基于开关电容和三绕组耦合电感的高电压增益DC-DC变换器

doi:10.19595/j.cnki.1000-6753.tces.191004

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (2360 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract In this paper, a DC-DC converter with high voltage gain and soft-switching characteristics is proposed, which combines switched-capacitor network and three-winding coupled inductor. The proposed converter can achieve the voltage regulation ability by PWM technique, and the high voltage gain without an extreme duty cycle. The introduction of couple inductor can help to reduce the number of diodes and capacitors, leading to the reduction in the conduction losses and the cost of the converter. The voltage stresses of all semiconductor devices are at low level, and low voltage rating devices with better performance can be employed to reduce the conduction losses significantly. All the active switches can realize zero-voltage switching (ZVS) turn-on. Some of the diodes can achieve zero-current switching (ZCS) turn-off, and the turn-off di/dt rates of the other diodes are controlled by the leakage inductance of the coupled inductor, so the reverse recovery problems of all diodes are alleviated effectively. Therefore, the proposed converter has the potential to further improve the efficiency of the high step-up converter. The operation principle, voltage gain characteristic, device voltage stresses, input current ripple, and soft-switching conditions were analyzed in detail. Finally, the theoretical analysis was verified by a 600W prototype converter with 25~40V input and 400V output.

Key words： High voltage gain switched-capacitor coupled inductor soft-switching DC-DC converter

Received: 08 August 2019

PACS:

TM46

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Lei Haodong
	Hao Ruixiang
	You Xiaojie
	Li Fang

Cite this article:

Lei Haodong,Hao Ruixiang,You Xiaojie等. High Voltage Gain DC-DC Converter With Switched-Capacitor and Three-Winding Coupled Inductor[J]. Transactions of China Electrotechnical Society, 2020, 35(17): 3666-3677.

URL:

https://dgjsxb.ces-transaction.com/EN/10.19595/j.cnki.1000-6753.tces.191004 OR https://dgjsxb.ces-transaction.com/EN/Y2020/V35/I17/3666

[1] Blaabjerg F, Chen Zhe, Kjaer S B.Power electronics as efficient interface in dispersed power generation systems[J]. IEEE Transactions on Power Electronics, 2004, 19(5): 1184-1194.
[2] Meneses D, Blaabjerg F, García Ó, et al.Review and comparison of step-up transformerless topologies for photovoltaic AC-module application[J]. IEEE Transactions on Power Electronics, 2013, 28(6): 2649-2663.
[3] Lai J S, Ellis M W.Fuel cell power systems and applications[J]. Proceedings of the IEEE, 2017, 105(11): 2166-2190.
[4] Dong Dong, Cvetkovic I, Boroyevich D, et al.Grid-interface bidirectional converter for residential DC distribution systems-part one: high-density two-stage topology[J]. IEEE Transactions on Power Electronics, 2013, 28(4): 1655-1666.
[5] Li Wuhua, He Xiangning.Review of nonisolated high-step-up DC/DC converters in photovoltaic grid-connected applications[J]. IEEE Transactions on Industrial Electronics, 2011, 58(4): 1239-1250.
[6] Forouzesh M, Siwakoti Y P, Gorji S A, et al.Step-up DC-DC converters: a comprehensive review of voltage-boosting techniques, topologies, and applications[J]. IEEE Transactions on Power Electronics, 2017, 32(12): 9143-9178.
[7] Gu Bin, Dominic J, Chen Baifeng, et al.Hybrid transformer ZVS/ZCS DC-DC converter with optimized magnetics and improved power devices utilization for photovoltaic module applications[J]. IEEE Transactions on Power Electronics, 2015, 30(4): 2127-2136.
[8] Esram T, Chapman P L.Comparison of photovoltaic array maximum power point tracking techniques[J]. IEEE Transactions on Energy Conversion, 2007, 22(2): 439-449.
[9] Watson R, Lee F C, Hua G C.Utilization of an active-clamp circuit to achieve soft switching in flyback converters[J]. IEEE Transactions on Power Electronics, 1996, 11(1): 162-169.
[10] Wu T F, Lai Y S, Hung J C, et al.Boost converter with coupled inductors and Buck-Boost type of active clamp[J]. IEEE Transactions on Industrial Electronics, 2008, 55(1): 154-162.
[11] Zhao Qun, Lee F C.High performance coupled- inductor DC-DC converters[C]//Eighteenth Annual IEEE Applied Power Electronics Conference and Exposition, Miami Beach, FL, USA, 2003: 109-113.
[12] Tseng K C, Liang T J.Novel high-efficiency step-up converter[J]. IEE Proceedings-Electric Power Applications, 2004, 151(2): 182-190.
[13] Tseng K C, Huang C C.High step-up high-efficiency interleaved converter with voltage multiplier module for renewable energy system[J]. IEEE Transactions on Industrial Electronics, 2014, 61(3): 1311-1319.
[14] 吴琨, 钱挺. 一种带三绕组耦合电感的级联型高增益功率变换器[J]. 电工技术学报, 2017, 32(20): 124-132.
Wu Kun, Qian Ting.A cascaded high step-up DC-DC converter with three-winding coupled inductor[J]. Transactions of China Electrotechnical Society, 2017, 32(20): 124-132.
[15] 林雪凤, 许建平, 周翔. 谐振软开关耦合电感高增益DC-DC变换器[J]. 电工技术学报, 2019, 34(4): 747-755.
Lin Xuefeng, Xu Jianping, Zhou Xiang.Soft- switched high step-up DC-DC converter with coupled inductor of resonance[J]. Transactions of China Electrotechnical Society, 2019, 34(4): 747-755.
[16] Li Wuhua, Zhao Yi, Wu Jiande, et al.Interleaved high step-up converter with winding-cross-coupled inductors and voltage multiplier cells[J]. IEEE Transactions on Power Electronics, 2012, 27(1): 133-143.
[17] Zhao Yi, Li Wuhua, He Xiangning.Single-phase improved active clamp coupled-inductor-based converter with extended voltage doubler cell[J]. IEEE Transactions on Power Electronics, 2012, 27(6): 2869-2878.
[18] Li Wuhua, Li Weichen, Xiang Xin, et al.High step-up interleaved converter with built-in transformer voltage multiplier cells for sustainable energy applications[J]. IEEE Transactions on Power Electronics, 2014, 29(6): 2829-2836.
[19] Forouzesh M, Shen Yanfeng, Yari K, et al.High- efficiency high step-up DC-DC converter with dual coupled inductors for grid-connected photovoltaic systems[J]. IEEE Transactions on Power Electronics, 2018, 33(7): 5967-5982.
[20] Sanders S R, Alon E, Le H P, et al.The road to fully integrated DC-DC conversion via the switched- capacitor approach[J]. IEEE Transactions on Power Electronics, 2013, 28(9): 4146-4155.
[21] Schaef C, Rentmeister J, Stauth J T.Multimode operation of resonant and hybrid switched-capacitor topologies[J]. IEEE Transactions on Power Electronics, 2018, 33(12): 10512-10523.
[22] 薛利坤, 王萍, 王议锋, 等. 基于开关电容和耦合电感的交错并联型高电压增益双向DC-DC变换器[J]. 电工技术学报, 2016, 31(24): 181-187,194.
Xue Likun, Wang Ping, Wang Yifeng, et al.Interleaved high gain bidirectional DC-DC converter with switched capacitor and coupled inductor[J]. Transactions of China Electrotechnical Society, 2016, 31(24): 181-187,194.
[23] Ben-Yaakov S.Behavioral average modeling and equivalent circuit simulation of switched capacitors converters[J]. IEEE Transactions on Power Electronics, 2012, 27(2): 632-636.
[24] Law K K, Cheng K W E, Yeung Y P B. Design and analysis of switched-capacitor-based step-up resonant converters[J]. IEEE Transactions on Circuits and Systems-I: Regular Papers, 2005, 52(5): 943-948.
[25] Vasić M, Serrano D, Toral V, et al.Ultraefficient voltage doubler based on a GaN resonant switched-capacitor converter[J]. IEEE Journal of Emerging and Selected Topics in Power Electronics, 2019, 7(2): 622-635.
[26] Ioinovici A, Tse C K, Chung H S H. Comments on “Design and analysis of switched-capacitor-based step-up resonant converters”[J]. IEEE Transactions on Circuits and Systems-I: Regular Papers, 2006, 53(6): 1403.
[27] Abutbul O, Gherlitz A, Berkovich Y, et al.Step-up switching-mode converter with high voltage gain using a switched-capacitor circuit[J]. IEEE Transactions on Circuits and Systems-I: Fundamental Theory and Applications, 2003, 50(8): 1098-1102.
[28] Rosas-Caro J C, Ramirez J M, Peng F Z, et al. A DC-DC multilevel Boost converter[J]. IET Power Electronics, 2010, 3(1): 129-137.
[29] Prabhala V A K, Fajri P, Gouribhatla V S P, et al. A DC-DC converter with high voltage gain and two input boost stages[J]. IEEE Transactions on Power Electronics, 2016, 31(6): 4206-4215.
[30] Lei Yutian, May R, Pilawa-Podgurski R.Split-phase control: achieving complete soft-charging operation of a Dickson switched-capacitor converter[J]. IEEE Transactions on Power Electronics, 2016, 31(1): 770-782.
[31] 雷浩东, 郝瑞祥, 游小杰, 等. 基于开关电容的软开关高电压增益DC-DC变换器[J]. 电工技术学报, 2018, 33(12): 2821-2830.
Lei Haodong, Hao Ruixiang, You Xiaojie, et al.Soft-switching high voltage gain DC-DC converter based on switched-capacitor[J]. Transactions of China Electrotechnical Society, 2018, 33(12): 2821-2830.