Abstract：The traditional zero-voltage-switch(ZVS) full-bridge(FB) converter owns two typical defects: one is that the load arrange is narrow for lagging leg to achieve ZVS and the other is that there is obvious voltage overshoot,voltage shock and loss of duty cycle exists on the transformer secondary side. In this paper,a passive auxiliary circuit and a non-dissipative buffer circuit based on phase-shift control are utilized to solve problems mentioned above. Furthermore,the paper also specifically analyzes the principle,operation modes and the necessary condition of soft switching. In order to verify the function of this novel DC-DC ZVS converter,an experimental prototype of 24V/3A,100kHz was built up. Experimental results prove that the converter can achieve ZVS at a wide load range and improve the performance of this novel converter effectively.
孙铁成，郭超，娜仁图亚，孙航，申宏伟. 具有移相控制的ZVS全桥DC-DC斩波变换器[J]. 电工技术学报, 2014, 29(12): 66-72.
Sun Tiecheng,Guo Chao,Naren Tuya,Sun Hang,Shen Hongwei. A Novel DC-DC ZVS Full-Bridge Converter Based on Phase-Shift Control. Transactions of China Electrotechnical Society, 2014, 29(12): 66-72.
[1] 陈武,阮新波,张容荣. 加复位绕组的零电压开关PWM全桥变换器[J]. 电工技术学报,2007,22(11): 117-124. Chen Wu,Ruan Xinbo,Zhang Rongrong. ZVS PWM full-bridge converter with reset winding[J]. Transactions of China Electrotechnical Society,2007,22(11): 117-124. [2] Kato H,Matsuo H,Ito T,et al. Comparative analysis of full bridge and half bridge current resonant DC-DC converter[C]. Telecommunications Energy Conference (INTELEC),2011: 1-6. [3] 刘科麟,刘布民. 一种新型的零电压零电流三电平变换器的研究[J]. 现代电子技术,2012,35(16): 122-125. Liu Kelin,Liu Bumin. ZVZCS three-level converter with dual-side passive auxiliary net[J]. Modern Electronics Technique,2012,35(16): 122-125. [4] Chen Yu,Pei Xuejun,Peng Li. A high-performance dual output DC-DC converter combined the phase shift full bridge and LLC resonant half bridge with the shared lagging leg[C]. Applied Power Electronics Conference and Exposition(APEC),2010: 1435-1440. [5] 王强. 新型软开关单Buck 逆变器[J]. 电力电子技术,2011,45(10): 73-75. Wang Qiang. A novel soft-switching single Buck inverter[J]. Power Electronics,2011,45(10): 73-75. [6] Lin B R,Chen J J,Chiang H K. Analysis of a new ZVS converter with output voltage doubler[J]. Interna- tional Journal of Electronics,2009,96(10): 1057- 1070. [7] Mishima T,Nakaoka M. Practical evaluation of a ZVS PWM DC-DC converter with secondary-side phase-shifting active rectifier[J]. IEEE Transactions on Power Electronics,2011,26(12): 3896-3907. [8] Agostini Jr. Eloi1,Barbi Ivo. A novel three-phase three-level ZVS PWM DC-DC converter[C]. 2009 Brazilian Power Electronics Conference,2009: 916- 924. [9] 孙铁成,邓云飞,刘策,等. 改进型倍流整流式ZVS三电平DC-DC变换器[J]. 电源学报,2011 (5): 25-31. Sun Tiecheng,Deng Yunfei,Liu Ce,et al. Improved current-double-rectifier ZVS three-level DC-DC converter[J]. Journal of Power Supply,2011(5): 25-31. [10] Li Peng,Li Wuhua,Zhao Yi,et al. ZVS three-level phase-shift high step-down DC/DC converter with two transformers[C]. Proceedings of the 2011 14th European Conference on Power Electronics and Applications,2011. [11] 张欣,陈武,阮新波. 一种辅助电流可控的移相全桥零电压开关PWM变换器[J]. 电工技术学报,2010,25(3): 81-88. Zhang Xin,Chen Wu,Ruan Xinbo. A novel ZVS PWM phase-shifted full-bridge converter with controlled auxiliary circuit[J]. Transactions of Electrotechnical Soiety,2010,25(3): 81-88. [12] 孙铁成,汤平华,孙亚秀. 基于DSP控制的新型全桥ZVS PWM DC-DC变换器[J]. 哈尔滨工业大学学报,2006,38(2): 184-187. Sun Tiecheng,Tang Pinghua,Sun Yaxiu. Novel full- bridge ZVS PWM DC-DC converter based on DSP control[J]. Journal of Harbin Institute of Technology,2006,38(2): 184-187. [13] Dai Yunzhong,Luo Renze,Ding Jialin,et al. New control technique of PWM rectifier based on DSP[C]. 2011 International Conference on Computational and Information Sciences,2011: 975-978. [14] Nie Songsong,Chen Yu,Pei Xuejun. A DSP-based diagnositc system for DC-DC converters using the shape of voltage across the magnetic components[C]. IEEE Energy Conversion Congress and Expositon,2010: 1908-1915.
2014, Vol. 29 
