一种基于差频无功理论的有源电容及其控制策略

doi:10.19595/j.cnki.1000-6753.tces.241630

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (3240 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Active capacitors have demonstrated good performance in filtering applications. However, the voltage and current fluctuations of energy storage components are constrained by the voltage and current ratings of the switching devices, limiting the storage capacity. It typically restricts their application to medium and low-power scenarios. This paper proposes an active capacitor based on differential-frequency reactive power. By synthesizing low-frequency reactive power from two high-frequency voltage signals with different frequencies, the proposed active capacitor increases the operating frequency of the passive components and enhances their reactive power absorption capability. Additionally, a dual-resonance impedance network is designed to overcome the limitations imposed by the voltage ratings of the switching devices on the storage power.
First, a high-frequency rotating voltage vector is generated using a three-phase bridge circuit, and the reactive power produced by this vector in the impedance network is analyzed. It is found that the high-frequency voltage not only generates high-frequency reactive power but also produces differential-frequency reactive power, with a frequency equal to the difference between the two voltage vectors. This differential-frequency reactive power is used to compensate for the second harmonic power of the inverter, enabling the conversion of low-frequency power into high-frequency processing. Secondly, an impedance network with dual resonance points is designed. Through resonance, the network eliminates high-frequency reactive power, retains differential-frequency reactive power, and amplifies the voltage and current amplitudes of the passive components, thereby improving the reactive power compensation capacity of the active capacitor. Moreover, the voltage stress on the switching devices is only related to the DC-side voltage, preventing the voltage rating limitations on storage power that are typically encountered with traditional active capacitors.
Regarding the control strategy, a perturb and observe (P&O) algorithm-based control method is employed. This method generates differential-frequency reactive power by constructing high-frequency signals to compensate for fluctuating power. The active capacitor's DC side's real-time voltage and current measurements are sampled. Based on the DC bus voltage fluctuations, the amplitude and phase of one high-frequency vector are adjusted, while the other high-frequency vector is fixed, simplifying the control process.
Simulation results show that when the DC-side voltage is 600 V and the second harmonic voltage ripple of the DC bus is 20 V, the proposed active capacitor effectively suppresses the ripple. After decoupling, the DC bus voltage ripple factor is reduced to less than 0.5%, and the voltage stress on the switching devices is only related to the DC voltage. As the target reactive power increases, the voltage and current fluctuations of the energy storage capacitor and inductor also increase. Additionally, a small-power experimental platform is set up. The active capacitor successfully suppressed the second harmonic voltage ripple of the DC bus to below 4 V.
In summary, the active capacitor based on differential-frequency reactive power offers the following advantages. (1) The energy storage capacitor operates at higher frequencies with positive and negative voltages, improving capacitor utilization and enabling smaller capacitors of the same type. (2) Resonance amplifies the voltage fluctuations of the energy storage capacitor, enhancing decoupling ability. (3) Decoupling the capacitor voltage fluctuations does not impact the switching devices, and the current in the branches is positively correlated with the decoupling power, reducing the voltage and current stress on the switches, which lowers system cost.

Key words： Active capacitor active power filtering single-phase inverter power decoupling double- frequency power pulsation

Received: 14 September 2024

PACS:

TM464

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Liu Peng
	Sheng Jiaying
	Zhang Yonggao

Cite this article:

Liu Peng,Sheng Jiaying,Zhang Yonggao. An Active Capacitor and Its Control Strategy Based on Differential Frequency Reactive Power Theory[J]. Transactions of China Electrotechnical Society, 2025, 40(20): 6644-6657.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.241630 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I20/6644

[1] 王立乔, 陈建医, 程超然, 等. 单级单相无电解电容Buck-Boost逆变器[J]. 电工技术学报, 2023, 38(24): 6768-6781.
Wang Liqiao, Chen Jianyi, Cheng Chaoran, et al.A single-stage single-phase Buck-Boost inverter without electrolytic capacitor[J]. Transactions of China Elec- trotechnical Society, 2023, 38(24): 6768-6781.
[2] 陈贺驰, 杨江朋, 张恒鹏, 等. 具有功率解耦功能的五开关共地逆变器[J]. 电工技术学报, 2024, https://doi.org/10.19595/j.cnki.1000-6753.tces.241343.
Chen Hechi,Yang Jiang peng, Zhang Hengpeng, et al. Five-switch common ground inverter with power decoupling function[J]. Transactions of China Elec- trotechnical Society, 2024, https://doi.org/10.19595/ j.cnki.1000-6753.tces.241343.
[3] Pang H M, Bryan P M H. A life prediction scheme for electrolytic capacitors in power converters without current sensor[C]//2010 Twenty-Fifth Annual IEEE Applied Power Electronics Conference and Expo- sition (APEC), Palm Springs, CA, 2010: 973-979.
[4] 杨洋, 阮新波, 叶志红. 无电解电容AC/DC LED驱动电源中减小输出电流脉动的前馈控制策略[J]. 中国电机工程学报, 2013, 33(21): 18-25, 189.
Yang Yang, Ruan Xinbo, Ye Zhihong.A feed-forward scheme to reduce output current ripple of an electrolytic capacitor-less AC/DC LED driver[J]. Proceedings of the CSEE, 2013, 33(21): 18-25, 189.
[5] 王立乔, 王海旭, 崔舒敏, 等. 串联型功率解耦型无电解电容PFC电路[J]. 中国电机工程学报, 2019, 39(17): 5195-5204, 5300.
Wang Liqiao, Wang Haixu, Cui Shumin, et al.A new series compensation control strategy of power factor corrector without electrolytic capacitor by power decoupling[J]. Proceedings of the CSEE, 2019, 39(17): 5195-5204, 5300.
[6] Ruan Xinbo, Wang Beibei, Yao Kai, et al.Optimum injected current harmonics to minimize peak-to- average ratio of LED current for electrolytic capacitor-less AC-DC drivers[J]. IEEE Transactions on Power Electronics, 2010, 26(7): 1820-1825.
[7] 勘匕凯, 阮新波, 冒小晶, 等. 减小DCM Boost PFC变换器储能电容的方法[J]. 电工技术学报, 2012, 27(1): 172-181.
Kan Bikai, Ruan Xinbo, Mao Xiaojing, et al.A method of reducing storage capacitor of DCM Boost PFC converter[J]. Transactions of China Electro- technical Society, 2012, 27(1): 172-181.
[8] 顾琳琳, 阮新波, 姚凯, 等. 采用谐波电流注入法减小储能电容容值[J]. 电工技术学报, 2010, 25(5): 142-148.
Gu Linlin, Ruan Xinbo, Yao Kai, et al.A harmonic current injection to reduce storage capacitance[J]. Transactions of China Electrotechnical Society, 2010, 25(5): 142-148.
[9] Wang Ruxi, Wang Fei, Boroyevich D, et al.A high power density single-phase PWM rectifier with active ripple energy storage[J]. IEEE Transactions on Power Electronics, 2010, 26(5): 1430-1443.
[10] Tang Yi, Blaabjerg F, Loh P C, et al.Decoupling of fluctuating power in single-phase systems through a symmetrical half-bridge circuit[J]. IEEE Transactions on Power Electronics, 2014, 30(4): 1855-1865.
[11] 王立乔, 崔舒敏, 陈梅. 功率解耦型无电解电容PFC电路并联补偿控制[J]. 电工技术学报, 2019, 34(3): 516-528.
Wang Liqiao, Cui Shumin, Chen Mei.Parallel com- pensation control of power factor corrector without electrolytic capacitor by power decoupling[J]. Transa- ctions of China Electrotechnical Society, 2019, 34(3): 516-528.
[12] Lin Jun, Weiss G.An indirect approach to control an active capacitor[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2020, 8(3): 2898-2906.
[13] 马兰, 曹晓琦, 张影, 等. 单相统一电能质量调节器二次纹波补偿及抑制策略[J]. 电工技术学报, 2024, 39(22): 7197-7212.
Ma Lan, Cao Xiaoqi, Zhang Ying, et al.Secondary ripple compensation and suppression strategy for single-phase unified power quality conditioner[J]. Transactions of China Electrotechnical Society, 2024, 39(22): 7197-7212.
[14] 刘永露, 袁银浩, 王辉, 等. 模块化解耦电路的协同控制策略[J]. 电工技术学报, 2024, 39(10): 3118-3128.
Liu Yonglu, Yuan Yinhao, Wang Hui, et al.Cooperative control strategy for modular decoupling circuits[J]. Transactions of China Electrotechnical Society, 2024, 39(10): 3118-3128.
[15] Cirrincione M, Pucci M, Vitale G.A single-phase DG generation unit with shunt active power filter capability by adaptive neural filtering[J]. IEEE Transactions on Industrial Electronics, 2008, 55(5): 2093-2110.
[16] Sharmeela C, Mohan M R, Uma G.Line harmonics reduction using neural based controller for shunt active filters[C]//TENCON 2003. Conference on Convergent Technologies for Asia-Pacific Region, Bangalore, India, 2003: 1554-1557.
[17] Cirrincione M, Pucci M, Vitale G, et al.Current harmonic compensation by a single-phase shunt active power filter controlled by adaptive neural filtering[J]. IEEE Transactions on Industrial Electronics, 2009, 56(8): 3128-3143.
[18] Patil D, Agarwal V.Compact onboard single-phase EV battery charger with novel low-frequency ripple compensator and optimum filter design[J]. IEEE Transactions on Vehicular Technology, 2016, 65(4): 1948-1956.
[19] Qin Shibin, Lei Yutian, Barth C, et al.A high power density series-stacked energy buffer for power pulsation decoupling in single-phase converters[J]. IEEE Transactions on Power Electronics, 2016, 32(6): 4905-4924.
[20] Wang Haoran, Liu Yang, Wang Huai.On the practical design of a two-terminal active capacitor[J]. IEEE Transactions on Power Electronics, 2019, 34(10): 10006-10020.
[21] Wang Huai, Chung H S, Liu Wenchao.Use of a series voltage compensator for reduction of the DC-link capacitance in a capacitor-supported system[J]. IEEE Transactions on Power Electronics, 2014, 29(3): 1163-1175.
[22] Saito M, Matsui N.Modeling and control strategy for a single-phase PWM rectifier using a single-phase instantaneous active/reactive power theory[C]//The 25th International Telecommunications Energy Con- ference, Yokohama, Japan, 2003: 573-578.
[23] Wang Ruxi, Wang F, Lai Rixin, et al.Study of energy storage capacitor reduction for single phase PWM rectifier[C]//2009 Twenty-Fourth Annual IEEE Applied Power Electronics Conference and Exposition, Washington, DC, USA, 2009: 1177-1183.
[24] Cao Xin, Zhong Qingchang, Ming Wenlong.Ripple eliminator to smooth DC-bus voltage and reduce the total capacitance required[J]. IEEE Transactions on Industrial Electronics, 2015, 62(4): 2224-2235.
[25] 李红波, 张凯, 赵晖. 高功率密度单相变换器的直流有源滤波器研究[J]. 中国电机工程学报, 2012, 32(15): 40-47.
Li Hongbo, Zhang Kai, Zhao Hui.Researches on DC active power filters for high power density single phase converters[J]. Proceedings of the CSEE, 2012, 32(15): 40-47.
[26] Huang Xinze, Ruan Xinbo, Fang Jie, et al.A virtual impedance based control scheme for modular electrolytic capacitor-less second harmonic current compensator[J]. IEEE Transactions on Industrial Electronics, 2021, 68(1): 198-209.
[27] Chen Minjie, Afridi K K, Perreault D J.Stacked switched capacitor energy buffer architecture[C]// 2012 Twenty-Seventh Annual IEEE Applied Power Electronics Conference and Exposition (APEC), Orlando, FL, USA, 2012: 1404-1413.
[28] Afridi K K, Chen Minjie, Perreault D J.Enhanced bipolar stacked switched capacitor energy buffers[J]. IEEE Transactions on Industry Applications, 2013, 50(2): 1141-1149.
[29] Lee Shenyang, Chen Yanglin, Chen Y M, et al.Development of the active capacitor for PFC con- verters[C]//2014 IEEE Energy Conversion Congress and Exposition (ECCE), Pittsburgh, PA, USA, 2014: 1522-1527.
[30] Huang Xinze, Ruan Xinbo, Du Fangjun, et al.A pulsed power supply adopting active capacitor converter for low-voltage and low-frequency pulsed loads[J]. IEEE Transactions on Power Electronics, 2018, 33(11): 9219-9230.
[31] 林国庆, 黄远彬. 两开关无电解电容LED驱动电路拓扑及控制策略[J]. 电工技术学报, 2024, 39(18): 5742-5754.
Lin Guoqing, Huang Yuanbin.Two-switch elec- trolytic capacitor-less LED driving circuit topology and control strategy[J]. Transactions of China Electrotechnical Society, 2024, 39(18): 5742-5754.
[32] 陈武, 王广江. 一种高功率因数无电解电容LED恒流驱动电源[J]. 电工技术学报, 2013, 28(11): 216-222.
Chen Wu, Wang Guangjiang.An electrolytic capacitor- less LED driver with high input power factor and constant output current[J]. Transactions of China Electrotechnical Society, 2013, 28(11): 216-222.