五相永磁同步电机改进型无差拍直接转矩和磁链控制

doi:10.19595/j.cnki.1000-6753.tces.221730

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (3775 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract With the advantages of higher bus voltage utilization and more degrees of control freedom, multiphase permanent magnet synchronous motors (PMSMs) are widely used in electric vehicles, ship propulsion, and other fields. Direct torque control (DTC) and vector control (VC) are the most popular methods. Compared with VC, DTC needs two hysteresis comparators of stator flux linkage and torque and a switching table, which has a simple structure and fast dynamic response. However, traditional DTC has the disadvantages of large torque, flux linkage ripples, and high current harmonics. Model predictive torque control (MPTC) selects the optimal voltage vector from a control set according to the cost function to improve the torque and flux dynamic response. It has heavy computational burden and difficulty in tuning the weighting factor. Deadbeat direct torque and flux control (DB-DTFC) can eliminate the errors of torque and flux linkage within one sampling period by a voltage vector, which is obtained by discretizing the mathematical model. In addition, its control structure is simple, and it is unnecessary to adjust redundant parameters. However, there is a coupled relationship between torque and stator flux linkage. The traditional DB-DTFC has poor dynamic and steady-state performance. Therefore, an improved DB-DTFC strategy is proposed for five-phase PMSM.
Firstly, the PMSM model is discretized in the two-stationary frame, and a voltage vector is obtained from the relationship among stator voltage, torque, and stator flux linkage. Thus, the decoupling control of torque and stator flux linkage can be achieved. Secondly, current and flux linkage observers are built to compensate for delay and parameter disturbance in the digital control system. Finally, due to harmonic space in the five-phase PMSM, the space vector pulse width modulation (SVPWM) based on four non-zero vectors is designed to restrain the third harmonic current.
Experimental results of the traditional and improved DB-DTFC were tested at rated speed to evaluate the steady-state performance. Compared with the traditional DB-DTFC, the improved DB-DTFC can better suppress the torque and flux linkage ripples, the waveform of phase current is more sinusoidal, and the CPU execution time is shorter. Therefore, the voltage vector obtained by the improved DB-DTFC is more consistent with the deadbeat control goal, improving the stator flux and torque control accuracy and restraining current harmonics. Moreover, during dynamic experiments, the improved DB-DTFC has faster torque and speed responses, shorter adjustment time, and more dynamic response than the traditional DB-DTFC, ensuring the control accuracy of flux linkage.
The effectiveness of the proposed strategy is verified through theoretical analysis and experiments, and the following conclusions can be drawn. (1) Compared with the traditional DB-DTFC, the stator voltage of the method is much easier to obtain, thus requiring less computation. (2) The model of torque and flux linkage is accurate to achieve the decoupling control. The ripples are less at steady-state operation, thus improving the steady-state and dynamic performance. (3) Current and flux linkage observers are designed to eliminate the delay of digital control and to improve the parameter robustness. (4) SVPWM based on four non-zero vectors can effectively restrain the third harmonic current and reduce the distortion of phase current.

Key words： Deadbeat control direct torque and flux control (DTFC) permanent magnet synchronous motor (PMSM) delay compensation space vector pulse width modulation (SVPWM)

Received: 13 September 2022

PACS:

TM351

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Liu Guohai
	Sun Wenchao
	Zhou Huawei
	Liu Zhengmeng

Cite this article:

Liu Guohai,Sun Wenchao,Zhou Huawei等. An Improved Deadbeat Direct Torque and Flux Control Strategy of Five-Phase Permanent Magnet Synchronous Motor[J]. Transactions of China Electrotechnical Society, 2023, 38(24): 6658-6667.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.221730 OR https://dgjsxb.ces-transaction.com/EN/Y2023/V38/I24/6658

[1] Zhou Huawei, Xu Jinhui, Chen Cheng, et al.Disturbance-observer-based direct torque control of five-phase permanent magnet motor under open- circuit and short-circuit faults[J]. IEEE Transactions on Industrial Electronics, 2021, 68(12): 11907-11917.
[2] 王震宇, 孙伟, 蒋栋. 基于虚拟电压注入的闭环磁链观测器的感应电机无速度传感器矢量控制系统[J]. 电工技术学报, 2022, 37(2): 332-343.
Wang Zhenyu, Sun Wei, Jiang Dong.Induction motor speed sensorless vector control system based on closed-loop flux observer with virtual voltage injection[J]. Transactions of China Electrotechnical Society, 2022, 37(2): 332-343.
[3] 李修东, 郑晓钦, 王海峰, 等. 最大转矩范围内九相永磁同步电机缺相容错运行铜耗优化策略[J]. 电工技术学报, 2022, 37(17): 4355-4363.
Li Xiudong, Zheng Xiaoqin, Wang Haifeng, et al.Copper consumption optimization strategy of nine- phase permanent magnet synchronous motor under fault-tolerant operation in the maximum torque range[J]. Transactions of China Electrotechnical Society, 2022, 37(17): 4355-4363.
[4] 高宏伟, 杨贵杰, 刘剑. 3次谐波注入式五相永磁同步电机矢量控制策略[J]. 中国电机工程学报, 2014, 34(24): 4101-4108.
Gao Hongwei, Yang Guijie, Liu Jian.A vector control strategy for five-phase PMSM with third harmonic injection[J]. Proceedings of the CSEE, 2014, 34(24): 4101-4108.
[5] Li Jianhua, Du Bochao, Zhao Tianxu, et al.Current sensor fault-tolerant control for five-phase PMSM drives based on third-harmonic space[J]. IEEE Transactions on Industrial Electronics, 2022, 69(10): 9827-9837.
[6] 黄林森, 赵文祥, 吉敬华, 等. 稳态性能改善的双三相永磁电机直接转矩控制[J]. 电工技术学报, 2022, 37(2): 355-367.
Huang Linsen, Zhao Wenxiang, Ji Jinghua, et al.Direct torque control for dual three-phase permanent- magnet machine with improved steady-state perfor- mance[J]. Transactions of China Electrotechnical Society, 2022, 37(2): 355-367.
[7] 陈浩, 和阳, 赵文祥, 等. 基于占空比调制的五相容错永磁游标电机直接转矩控制[J]. 电工技术学报, 2020, 35(5): 1055-1064.
Chen Hao, He Yang, Zhao Wenxiang, et al.Direct torque control of five-phase fault-tolerant permanent magnet vernier motor based on duty cycle modu- lation[J]. Transactions of China Electrotechnical Society, 2020, 35(5): 1055-1064.
[8] Choi Y S, Choi H H, Jung J W.Feedback lineari- zation direct torque control with reduced torque and flux ripples for IPMSM drives[J]. IEEE Transactions on Power Electronics, 2016, 31(5): 3728-3737.
[9] 李祥林, 薛志伟, 阎学雨, 等. 基于电压矢量快速筛选的永磁同步电机三矢量模型预测转矩控制[J]. 电工技术学报, 2022, 37(7): 1666-1678.
Li Xianglin, Xue Zhiwei, Yan Xueyu, et al.Voltage vector rapid screening-based three-vector model predictive torque control for permanent magnet synchronous motor[J]. Transactions of China Elec- trotechnical Society, 2022, 37(7): 1666-1678.
[10] 赵勇, 黄文新, 林晓刚, 等. 基于权重系数消除和有限控制集优化的双三相永磁容错电机快速预测直接转矩控制[J]. 电工技术学报, 2021, 36(1): 3-14.
Zhao Yong, Huang Wenxin, Lin Xiaogang, et al.Fast predictive direct torque control of dual three-phase permanent magnet fault tolerant machine based on weighting factor elimination and finite control set optimization[J]. Transactions of China Electro- technical Society, 2021, 36(1): 3-14.
[11] Huang Wentao, Hua Wei, Fan Qigao.Performance analysis and comparison of two fault-tolerant model predictive control methods for five-phase PMSM drives[J]. CES Transactions on Electrical Machines and Systems, 2021, 5(4): 311-320.
[12] Wang Wusen, Liu Chunhua, Zhao Hang, et al.Improved deadbeat-direct torque and flux control for PMSM with less computation and enhanced robustness[J]. IEEE Transactions on Industrial Electronics, 2023, 70(3): 2254-2263.
[13] Lee J S, Choi C H, Seok J K, et al.Deadbeat-direct torque and flux control of interior permanent magnet synchronous machines with discrete time stator current and stator flux linkage observer[J]. IEEE Transactions on Industry Applications, 2011, 47(4): 1749-1758.
[14] Lee J S, Lorenz R D.Deadbeat-direct torque and flux control of IPMSM drives using a minimum time ramp trajectory method at voltage and current limits[C]// 2013 IEEE Energy Conversion Congress and Expo- sition, Denver, CO, USA, 2013: 1778-1785.
[15] Lin Xiaogang, Huang Wenxin, Jiang Wen, et al.Deadbeat direct torque and flux control for permanent magnet synchronous motor based on stator flux oriented[J]. IEEE Transactions on Power Electronics, 2020, 35(5): 5078-5092.
[16] 刘国海, 刘凯旋, 周华伟, 等. 基于定子磁链定向的五相PMSM新型无差拍直接转矩和磁链控制[J]. 中国电机工程学报, 2022, 42(16): 6073-6082, 6181.
Liu Guohai, Liu Kaixuan, Zhou Huawei, et al.Novel deadbeat direct torque and flux control of five-phase PMSM based on stator flux orientation[J]. Pro- ceedings of the CSEE, 2022, 42(16): 6073-6082, 6181.
[17] 秦艳忠, 阎彦, 陈炜, 等. 永磁同步电机参数误差补偿-三矢量模型预测电流控制[J]. 电工技术学报, 2020, 35(2): 255-265.
Qin Yanzhong, Yan Yan, Chen Wei, et al.Three- vector model predictive current control strategy for permanent magnet synchronous motor drives with parameter error compensation[J]. Transactions of China Electrotechnical Society, 2020, 35(2): 255-265.
[18] 章回炫, 范涛, 边元均, 等. 永磁同步电机高性能电流预测控制[J]. 电工技术学报, 2022, 37(17): 4335-4345.
Zhang Huixuan, Fan Tao, Bian Yuanjun, et al.Predictive current control strategy of permanent magnet synchronous motors with high performance[J]. Transactions of China Electrotechnical Society, 2022, 37(17): 4335-4345.
[19] Zuo Yuefei, Mei Jie, Jiang Chaoqiang, et al.Digital implementation of deadbeat-direct torque and flux control for permanent magnet synchronous machines in the M-T reference frame[J]. IEEE Transactions on Power Electronics, 2021, 36(4): 4610-4621.
[20] 薛诚, 宋文胜, 冯晓云. 五相永磁同步电机多目标优化直接转矩控制算法[J]. 中国电机工程学报, 2016, 36(6): 1695-1704.
Xue Cheng, Song Wensheng, Feng Xiaoyun.A direct torque control algorithm of five-phase permanent- magnet machines with multi-objective optimization[J]. Proceedings of the CSEE, 2016, 36(6): 1695-1704.
[21] Suhel S M, Maurya R.A new switching sequences of SVPWM for six-phase induction motor with features of reduced switching losses[J]. CES Transactions on Electrical Machines and Systems, 2021, 5(2): 100-107.
[22] 朱琳, 卜飞飞, 黄文新, 等. 五相逆变器非正弦双随机空间矢量脉宽调制策略[J]. 电工技术学报, 2018, 33(20): 4824-4833.
Zhu Lin, Bu Feifei, Huang Wenxin, et al.Non- sinusoidal dual random space vector pulse width modulation strategy for five-phase inverter[J]. Transactions of China Electrotechnical Society, 2018, 33(20): 4824-4833.