cite this article:

Liu Ziyi,Li Wengheng,Zhu Changsheng. Five-Level Switching Power Amplifier for Active Magnetic Bearings with Short-Circuit Fault-Tolerance[J]. Transactions of China Electrotechnical Society, 2026, 41(4): 1195-1209.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.250234 OR https://dgjsxb.ces-transaction.com/EN/Y2026/V41/I4/1195

[1] 李翁衡, 祝长生. 主动电磁轴承-柔性转子系统振动位移的高精度跟踪和估计方法[J]. 电工技术学报, 2023, 38(12): 3151-3164.
Li Wengheng, Zhu Changsheng.High precision tracking and estimation method for vibration dis- placement of active magnetic bearings-flexible rotor system[J]. Transactions of China Electrotechnical Society, 2023, 38(12): 3151-3164.
[2] 戈宝军, 杨子豪, 陶大军, 等. 计及磁路分布特性的电磁轴承解析模型建立与支撑性能影响因素研究[J]. 电工技术学报, 2023, 38(8): 2025-2035, 2085.
Ge Baojun, Yang Zihao, Tao Dajun, et al.Establish- ment of analytical model of active magnetic bearing considering magnetic circuit distribution characteri- stics and study on influencing factors of support performance[J]. Transactions of China Electrotech- nical Society, 2023, 38(8): 2025-2035, 2085.
[3] 李诗文, 邓智泉, 曹鑫, 等. 一种改进的磁悬浮轴承开关功率放大器数字单周期控制[J]. 电工技术学报, 2020, 35(2): 274-283.
Li Shiwen, Deng Zhiquan, Cao Xin, et al.An improved digital one-cycle control algorithm for switching power amplifier in magnetic bearings[J]. Transactions of China Electrotechnical Society, 2020, 35(2): 274-283.
[4] Kamath K P, Vijay G S, Bekinal S I, et al.Power amplifiers and their feedback mechanisms for AMB: a comprehensive review[J]. IEEE Access, 2023, 11: 132893-132915.
[5] 周小康, 马奎, 梁蓓. IGBT模块失效机理和主动热控制综述[J]. 电子技术应用, 2020, 46(2): 18-23.
Zhou Xiaokang, Ma Kui, Liang Bei.Summary of IGBT module failure mechanism and active thermal control[J]. Application of Electronic Technique, 2020, 46(2): 18-23.
[6] 李志刚, 梅霜, 王少杰, 等. IGBT模块开关损耗计算方法综述[J]. 电子技术应用, 2016, 42(1): 10-14, 18.
Li Zhigang, Mei Shuang, Wang Shaojie, et al.The review of IGBT module switching loss calculation method[J]. Application of Electronic Technique, 2016, 42(1): 10-14, 18.
[7] Hu Anliang, Biela J.Fast and accurate data sheet based analytical switching loss model for a SiC MOSFET and Schottky diode half-bridge[J]. IEEE Open Journal of Power Electronics, 2024, 5: 1684-1696.
[8] Geramirad H, Morel F, Dworakowski P, et al.Conducted EMI reduction in a 100kW 1.2kV dual active bridge converter[C]//PCIM Europe Digital Days 2020; International Exhibition and Conference for Power Electronics, Intelligent Motion, Renewable Energy and Energy Management, Germany, 2020: 1-8.
[9] Geramirad H, Morel F, Dworakowski P, et al.Experimental EMI study of a 3-phase 100kW 1200V dual active bridge converter using SiC MOSFETs[C]// 2020 22nd European Conference on Power Elec- tronics and Applications (EPE'20 ECCE Europe), Lyon, France, 2020: 1-10.
[10] Kumar S, Voruganti S K, Akin B, et al.Common- mode current analysis and cancellation technique for dual active bridge converter based DC system[J]. IEEE Transactions on Industry Applications, 2022, 58(4): 4955-4966.
[11] Zhao Shuang, Zhang Man, Zhang Zheng, et al.Analytic model of the voltage oscillation in a high- power converter with silicon carbide devices[J]. IEEE Transactions on Industry Applications, 2024, 60(2): 3345-3358.
[12] Li Jiawen, Yang Xin, Xu Mengwei, et al.Investi- gation on optimal switching oscillation suppression for SiC MOSFET by inductively coupled damping[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2023, 11(1): 667-678.
[13] 任鹏, 涂春鸣, 侯玉超, 等. 基于Si和SiC器件的混合型级联多电平变换器及其调控优化方法[J]. 电工技术学报, 2023, 38(18): 5017-5028.
Ren Peng, Tu Chunming, Hou Yuchao, et al.Research on a hybrid cascaded multilevel converter based on Si and SiC device and its control optimization method[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 5017-5028.
[14] 向超群, 杜京润, Zhang Xinan, 等. 电容电压平衡的四电平有源中性点钳位逆变器的改进模型预测电流控制[J]. 电工技术学报, 2024, 39(18): 5826-5838.
Xiang Chaoqun, Du Jingrun, Zhang Xinan, et al.An improved model predictive control of four-level active neutral point clamped inverter with balanced capacitor voltage[J]. Transactions of China Electro- technical Society, 2024, 39(18): 5826-5838.
[15] 叶满园, 喻生铭, 刘文芳, 等. 不对称级联九电平逆变器线性功率均衡控制策略[J]. 电工技术学报, 2024, 39(14): 4495-4507.
Ye Manyuan, Yu Shengming, Liu Wenfang, et al.Linear power balance strategy for asymmetric cascaded H-bridge nine-level inverter[J]. Transa- ctions of China Electrotechnical Society, 2024, 39(14): 4495-4507.
[16] Yang Jichang, Jiang Dong, Sun Hongbo, et al.A series-winding topology converter with capability of fault-tolerant operation for active magnetic bearing drive[J]. IEEE Transactions on Industrial Electronics, 2022, 69(7): 6678-6687.
[17] Ding Jianfu, Sun Hongbo, Jiang Dong, et al.Open- circuit fault-tolerant control and topology switching strategy of active magnetic bearing power electronics controller[J]. IEEE Transactions on Power Electronics, 2022, 37(9): 10928-10938.
[18] Jiang Dong, Ding Jianfu, Hu Feng, et al.Open-circuit fault-tolerant control strategy of five-leg drive in active magnetic bearing[J]. IEEE Transactions on Industry Applications, 2023, 59(6): 7545-7554.
[19] 刘程子, 奚志胜, 杨艳, 等. 一种应用于磁悬浮轴承的具有容错功能的多桥臂开关功放电路[J]. 中国电机工程学报, 2023, 43(17): 6828-6840.
Liu Chengzi, Xi Zhisheng, Yang Yan, et al.Utility model relates to a fault-tolerant multi-leg switch power amplifier circuit applied to magnetic bearing[J]. Proceedings of the CSEE, 2023, 43(17): 6828-6840.
[20] Shuai Yixuan, Jiang Dong, Hu Feng, et al.General switch short-circuit fault-tolerant strategy of active magnetic bearing power electronics drive[J]. IEEE Transactions on Power Electronics, 2023, 38(11): 14504-14515.
[21] 刘程子, 贾丽焱, 杨艳, 等. 一种具有容错功能的多桥臂开关功放电路[J]. 中国电机工程学报, 2024, 44(20): 8279-8292.
Liu Chengzi, Jia Liyan, Yang Yan, et al.A multi-leg switch power amplifier circuit with fault-tolerance function[J]. Proceedings of the CSEE, 2024, 44(20): 8279-8292.
[22] 张德魁, 赵雷, 赵鸿宾. 电流响应速度及力响应速度对磁轴承系统性能的影响[J]. 清华大学学报(自然科学版), 2001, 41(6): 23-26.
Zhang Dekui, Zhao Lei, Zhao Hongbin.Effect of current response rate and force response rate on performance of magnetic bearing systems[J]. Journal of Tsinghua University (Science and Technology), 2001, 41(6): 23-26.
[23] Zhang Hongcai, Tian Kanli, Chen Chen, et al.A high voltage high power switching power amplifier[C]// 2023 IEEE 5th International Conference on Power, Intelligent Computing and Systems (ICPICS), Shenyang, China, 2023: 234-239.
[24] 程炜超, 谢振宇, 张云聪, 等. 重载磁悬浮轴承电控系统的研究[J]. 机电工程, 2019, 36(6): 562-567.
Cheng Weichao, Xie Zhenyu, Zhang Yuncong, et al.Electric control system of heavy-load magnetic bearing[J]. Journal of Mechanical & Electrical Engin- eering, 2019, 36(6): 562-567.