|
|
|
| Capacitor Clamp ZVS Flyback Converter with Synchronous Rectifier |
| Lin Hai, Zhao Rongrong, Zhang Junming, Huang Xiucheng, Qian Zhaoming |
| Zhejiang University, Hangzhou 310027 China |
|
|
|
|
Abstract To further improve the efficiency of a flyback converter, a novel flyback converter with synchronous rectifier (SR) and its related control scheme are proposed in this paper. Due to the bidirectional current flow capability of the SR, the transformer leakage energy can be recycled by paralleling lossless snubber capacitor between the drain and source of the primary switch, and the primary side switch can also be soft switched. Therefore, the switching loss and the leakage energy loss can be reduced, and high conversion efficiency can be achieved in the whole load range. The experimental results from a 16V/4A prototype verify the effectiveness of the proposed method.
|
|
Received: 13 April 2013
Published: 27 June 2014
|
|
|
|
|
|
[1] ENERGY STAR, Single Voltage External AC-DC and AC-AC Power Supplies[S].
[2] Zhang J M, Huang X C, Wu X K, et al. A high efficiency flyback converter with new active clamp technique[J]. IEEE Transactions on Power Electronics, 2010, 25(7): 1775-1785.
[3] 刘树林, 曹晓生, 马一博. RCD钳位反激变换器的回馈能耗分析及设计考虑[J]. 中国电机工程学报, 2010, 30(33): 9-15.
Liu ShuLin, Cao Xiaosheng, Ma Yibo. Design and analysis on feedback energy loss of RCD clamping flyback converters[J]. Proceedings of the CSEE, 2010, 30(33): 9-15.
[4] Watson R, Lee F C, Hua G C. Utilization of an active-clamp circuit to achieve soft switching in flyback converters[J]. IEEE Transactions on Power Electronics, 1996, 11(1): 162-169.
[5] Lo Y K, Lin J Y. Active-clamping ZVS flyback converter employing two transformers[J]. IEEE Transactions on Power Electronics, 2007, 22(6): 2416-2423.
[6] Koo G B, Youn M J. A new zero voltage switching active clamp flyback converter[C]. Proceedings of IEEE Power Electronics Specialists Conference, 2004: 508-510.
[7] Liao C S, Smedley K M. Design of high efficiency flyback converter with energy regenerative Snubber [C]. Proceedings of IEEE Applied Power Electronics Conference, 2008: 796-800.
[8] Kim M, Jung Y. A novel soft-switching two-switch flyback converter with a wide operating range and regenerative clamping[J]. Journal of Power Electronics, 2009, 9(5): 772-780.
[9] Zhao S Y, Zhang J M. A low cost low power flyback converter with a simple transformer[C]. IEEE 2012 7th International Power Electronics and Motion Control Conference, 2012: 1336- 1342.
[10] Xie X F, Liu J C P, Poon F N K, et al. A novel high frequency current-driven synchronous rectifier applicable to most switching topologies[J]. IEEE Transactions on Power Electronics, 2001, 16(9): 635-648.
[11] Zhang J M, Xie X G, Jiao D Z, et al. A high efficiency adapter with novel current driven synchronous rectifier[C]. IEICE Transactions on Communications, 2004, E87-B(12): 3471-3477.
[12] Jitaru I D. High Efficiency flyback converter using synchronous rectification[C]. Proceedings of IEEE- APEC, Dallas, TX , USA, 2002, 2: 867-871.
[13] 梁永春, 孙林, 龚春英, 等. 同步整流反激逆变器研究[J]. 中国电机工程学报, 2006, 26(6): 95-99.
Liang Yongchun, Sun Lin, Gong Chunying, et al. Synchronous rectification approach for flyback inverter [J]．Proceedings of the CSEE, 2006, 26(6): 95-99.
[14] 成晶晶, 谢小高, 彭方正, 等. 基于准谐振及同步整流的反激变换器效率研究[J]. 电力电子技术, 2009, 43(3): 34-35, 44.
Cheng Jingjing, Xie Xiaogao, Peng Fangzheng, et al. Research on efficiency of quasi-resonant and synchronous rectification in flyback converters[J]. Power Electronics, 2009, 43(3): 34-55, 44.
[15] 谢小高, 张军明, 钱照明. 基于新型同步整流驱动方案的绿色电源[J]. 电力电子技术, 2007, 22(3): 96-101.
Xie Xiaogao, Zhang Junmin, Qian Zhaoming. A green Power supply based on a new synchronous rectification [J]. Power Electronics, 2007, 22(3): 96-101. |
|
|
|
2014, Vol. 29 
