一种恒流/恒压输出自切换的电场耦合式无线电能传输系统

doi:10.19595/j.cnki.1000-6753.tces.242269

Abstract
Figure/Table
References
Related Citation (7)

Download: PDF (7907 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Brushes and slip rings in rotary steerable systems are the main equipment for power transmission under rotational conditions to charge the batteries in steering control and measurement modules. However, this transmission method is prone to generating electrical sparks, potentially triggering safety risks. In addition, the wear and tear caused by long-term operation may lead to poor contact, resulting in unstable power transmission, which reduces the stability of the power supply in a rotary steerable system. Wireless power transfer (WPT) technology can address the issues of poor power supply safety and stability caused by traditional brushes and slip rings. The capacitive power transfer (CPT) system offers advantages such as low eddy current loss and strong resistance to electromagnetic interference. It is well-suited to withstand harsh conditions in the downhole.
The battery charging process typically includes two stages: constant current charging and constant voltage charging. Firstly, the charging is carried out in constant current mode, where the charging voltage rises rapidly as the equivalent load of the battery increases. Once the voltage reaches the rated value, it switches to constant voltage mode until the charging process is complete. This paper proposes a CPT system that automatically switches between constant current and voltage modes. The system achieves a smooth, automatic transition from constant current output to constant voltage output without additional active control while maintaining zero phase angle (ZPA) operation in both output modes.
The topology of the CPT system with automatic switching between constant current and constant voltage modes was presented. The electric field coupler adopted a single transmitter and dual receiver structure in the system. Therefore, the coupler’s voltage source equivalent model was established. Then, a decoupled secondary-side single-transmitter dual-receiver coupler model was designed based on physical parameter design to avoid mutual interference between the secondary side inputs. The system's output characteristics were theoretically analyzed. The system's output characteristics gradually transition from constant current output to constant voltage output as the load increases. The system maintains the ZPA state throughout the entire charging process.
Electromagnetic simulation of the electric field distribution of the coupler was conducted using the finite element method. The simulation results show that the leakage electric field generated by the coupler during system operation does not interfere with the normal operation of the instruments in the rotary steerable system. Then, a prototype was built. The experimental results indicate that the system can achieve a constant current output of 1.5 A and a constant voltage output of 60 V. The current fluctuation is less than 5% in the constant current output mode, the voltage fluctuation is less than 3% in the constant voltage output mode, and the maximum transmission efficiency is approximately 90% during system operation. These results meet the constant current and constant voltage requirements for battery charging.

Key words： Capacitive wireless power transfer rotary coupler constant current and constant voltage self- switching

Received: 17 December 2024

PACS:

TM724

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Ji Li
	Zhang Jiaqi
	Zhang Jianghong

Cite this article:

Ji Li,Zhang Jiaqi,Zhang Jianghong. A Capacitive Wireless Power Transfer System with Self-Adaptive Output Switching Between Constant Current and Constant Voltage[J]. Transactions of China Electrotechnical Society, 2025, 40(24): 7879-7890.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.242269 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I24/7879

[1] 贾亚辉, 王智慧, 肖静, 等. 磁耦合无线电能传输系统宽范围零电压开关实现方法[J]. 电工技术学报, 2024, 39(22): 6952-6964.
Jia Yahui, Wang Zhihui, Xiao Jing, et al.Imple- mentation method of wide range zero voltage switching in magnetic coupling wireless power transfer system[J]. Transactions of China Elec- trotechnical Society, 2024, 39(22): 6952-6964.
[2] 吉莉, 葛富辰, 张弛, 等. 基于电磁耦合结构的谐振屏蔽及抗偏移性能研究[J]. 电工电能新技术, 2023, 42(7): 68-76.
Ji Li, Ge Fuchen, Zhang Chi, et al.Research on resonance shielding and anti-misalignment per- formance based on electromagnetic coupling structure[J]. Advanced Technology of Electrical Engineering and Energy, 2023, 42(7): 68-76.
[3] 刘耀, 肖晋宇, 赵小令, 等. 无线电能传输技术发展与应用综述[J]. 电工电能新技术, 2023, 42(2): 48-67.
Liu Yao, Xiao Jinyu, Zhao Xiaoling, et al.Development and application review on wireless power transmission technology[J]. Advanced Tech- nology of Electrical Engineering and Energy, 2023, 42(2): 48-67.
[4] 张鑫, 杨帅鑫, 王文杰, 等. 电场耦合无人机无线电能传输系统轻量化抗偏无线输电耦合机构研究[J]. 电工技术学报, 2025, 40(14): 4343-4354.
Zhang Xin, Yang Shuaixin, Wang Wenjie, et al.Study on Lightweight Anti-Bias Wireless Transmission Coupling Mechanism for Electric Field Coupled UAV WPT System[J]. Transactions of China Electrote- chnical Society, 2025, 40(14): 4343-4354.
[5] 荣灿灿, 严俐慧, 路聪慧, 等. 基于超材料与超表面的无线电能传输技术研究现状与进展综述[J]. 电工技术学报, 2023, 38(20): 5369-5384.
Rong Cancan, Yan Lihui, Lu Conghui, et al.Over- view on research status and progress of wireless power transfer technology based on metamaterials and metasurfaces[J]. Transactions of China Electro- technical Society, 2023, 38(20): 5369-5384.
[6] 王得安, 张剑韬, 朱春波, 等. 海洋环境对水下无线电能传输系统的影响机理研究进展[J]. 电工技术学报, 2025, 40(3): 653-675.
Wang Dean, Zhang Jiantao, Zhu Chunbo, et al.Review of progress in the study of marine environment effects on underwater wireless power transfer systems[J]. Transactions of China Elec- trotechnical Society, 2025, 40(3): 653-675.
[7] 唐丁源, 周玮, 黄亮, 等. 具有恒压输出特性的电场耦合式动态无线电能传输技术[J]. 电工技术学报, 2023, 38(20): 5385-5397.
Tang Dingyuan, Zhou Wei, Huang Liang, et al.Dynamic electric-filed coupled wireless power transfer system with constant voltage output characteristics[J]. Transactions of China Electro- technical Society, 2023, 38(20): 5385-5397.
[8] Yang Lei, Feng Baoxiang, Zhang Yuanqi, et al.Single wire capacitive wireless power transfer system for wearable biomedical sensors based on flexible graphene film material[J]. IEEE Transactions on Biomedical Circuits and Systems, 2022, 16(6): 1337-1347.
[9] Chang Yufang, Zhang Xiaoke, Ma Chao, et al.A constant voltage/current CPT system with lightweight characteristics for the unmanned aerial vehicle[J]. IEEE Access, 2023, 12: 1737-1746.
[10] 苏玉刚, 檀竹斌, 胡宏晟, 等. 电场耦合电动车动态无线充电系统及耦合机构设计方法[J]. 中国电机工程学报, 2025, 45(4): 1599-1610.
Su Yugang, Tan Zhubin, Hu Hongsheng, et al.Electric-field coupled dynamic wireless charging system for electric vehicles and the design method of coupler[J]. Proceedings of the CSEE, 2025, 45(4): 1599-1610.
[11] 杨云虎, 贾维娜, 梁大壮, 等. LCC-LCC/S自切换恒流-恒压复合型无线电能传输系统[J]. 电工技术学报, 2023, 38(18): 4823-4837, 4852.
Yang Yunhu, Jia Weina, Liang Dazhuang, et al.A self-switching wireless power transfer system based on hybrid topology of LCC-LCC/S with constant current and constant voltage[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 4823-4837, 4852.
[12] 李中启, 张晨曦, 王建斌, 等. 基于变频重构S/SP拓扑的无线电能传输系统恒流恒压研究[J]. 电工技术学报, 2024, 39(15): 4718-4732.
Li Zhongqi, Zhang Chenxi, Wang Jianbin, et al.Research on constant current and constant voltage of WPT system based on variable frequency recon- figuration S/SP topology[J]. Transactions of China Electrotechnical Society, 2024, 39(15): 4718-4732.
[13] 苏玉刚, 颜志琼, 胡宏晟, 等. 基于频率切换实现恒流/恒压输出的电场耦合无线电能传输系统[J]. 中国电机工程学报, 2024, 44(4): 1553-1565.
Su Yugang, Yan Zhiqiong, Hu Hongsheng, et al.Electric-field coupled wireless power transfer system with constant current/constant voltage output characteri- stics based on frequency switching[J]. Proceedings of the CSEE, 2024, 44(4): 1553-1565.
[14] Zang Shaoge, Lu Kai, Nguang S K, et al.Robust- output feedback control of a rotary capacitive power transfer system[J]. IEEE Access, 2019, 7: 113452-113462.
[15] Lu Fei, Zhang Hua, Hofmann H, et al.A double-sided LC-compensation circuit for loosely coupled capa- citive power transfer[J]. IEEE Transactions on Power Electronics, 2018, 33(2): 1633-1643.
[16] 王卓, 牛小方, 杨明, 等. LCLC电场式无线电能传输的耦合分析与实验[J]. 电力电子技术, 2023, 57(11): 63-67.
Wang Zhuo, Niu Xiaofang, Yang Ming, et al.Coupling analysis and experiment of electric field wireless power transfer in bilateral LCLC[J]. Power Electronics, 2023, 57(11): 63-67.
[17] Wang Shiying, Liang Junrui, Fu Minfan.Analysis and design of capacitive power transfer systems based on induced voltage source model[J]. IEEE Transactions on Power Electronics, 2020, 35(10): 10532-10541.
[18] 苏玉刚, 谢诗云, 王智慧, 等. 基于F-F/T变结构谐振网络的恒压-恒流型电场耦合电能传输系统[J]. 电工技术学报, 2019, 34(6): 1127-1136.
Su Yugang, Xie Shiyun, Wang Zhihui, et al.An electric-field coupled power transfer system with constant voltage and constant current output based on F-F/T changeable resonant circuit[J]. Transactions of China Electrotechnical Society, 2019, 34(6): 1127-1136.
[19] 廖志娟, 周磊, 吴镇, 等. 变结构LC-CLCL拓扑恒压恒流型电场耦合电能传输系统[J]. 中国电机工程学报, 2021, 41(17): 6039-6049.
Liao Zhijuan, Zhou Lei, Wu Zhen, et al.An electric-field coupled power transfer system with constant voltage and constant current output based on changeable LC-CLCL resonant circuit[J]. Proceedings of the CSEE, 2021, 41(17): 6039-6049.
[20] Lian Jing, Qu Xiaohui.An LCLC-LC-compensated capacitive power transferred battery charger with near-unity power factor and configurable charging profile[J]. IEEE Transactions on Industry Appli- cations, 2022, 58(1): 1053-1060.
[21] Wu Xueying, Su Yugang, Hu A P, et al.A sleeve-type capacitive power transfer system with different coupling arrangements for rotary application[J]. IEEE Access, 2020, 8: 69148-69159.
[22] 周玮, 高侨, 陈泽林, 等. 基于同侧解耦型电场耦合机构的多发射多接收无线电能传输系统[J]. 电工技术学报, 2023, 38(18): 4811-4822.
Zhou Wei, Gao Qiao, Chen Zelin, et al.Same-sided decoupled electric-field coupler based wireless power transfer system with multi-transmitter and multi- receiver[J]. Transactions of China Electrotechnical Society, 2023, 38(18): 4811-4822.
[23] 周玮, 郑宇锋, 陈泽林, 等. 基于副边解耦极板的电容式无线电能传输系统拾取端失谐评估[J]. 电力系统自动化, 2024, 48(3): 142-149.
Zhou Wei, Zheng Yufeng, Chen Zelin, et al.Detuning estimation of pickup loop in capacitive wireless power transfer system based on secondary-side decoupled capacitive coupler[J]. Automation of Electric Power System, 2024, 48(3): 142-149.
[24] Ji Li, Ge Fuchen, Zhang Chi.Design of wireless power transmission coupling structure based on rotary steerable drilling[J]. IEEE Transactions on Power Electronics, 2023, DOI: 10.1109.TPEL.3023.3319577.
[25] 胡杰, 陈丽华, 罗博, 等. 基于全耦合电容模型的双发射电场耦合式无线电能传输系统[J]. 电工技术学报, 2019, 34(17): 3542-3551.
Hu Jie, Chen Lihua, Luo Bo, et al.Electric field coupled power transmission system with dual transmitting terminals based on full-capacitive coupling model[J]. Transactions of China Electro- technical Society, 2019, 34(17): 3542-3551.
[26] Wang Yao, Zhang Hua, Lu Fei.Review, analysis, and design of four basic CPT topologies and the application of high-order compensation networks[J]. IEEE Transactions on Power Electronics, 2022, 37(5): 6181-6193.
[27] Liu Yipeng, Wu Tao, Fu Minfan.Interleaved capacitive coupler for wireless power transfer[J]. IEEE Transactions on Power Electronics, 2021, 36(12): 13526-13535.
[28] Jia Jianbo, Jia Yahui, Li Xiaofei.Analysis, design, and experimental verification of a parallel wireless power and data transmission method for rotary steering systems[J]. Energies, 2022, 15(17): 6349.
[29] 张辉, 刘庆波, 底青云, 等. 井下非接触电能传输耦合器仿真与优化[J]. 地球物理学进展, 2022, 37(4): 1780-1788.
Zhang Hui, Liu Qingbo, Di Qingyun, et al.Simulation and optimization of downhole contactless power transmission coupler[J]. Progress in Geophysics, 2022, 37(4): 1780-1788.
[30] Wang Youzheng, Liu Hongchen, Yu Huiying, et al.A hybrid battery wireless charger for self-adapting battery charging curve and anti-misalignment[J]. IEEE Journal of Emerging and Selected Topics in Industrial Electronics, 2023, 4(4): 1192-1203.
[31] 钱林俊, 于博泉, 刘亚兵, 等. 具有抗偏移及漏电场屏蔽特性的UUV电场耦合无线电能传输系统[J/OL]. 电源学报, 1-13 [2025-02-05]. http://kns.cnki.net/kcms/detail/12.1420.TM.20231219.0952.004.html.
Qian Linjun, Yu Boquan, Liu Yabing, et al. Electric- filed coupled wireless power transfer system for UUV with anti-offset and leakage field shielding characteristics[J/OL]. Journal of Power Supply, 1-13 [2025-02-05]. http://kns.cnki.net/kcms/detail/12.1420.TM.20231219.0952.004.html.