基于磁场调制理论的无轴承永磁薄片电机偏心不平衡磁拉力分析及其补偿

doi:10.19595/j.cnki.1000-6753.tces.240321

Abstract
Figure/Table
References
Related Citation (4)

Download: PDF (7636 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract Unbalanced magnetic pulling force significantly impacts the suspension performance of bearingless slice motors. Previous studies have overlooked the influence of stator slotting on an unbalanced magnetic pulling force, resulting in low model accuracy and average compensation effect. In addition, the existing models for analyzing the eccentric unbalanced magnetic pulling force of permanent magnet motors are unsuitable for bearingless permanent slice film motors that require high model accuracy. The existing models for bearingless permanent slice film motors do not consider the influence of stator slots, and the model accuracy is not high enough. Therefore, it is necessary to establish a high-precision analytical model that takes into account the influence of slotting to accurately analyze the unbalanced magnetic pulling force.
The radial displacement of the rotor of a bearingless permanent magnet slice film motor during suspension is not zero. The geometric center of the rotor fails to be concentric with the geometric center of the stator, resulting in eccentricity. Such eccentricity distorts the originally sinusoidal air gap magnetic field and produces harmonics, which become the main source of unbalanced magnetic pulling force in thin film motors. A small amount of unbalanced magnetic pulling force generated from machining errors and asymmetric sensor installation is neglected. Therefore, accurately analyzing the air gap magnetic field under eccentricity is the key to accurately analyzing the unbalanced magnetic pulling force of bearingless permanent magnet slice motors.
Combined with one-dimensional and two-dimensional analytical methods, this paper proposes an eccentric air gap magnetic field analysis method for bearingless slice film motors based on magnetic field modulation theory, considering the influence of stator slotting. The air gap magnetic permeability ratio measures the effect of slotting on the eccentric magnetic field of the motor, and the eccentric unbalanced magnetic pulling force is analyzed. Then, based on the theory of magnetic field modulation, the underlying mechanism of unbalanced magnetic pulling force is reanalyzed. It is proven that the model constructed in this paper has high accuracy and simple calculation. Finally, compensation experiments verify that precise compensation of unbalanced magnetic pulling force can greatly improve the suspension performance of bearingless slice motors.
The proposed unbalanced magnetic tension model has an error of about 0.5% in simulation, significantly improving the accuracy. When compensating for the unbalanced magnetic tension of a thin film motor, it can significantly improve the suspension performance of the motor and reduce displacement to 15 μm, suitable for heart pump thin film motors with extremely high suspension performance requirements.

Key words： Bearingless slice motor eccentric unbalanced magnetic pull magnetic field modulation effect the mechanism of unbalanced magnetic pull

Received: 01 March 2024

PACS:

TM461

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Wang Suo
	Wang Yu

Cite this article:

Wang Suo,Wang Yu. Analysis and Compensation of Eccentric Unbalanced Magnetic Pulling Force in Bearingless Permanent Magnet Slice Motors Based on Magnetic Field Modulation Theory[J]. Transactions of China Electrotechnical Society, 2025, 40(6): 1746-1757.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.240321 OR https://dgjsxb.ces-transaction.com/EN/Y2025/V40/I6/1746

[1] 王晓琳, 石滕瑞, 鲍旭聪. 基于频域拟合的无轴承永磁薄片电机径向悬浮力建模分析[J]. 电工技术学报, 2023, 38(2): 317-329.
Wang Xiaolin, Shi Tengrui, Bao Xucong.Accurate mathematical modeling of radial suspension force on bearingless permanent magnet slice motors based on frequency domain fitting[J]. Transactions of China Electrotechnical Society, 2023, 38(2): 317-329.
[2] 赵士豪, 陈进华, 张驰, 等. 不均匀气隙表贴式永磁同步电机磁场解析计算[J]. 电工技术学报, 2022, 37(14): 3502-3513.
Zhao Shihao, Chen Jinhua, Zhang Chi, et al.Analytical calculation of magnetic field of permanent magnet synchronous motor with uneven air gap structure[J]. Transactions of China Electrotechnical Society, 2022, 37(14): 3502-3513.
[3] Martin N, Natale B, Reto S.Bearinless centrifugal pump for highly pure chemicals[C]//8th International Symposium on Magentic Bearing, Mito, Japan, 2002: 283-288.
[4] 胡炳全, 陈盛奎, 潘俞丹. 体外膜肺氧合在高危重症冠心病患者介入治疗中的应用进展[J]. 现代医学与健康研究电子杂志, 2021, 7(24): 136-138.
Hu Bingquan, Chen Shengkui, Pan Yudan, et al.Pro- gress in the application of extracorporeal membrane oxygenation in interventional treatment of critically ill coronary heart disease patients[J]. Modern Medicine and Health Research, 2021, 7(24): 136-138.
[5] 张艺, 王宇, 张成糕. 基于霍尔负序解调法的无轴承永磁薄片电机径向位移检测方法[J]. 中国电机工程学报, 2023, 43(19): 7659-7668.
Zhang Yi, Wang Yu, Zhang Chenggao.Radical displacement detection method based on negative sequence demodulation method on hall signals of bearingless permanent magnet slice motor[J]. Pro- ceedings of the CSEE, 2023, 43(19): 7659-7668.
[6] Gerada D, Mebarki A, Brown N L, et al.High-speed electrical machines: technologies, trends, and developments[J]. IEEE Transactions on Industrial Electronics, 2014, 61(6): 2946-2959.
[7] 于丰源, 陈昊, 闫文举, 等. 宽窄定子极轴向磁通开关磁阻电机的设计与分析[J]. 电工技术学报, 2023, 38(5): 1261-1274.
Yu Fengyuan, Chen Hao, Yan Wenju, et al.Design and characteristic analysis of a wide-narrow stator poles axial flux switched reluctance machine[J]. Transactions of China Electrotechnical Society, 2023, 38(5): 1261-1274.
[8] 孙德博, 胡艳芳, 牛峰, 等. 开关磁阻电机调速系统故障诊断和容错控制方法研究现状及展望[J]. 电工技术学报, 2022, 37(9): 2211-2229.
Sun Debo, Hu Yanfang, Niu Feng, et al.Status and prospect of fault diagnosis and tolerant control methods for switched reluctance motor drive system[J]. Transactions of China Electrotechnical Society, 2022, 37(9): 2211-2229.
[9] 张业成, 刘国海, 陈前. 基于电流波动特征的永磁同步电机匝间短路与局部退磁故障分类诊断研究[J]. 电工技术学报, 2022, 37(7): 1634-1643, 1653.
Zhang Yecheng, Liu Guohai, Chen Qian.Dis- crimination of interturn short-circuit and local demagnetization in permanent magnet synchronous motor based on current fluctuation characteristics[J]. Transactions of China Electrotechnical Society, 2022, 37(7): 1634-1643, 1653.
[10] 邓文哲, 左曙光, 林福, 等. 偏心条件下轴向磁通轮毂电机不平衡弯矩建模与分析[J]. 电工技术学报, 2017, 32(13): 153-161.
Deng Wenzhe, Zuo Shuguang, Lin Fu, et al.Modeling and analysis of unbalanced moment for an axial-flux in-wheel motor with eccentricity[J]. Transactions of China Electrotechnical Society, 2017, 32(13): 153-161.
[11] Smith A C, Dorrell D G.Calculation and measure- ment of unbalanced magnetic pull in cage induction motors with eccentric rotors. part 1: analytical model[J]. IEE Proceedings-Electric Power Appli- cations, 1996, 143(3): 193.
[12] Dorrell D G, Hsieh M F, Guo Youguang.Unbalanced magnet pull in large brushless rare-earth permanent magnet motors with rotor eccentricity[J]. IEEE Transactions on Magnetics, 2009, 45(10): 4586-4589.
[13] Song J Y, Kang K J, Kang C H, et al.Cogging torque and unbalanced magnetic pull due to simultaneous existence of dynamic and static eccentricities and uneven magnetization in permanent magnet motors[J]. IEEE Transactions on Magnetics, 2017, 53(3): 8200609.
[14] Zhu Z Q, Wu L J, Xia Z P.An accurate subdomain model for magnetic field computation in slotted surface-mounted permanent-magnet machines[J]. IEEE Transactions on Magnetics, 2010, 46(4): 1100-1115.
[15] Zhu Z Q, Howe D, Bolte E, et al.Instantaneous magnetic field distribution in brushless permanent magnet DC motors. I. open-circuit field[J]. IEEE Transactions on Magnetics, 1993, 29(1): 124-135.
[16] Wu L J, Zhu Z Q, Staton D, et al.Subdomain model for predicting armature reaction field of surface- mounted permanent-magnet machines accounting for tooth-tips[J]. IEEE Transactions on Magnetics, 2011, 47(4): 812-822.
[17] Li Yanxin, Lu Qinfen, Zhu Ziqiang.Unbalanced magnetic force prediction in permanent magnet machines with rotor eccentricity by improved super- position method[J]. IET Electric Power Applications, 2017, 11(6): 1095-1104.
[18] Zhu Z Q, Wu L J, Mohd Jamil M L. Influence of pole and slot number combinations on cogging torque in permanent magnet machines with static and rotating eccentricities[C]//IEEE Energy Conversion Congress and Exposition, Denver, CO, USA, 2013: 2834-2841.
[19] Kim U, Lieu D K.Magnetic field calculation in permanent magnet motors with rotor eccentricity: with slotting effect considered[J]. IEEE Transactions on Magnetics, 1998, 34(4): 2253-2266.
[20] Zhou Yu, Li Huaishu, Meng Guangwei, et al.Analytical calculation of magnetic field and cogging torque in surface-mounted permanent-magnet machines accounting for any eccentric rotor shape[J]. IEEE Transactions on Industrial Electronics, 2015, 62(6): 3438-3447.
[21] 仇志坚, 李琛, 周晓燕, 等. 表贴式永磁电机转子偏心空载气隙磁场解析[J]. 电工技术学报, 2013, 28(3): 114-121.
Qiu Zhijian, Li Chen, Zhou Xiaoyan, et al.Analytical calculation of no-load air-gap magnetic field in surface-mounted permanent magnet motors with rotor eccentricity[J]. Transactions of China Electro- technical Society, 2013, 28(3): 114-121.
[22] 周晓燕, 李琛, 仇志坚, 等. 基于摄动法的交替极永磁电机偏心磁场解析计算[J]. 电工技术学报, 2013, 28(9): 321-331.
Zhou Xiaoyan, Li Chen, Qiu Zhijian, et al.Magnetic field calculation for consequent-pole motor with rotor eccentricity based on perturbation method[J]. Transactions of China Electrotechnical Society, 2013, 28(9): 321-331.
[23] 吴海同. 磁悬浮高速永磁电机偏心不平衡分析与补偿研究[D]. 南京: 南京航空航天大学, 2020.
Wu Haitong.Analysis and compensation research on eccentricity and unbalance of magnetic suspension high speed permanent magnet motors[D]. Nanjing: Nanjing University of Aeronautics and Astronautics, 2020.
[24] Cheng Ming, Han Peng, Hua Wei.General airgap field modulation theory for electrical machines[J]. IEEE Transactions on Industrial Electronics, 2017, 64(8): 6063-6074.
[25] Cheng Ming, Wen Honghui, Han Peng, et al.Analysis of airgap field modulation principle of simple salient poles[J]. IEEE Transactions on Industrial Electronics, 2019, 66(4): 2628-2638.
[26] 于吉坤, 李立毅, 张江鹏, 等. 定子开槽永磁同步电机气隙比磁导解析计算[J]. 电工技术学报, 2016, 31(增刊1): 45-52.
Yu Jikun, Li Liyi, Zhang Jiangpeng, et al.Analytical calculation of air-gap relative permeance in slotted permanent magnet synchronous motor[J]. Transa- ctions of China Electrotechnical Society, 2016, 31(S1): 45-52.