基于定子磁链降阶状态观测的永磁同步电机无差拍直接转矩控制系统

Abstract
Figure/Table
References
Related Citation (15)

Download: PDF (2283 KB) HTML (1 KB)
Export: BibTeX | EndNote (RIS)

Abstract For the conventional direct torque control of permanent magnet synchronous motor, the flux and torque ripples are serious, and the inverter switching frequency is not constant. This paper proposes a deadbeat direct torque control scheme of permanent magnet synchronous motor. The error between the reference and actual flux amplitudes, and also the error between the reference and actual torques can be compensated accurately during a control cycle. So the flux and the torque can be controled in a deadbeat fashion. To solve this problem that permanent magnet synchronous motor direct torque control system requires the initial rotor position information to determine the initial value of the stator flux, the stator flux reduced order observer is constructed to eliminate the initial flux error. So the permanent magnet synchronous motor direct torque control system operation does not require the initial rotor position information. Finally a rotor speed identification method based on rotor flux is proposed, which is suitable for the deadbeat direct torque control algorithm and the stator flux reduced order observer. So the whole system can operate without any speed sensor.

Key words： Permanent magnet synchronous machine(PMSM) direct torque control(DTC) deadbeat control the stator flux reduced order observer speed identification

Received: 09 September 2013 Published: 17 June 2014

PACS:

TM351

	Service

	E-mail this article
	Add to my bookshelf
	Add to citation manager
	E-mail Alert
	RSS
	Articles by authors
	Wang Bin
	Wang Yue
	Guo Wei
	Wang Zhaoan

Cite this article:

Wang Bin,Wang Yue,Guo Wei等. Deadbeat Direct Torque Control of Permanent Magnet Synchronous Motor Based on Reduced Order Stator Flux Observer[J]. Transactions of China Electrotechnical Society, 2014, 29(3): 160-171.

URL:

http://dgjsxb.ces-transaction.com/EN/ OR http://dgjsxb.ces-transaction.com/EN/Y2014/V29/I3/160

[1] Zhong L, Rahman M F, Hu W Y, et al. Analysis of direct torque control in permanent magnet synchronous motor drives[J]. IEEE Transactions on Power Electronics, 1997, 12(3): 528-536.
[2] 田淳, 胡育文. 永磁同步电机直接转矩控制系统理论及控制方案的研究[J]. 电工技术学报, 2002, 17(1): 7-11.
Tian Chun, Hu Yuwen. Study of the scheme and theory of the direct torque control in permanent magnet synchronous motor drives[J]. Transactions of China Electrotechnical Society, 2002, 17(1): 7-11.
[3] 胡虎, 李永东. 基于区域电压矢量表的交流异步电动机直接转矩预测控制策略研究[J]. 电工技术学报, 2004, 19(2): 25-30.
Hu Hu, Li Yongdong. A predictive direct torque control strategies of induction motor based on area voltage vector table[J]. Transactions of China Electrotechnical Society, 2004, 19(2): 25-30.
[4] 李耀华, 刘卫国. 永磁同步电机直接转矩控制不合理转矩脉动抑制研究[J]. 西北工业大学学报, 2007, 25(5): 667-671.
Li Yaohua, Liu Weiguo. A method for suppressing unreasonable torque ripple in direct torque control of permanent magnet synchronous motor[J]. Journal of Northwestern Polytechnical University, 2007, 25(5): 667-671.
[5] 孙丹, 贺益康, 智大为. 基于模糊逻辑的永磁同步电动机直接转矩控制[J]. 电工技术学报, 2003, 18(1): 33-38.
Sun Dan, He Yikang, Zhi Dawei. Direct torque control of a permanent magnet synchronous motor based on fuzzy logic[J]. Transactions of China Electrotechnical Society, 2003, 18(1): 33-38.
[6] 刘军, 刘丁, 吴浦升, 等. 基于模糊控制调节电压矢量作用时间策略的永磁同步电机直接转矩控制仿真研究[J]. 中国电机工程学报, 2004, 24(10): 148-152.
Liu Jun, Liu Ding, Wu Pusheng, et a1. The simulation analysis of permanent magnet synchronous motor based on the strategy of modulating the time of voltage vector[J]. Proceedings of the CSEE, 2004 24(10): 148-152.
[7] 骆光照, 李斐, 杨南方, 等. 三电平逆变器供电永磁同步电机直接转矩控制研究[J]. 西北工业大学学报, 2012, 30(1): 22-26.
Luo Guangzhao, Li Fei, Yang Nanfang, et al. An efficient three-level inverter direct torque control (DTC) of permanent magnet synchronous motor (PMSM)[J]. Journal of Northwestern Polytechnical University, 2012, 30(1): 22-26.
[8] 刘述喜, 王明渝. 基于快速空间矢量调制算法的三电平直接转矩预测控制系统[J]. 电工技术学报, 2009, 24(2): 35-41.
Liu Shuxi, Wang Mingyu. Direct torque predictive control system supplied by three-level inverter based on a fast SVPWM algorithm[J]. Transactions of China Electrotechnical Society, 2009, 24(2): 35-41.
[9] Tang Lixin, Zhong Limin, Rahman M F, et a1. A novel direct torque controlled interior permanent magnet synchronous machine drive with low ripple in flux and torque and fixed switching frequency[J]. IEEE Transactions on Power Electronics, 2004, 19(2): 346-354.
[10] 刘军, 楚小刚, 白华煜. 基于参考磁链电压空间矢量调制策略的永磁同步电机直接转矩控制研究[J]. 电工技术学报, 2005, 20(6): 11-15.
Liu Jun, Chu Xiaogang, Bai Huayu. Study of permanent magnet synchronous motor direct torque control based on the strategy of reference stator flux linkage and voltage space vector modulation[J]. Transactions of China Electrotechnical Society, 2005, 20(6): 11-15.
[11] 孙丹, 贺益康. 基于恒定开关频率空间矢量调制的永磁同步电机直接转矩控制[J]. 中国电机工程学报, 2005, 25(12): 112-116.
Sun Dan, He Yikang. Space vector modulation based constant switching frequency direct torque control for permanent magnet synchronous motor[J]. Proceedings of the CSEE, 2005, 25(12): 112-116.
[12] 梁艳, 李永东. 无传感器永磁同步电机矢量控制中转子初始位置的估算方法[J]. 电工技术学报, 2003, 18(2): 10-13.
Liang Yan, Li Yongdong. Initial rotor position estimation for the sensorless vector control of PMSMs[J]. Transactions of China Electrotechnical Society, 2003, 18(2): 10-13.
[13] 秦峰, 贺益康, 刘毅, 等. 永磁同步电机转子位置的无传感器自检测[J]. 浙江大学学报(工学版), 2004, 38(4): 465-469.
Qin Feng, He Yikang, Liu Yi, et al. Rotor position sensorless estimation for permanent magnet synchronous motors[J]. Journal of Zhejiang University (Engineering Science), 2004, 38(4): 465-469.
[14] 廖勇, 沈朗, 姚骏, 等. 改进的面贴式永磁同步电机转子初始位置检测[J]. 电机与控制学报, 2009, 13(2): 203-207.
Liao Yong, Shen Lang, Yao Jun, et al. Initial rotor position detection for surface mounted PMSM based on rotating high frequency signal injection[J]. Electric Machines and Control, 2009, 13(2): 203-207.
[15] Consoli A, Scarcella G, Testa A. Industry application of zero-speed sensorless control techniques for PM synchronous motors[J]. IEEE Transactions on Industry Applications, 2001, 37(2): 513-521.
[16] 王子辉, 陆凯元, 叶云岳. 基于改进的脉冲电压注入永磁同步电机转子初始位置检测方法[J]. 中国电机工程学报, 2011, 31(36): 95-100.
Wang Zihui, Lu Kaiyuan, Ye Yunyue. Initial position estimation method for permanent magnet synchronous motor based on improved pulse voltage injection[J]. Proceedings of the CSEE, 2011, 31(36): 95-100.
[17] 韦鲲, 金辛海. 表面式永磁同步电机初始转子位置估计技术[J]. 中国电机工程学报, 2006, 26(22): 104-109.
Wei Kun, Jin Xinhai. Initial rotor position estimate technique on surface mounted permanent magnet synchronous motor[J]. Proceedings of the CSEE, 2006, 26(22): 104-109.
[18] 秦峰, 贺益康, 刘毅, 等. 两种高频信号注入法的无传感器运行研究[J]. 中国电机工程学报, 2005, 25(5): 116-120.
Qin Feng, He Yikang, Liu Yi, et al. Comparative investigation of sensorless control with two high- frequency signal injection schemes[J]. Proceedings of the CSEE, 2005, 25(5): 116-120.