多模态超宽输出双LLC谐振变换器拓扑及控制策略

doi:10.19595/j.cnki.1000-6753.tces.242118

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (6644 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract LLC resonant converters have become a research hotspot in wide-voltage DC-DC converters with superior soft-switching characteristics, high efficiency, and high power density. Due to the wide switching operating frequency range and low overall efficiency, traditional LLC resonant converters are unsuitable for wide voltage gain applications. Designing an LLC resonant converter is imperative.
This paper proposes a variable-mode ultra-wide LLC resonant converter based on the topology reconfiguration concept, achieving an ultra-wide output voltage gain range of up to 121. By reconfiguring half-bridge/full-bridge circuits and full-bridge/voltage-doubler rectifiers, the converter contains four operating modes with different voltage gain ranges: series-connected half-bridges (SCHB), single half-bridge (SHB), dual half-bridge (DHB), and mixed bridge (MB). The converter’s efficiency is improved while the cost is reduced through the multiplexing of power devices. The equivalent circuits are presented for its four operating modes, and the operating stages and waveforms of the MB mode are analyzed. The voltage and current relationship equations in the MB mode are derived. Subsequently, the voltage-gain expressions for each operating mode are deduced, the voltage gain curve of the converter is plotted, and the voltage gain range is determined. The converter contains five power MOSFETs, and each can achieve zero voltage switching (ZVS) turn-on in all operating modes.
To further enhance the overall efficiency of the proposed converter under the operating conditions of a wide output voltage gain range, a hybrid control strategy tailored to this converter is proposed. The hybrid control strategy introduces pulse width modulation (PWM) based on the traditional pulse frequency modulation (PFM). The converter operates with PFM in SCHB, SHB, and DHB modes and PWM in MB mode. The converter determines the operating mode according to the load conditions and then determines the MOSFETs’ operating frequency and duty cycle. In practice, the converter must operate in a continuous gain range, and mode switching is required when the output voltage reaches the switching point. Considering the existence of ripple and jitter in the output voltage, adding a hysteresis loop comparison in the switching process is necessary. Adding PWM simplifies the design of the resonant parameters and minimizes the variations in output voltage gain caused by load changes.

Key words： LLC resonant converter variable-mode wide output voltage gain range dual-transformer

Received: 26 November 2024

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Zhang Juntao
	Lin Guoqing

Cite this article:

Zhang Juntao,Lin Guoqing. A Variable-Mode Ultra-Wide Output Voltage Gain Dual LLC Resonant Converter and Control Method[J]. Transactions of China Electrotechnical Society, 2025, 40(24): 8052-8065.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.242118 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I24/8052

[1] Chen Zhe, Guerrero J M, Blaabjerg F.A review of the state of the art of power electronics for wind turbines[J]. IEEE Transactions on Power Electronics, 2009, 24(8): 1859-1875.
[2] Yilmaz M, Krein P T.Review of battery charger topologies, charging power levels, and infrastructure for plug-in electric and hybrid vehicles[J]. IEEE Transactions on Power Electronics, 2013, 28(5): 2151-2169.
[3] Singh A K, Kumar S, Singh B.Solar PV energy generation system interfaced to three phase grid with improved power quality[J]. IEEE Transactions on Industrial Electronics, 2020, 67(5): 3798-3808.
[4] Williamson S, Lukic M, Emadi A.Comprehensive drive train efficiency analysis of hybrid electric and fuel cell vehicles based on motor-controller efficiency modeling[J]. IEEE Transactions on Power Electronics, 2006, 21(3): 730-740.
[5] 陈杰, 刘昌咏, 邓文明, 等. 四开关三电平半桥LLC变换器的控制策略与效率优化[J]. 电工技术学报, 2024, 39(24): 7833-7845.
Chen Jie, Liu Changyong, Deng Wenming, et al.Control strategy and efficiency optimization of four- switch three-level half-bridge LLC converter[J]. Transactions of China Electrotechnical Society, 2024, 39(24): 7833-7845.
[6] Sun Wenjin, Xing Yan, Wu Hongfei, et al.Modified high-efficiency LLC converters with two split resonant branches for wide input-voltage range applications[J]. IEEE Transactions on Power Electronics, 2018, 33(9): 7867-7879.
[7] Fang Xiang, Hu Haibing, Shen Z J, et al.Operation mode analysis and peak gain approximation of the LLC resonant converter[J]. IEEE Transactions on Power Electronics, 2011, 27(4): 1985-1995.
[8] Fang Xiang, Hu Haibing, Chen F, et al.Efficiency- oriented optimal design of the LLC resonant converter based on peak gain placement[J]. IEEE Transactions on Power Electronics, 2013, 28(5): 2285-2296.
[9] 周子航, 高祎韩, 刘懿静, 等. 基于平面磁元件的LLC变换器相关参数的整体优化设计方法[J]. 电工技术学报, 2024, 39(15): 4820-4829, 4895.
Zhou Zihang, Gao Yihan, Liu Yijing, et al.Parameters global optimization design method for LLC converter with planar magnetic[J]. Transactions of China Electrotechnical Society, 2024, 39(15): 4820-4829, 4895.
[10] 赵永秀, 刘泽伟, 王崇杰, 等. 变模态倍压型LLC谐振变换器多目标参数优化[J]. 电工技术学报, 2024, 39(22): 7139-7153.
Zhao Yongxiu, Liu Zewei, Wang Chongjie, et al.Multi objective parameter optimization of variable mode voltage doubling LLC resonant converter[J]. Transactions of China Electrotechnical Society, 2024, 39(22): 7139-7153.
[11] Sun Xiaofeng, Li Xiaohua, Shen Yanfeng, et al.Dual-bridge LLC resonant converter with fixed- frequency PWM control for wide input applications[J]. IEEE Transactions on Power Electronics, 2017, 32(1): 69-80.
[12] Shahzad M I, Iqbal S, Taib S.A wide output range HB-2LLC resonant converter with hybrid rectifier for PEV battery charging[J]. IEEE Transactions on Transportation Electrification, 2017, 3(2): 520-531.
[13] 吴西奇, 李睿, 蔡旭, 等. 一种新型宽电压增益直流充电模块拓扑及调制技术[J]. 中国电机工程学报, 2021, 41(23): 8129-8139.
Wu Xiqi, Li Rui, Cai Xu, et al.A new wide voltage gain DC charging module topology and modulation technology[J]. Proceedings of the CSEE, 2021, 41(23): 8129-8139.
[14] Zuo Yu, Pan Xuewei, Wang Can.A reconfigurable bidirectional isolated LLC resonant converter for ultra-wide voltage-gain range applications[J]. IEEE Transactions on Industrial Electronics, 2022, 69(6): 5713-5723.
[15] 李浩昱, 李振伟, 赵雷, 等. 宽输入LLC谐振变换器多电平控制策略[J]. 电工技术学报, 2017, 32(4): 48-57.
Li Haoyu, Li Zhenwei, Zhao Lei, et al.Multi-level control strategy of wide input LLC resonant converter[J]. Transactions of China Electrotechnical Society, 2017, 32(4): 48-57.
[16] 王暄, 王广柱, 孙晓伟, 等. 具有宽范围输出电压的三电平半桥LLC谐振变换器控制策略[J]. 电工技术学报, 2017, 32(21): 24-33.
Wang Xuan, Wang Guangzhu, Sun Xiaowei, et al.Research on control strategy of three-level half-bridge LLC resonant converter with wide output voltage range[J]. Transactions of China Electrotechnical Society, 2017, 32(21): 24-33.
[17] Shang Ming, Wang Haoyu.A voltage quadrupler rectifier based pulsewidth modulated LLC converter with wide output range[J]. IEEE Transactions on Industry Applications, 2018, 54(6): 6159-6168.
[18] 周国华, 邱森林, 张小兵. 宽增益高效率级联式四开关Buck-Boost LLC变换器[J]. 电工技术学报, 2024, 39(4): 1103-1115.
Zhou Guohua, Qiu Senlin, Zhang Xiaobing.Cascaded four-switch Buck-Boost LLC converter with wide gain range and high efficiency[J]. Transactions of China Electrotechnical Society, 2024, 39(4): 1103-1115.
[19] Wang Haoyu, Li Zhiqing.A PWM LLC type resonant converter adapted to wide output range in PEV charging applications[J]. IEEE Transactions on Power Electronics, 2018, 33(5): 3791-3801.
[20] Khan S, Sha Deshang, Jia Xiangshuai, et al.Resonant LLC DC-DC converter employing fixed switching frequency based on dual-transformer with wide input- voltage range[J]. IEEE Transactions on Power Electronics, 2020, 36(1): 607-616.
[21] 冯兴田, 邵康, 崔晓, 等. 基于多模态切换的宽电压增益LLC谐振变换器控制策略[J]. 电工技术学报, 2020, 35(20): 4350-4360.
Feng Xingtian, Shao Kang, Cui Xiao, et al.Control strategy of wide voltage gain LLC resonant converter based on multi-mode switching[J]. Transactions of China Electrotechnical Society, 2020, 35(20): 4350-4360.
[22] Zhao Qinglin, Zhang Jianmeng, Fu Chaowei, et al.A structure-reconfigurable LLC resonant converter with wide gain range[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2023, 11(4): 4057-4067.
[23] Li Cheng, Zhou Mingde, Wang Haoyu.An H5- bridge-based asymmetric LLC resonant converter with an ultrawide output voltage range[J]. IEEE Transactions on Industrial Electronics, 2019, 67(11): 9503-9514.
[24] 孙鑫宇, 邓宇豪, 聂江霖, 等. 一种超宽电压增益双LLC谐振变换器及控制方法[J]. 中国电机工程学报, 2024, 44(5): 1974-1985.
Sun Xinyu, Deng Yuhao, Nie Jianglin, et al.An ultrawide voltage gain dual LLC resonant converter and control method[J]. Proceedings of the CSEE, 2024, 44(5): 1974-1985.